Outbreak of Silicosis among Engineered Stone Countertop Workers in Four States
Posted on by![](https://blogs.cdc.gov/wp-content/uploads/sites/22/2019/10/Silica-infographic2-FINAL-508-791x1024.jpg)
Engineered stone countertops, also known as “quartz surfacing,” are made from quartz aggregate held together with a resin binder. These materials are similar in appearance to natural stone and have become increasingly popular for use in home building and home improvement. Quartz surface imports to the United States have increased approximately 800% during 2010–2018 (U.S. International Trade Commission). Engineered stone materials may contain substantially more crystalline silica than natural stone (>90%, compared with <45% in granite) (OSHA/NIOSH Hazard Alert). Tasks such as cutting, grinding, polishing, and drilling can release hazardous levels of silica dust into the air. Inhalation of dust from silica-containing materials, such as engineered stone, can lead to silicosis. Silicosis is a progressive, debilitating, incurable, and sometimes fatal disease that results from scarring of the lungs, causing permanent lung damage.
Exposure to silica dust is a health hazard for workers who manufacture, finish, and install natural and engineered stone countertop products. Symptoms of silicosis may include cough, fatigue, shortness of breath, or chest pain. Silicosis typically occurs after 10 or more years of exposure to respirable crystalline silica. However, high levels of exposure can lead to more rapid development and more severe lung disease. In addition to silicosis, breathing in very small (“respirable”) crystalline silica particles can cause lung cancer, chronic obstructive pulmonary disease (COPD), and kidney disease, and is associated with the development of lung infections, autoimmune disorders, and cardiovascular impairment.
One case of silicosis associated with engineered stone fabrication was previously reported in the United States from Texas (Friedman, 2015). More recently, 18 cases of silicosis, including two fatalities, have been identified among workers in the stone fabrication industry in California, Colorado, Washington, and Texas (Rose and Heinzerling, 2019). Many of these workers worked primarily with engineered stone materials and were less than 50 years of age. Outbreaks of silicosis have also been reported among engineered stone workers in Israel, Spain, and Australia (Kramer, 2012; Perez-Alonso, 2014; Hoy, 2018; Leso, 2019). Medical screening offered to all at-risk stone fabrication workers in Queensland, Australia, has identified silicosis among 12% of workers (Kirby, 2019). In 2018, there were nearly 9,000 establishments with 96,000 employees in the stone fabrication industry in the United States (Bureau of Labor Statistics quarterly census of employment and wages). As many of these employees probably have not undergone medical examinations, it is likely that additional cases of silicosis remain unidentified in the US.
Employers must ensure that workers are protected from exposure to crystalline silica. The federal Occupational Safety and Health Administration (OSHA) has issued two respirable crystalline silica standards to protect workers. The standards for construction (29 CFR 1926.1153) and for general industry and maritime (29 CFR 1910.1053) both took effect on June 23, 2016. Similar standards have also been implemented in state OSHA jurisdictions over the past few years. Employers must comply with the applicable federal or state OSHA standards to ensure that employee exposures, at a minimum, are not above the permissible exposure limit (PEL) for respirable crystalline silica of 50 micrograms per cubic meter of air (50 µg/m3), averaged over an 8-hour work day. More information on the final silica rule, requirements for employers, and specific implementation dates for federal OSHA can be found here.
Silicosis is preventable when exposure to respirable silica dust is minimized through effective engineering controls and work practices. Engineering controls such as wet methods and ventilation should be used to control exposure to dust. Work practice controls, including appropriate housekeeping procedures, can be used along with engineering controls to protect employees. NIOSH-approved respiratory protection should be provided to employees when silica dust levels are hazardous and where required by the silica rule. Respiratory protection is the least effective control measure.
Under the OSHA silica rule, engineered stone countertop workers exposed to hazardous levels of silica dust must be examined by a licensed healthcare provider. The examination must include a respiratory questionnaire, physical examination, chest X-ray interpreted by a NIOSH certified B reader, and spirometry. Healthcare providers who suspect that a patient’s health problems are caused by working with quartz-containing materials should report the case to their local or state health department. Additionally, physicians can direct questions about silicosis reporting to [email protected]. In 2017, silicosis was a reportable condition in 22 states (state Occupational Safety and Health contact information can be found here).
Hazard alerts published in California, Washington, and Texas provide information on silica dust exposure, requirements for controlling dust, and resources for exposed workers. A webinar describing the dangers of silica exposure, employer requirements to comply with OSHA’s Respirable Crystalline Silica Rule, and methods employers can use to protect workers is available here.
The NIOSH Health Hazard Evaluation (HHE) Program provides free assistance and information to employees, employee representatives, and employers on workplace silica exposures and employee health. More information about the NIOSH HHE program can be found at the NIOSH HHE Topic Page. If you are interested in working with NIOSH, employees, union officials, or employers can request an evaluation of possible health hazards at their workplace here.
This blog focuses on worker exposure to high levels of silica over time. We cannot provide individual medical advice and will not post comments related to potential exposures of the general public/consumers/homeowners. Contact your physician if you have concerns about your health.
This blog has been translated into Spanish.
Katelynn Dodd, MPH, is an Associate Service Fellow (Epidemiologist) at the NIOSH Respiratory Health Division.
Amy Heinzerling, MD, MPH, is an Epidemic Intelligence Service Officer with the Centers for Disease Control and Prevention, assigned to the California Department of Public Health.
Cecile Rose, MD, MPH, is a Professor of Medicine in the Division of Environmental and Occupational Health at National Jewish Health and in Pulmonary Medicine at the University of Colorado.
Carolyn Reeb-Whitaker, MS, CIH, is the Principal Investigator for Occupational Respiratory Disease Surveillance at the Safety & Health Assessment & Research for Prevention (SHARP) program at the Washington State Department of Labor & Industries.
Robert Harrison, MD, MPH, is Chief of the Occupational Health Surveillance and Evaluation Program at the California Department of Public Health and a Clinical Professor of Medicine at UC San Francisco.
The authors would like to thank Ketki Patel, MD, PhD, Senior Epidemiologist at the Texas Department of State Health Services.
References
Friedman GK, Harrison R, Bojes H, Worthington K, Filios M. Notes from the field: silicosis in a countertop fabricator — Texas, 2014. MMWR Morb Mortal Wkly Rep. 2015 Feb 13;64(5):129-30.
Hoy RF, Baird T, Hammerschlag G, Hart D, Johnson AR, King P, Putt M, Yates DH. Artificial stone-associated silicosis: a rapidl.y emerging occupational lung disease. Occup Environ Med. 2018 Jan;75(1):3-5.
Kirby T. Australia reports on audit of silicosis for stonecutters. Lancet. 2019 Mar 2;393(10174):861.
Kramer MR, Blanc PD, Fireman E, Amital A, Guber A, Rhahman NA, Shitrit D. Artificial stone silicosis: disease resurgence among artificial stone workers. Chest. 2012 Aug;142(2):419-24.
Leso V, Fontana L, Romano R, Gervetti P, Iavicoli I. Artificial stone associated silicosis: a systematic review. Int J Environ Res Public Health. 2019 Feb;16(4):E568.
Perez-Alonso A, Cordoba-Dona JA, Millares-Lorenzo JL, Figueroa-Murillo E, Garcia-Vadillo C, Romero-Morillo J. Outbreak of silicosis in Spanish quartz conglomerate workers. Int J Occup Environ Health. 2014 Mar;20(1):26-32.
Rose C, Heinzerling A, Patel K, Sack C, Wolff J, Zell-Baran L, Weissman D, Hall E, Sooriash R, McCarthy RB, Bojes H, Korotzer B, Flattery J, Weinberg J, Potocko J, Jones KD, Reeb-Whitaker CK, Reul NK, LaSee CR, Materna BL, Raghu G, Harrison R. Severe Silicosis in Engineered Stone Fabrication Workers — California, Colorado, Washington, and Texas, 2017–2019. MMWR Morb Mortal Wkly Report. September 27, 2019 / 68(38);813–818.
U.S. Occupational Safety and Health Administration; National Institute of Occupational Safety and Health, CDC. Hazard alert: worker exposure to silica during countertop manufacturing, finishing, and installation. 2015. Available from: https://www.osha.gov/Publications/OSHA3768.pdf.
United States International Trade Commission for Harmonized Tariff Schedule (HTS) code 6810.99.0010, Agglomerated quartz slabs of the type used for countertops. Available from: https://dataweb.usitc.gov/
3 comments on “Outbreak of Silicosis among Engineered Stone Countertop Workers in Four States”
Comments listed below are posted by individuals not associated with CDC, unless otherwise stated. These comments do not represent the official views of CDC, and CDC does not guarantee that any information posted by individuals on this site is correct, and disclaims any liability for any loss or damage resulting from reliance on any such information. Read more about our comment policy ».
Having quartz countertop in your home makes it look elegant and modern, but customers are not aware what it may cause to the workers who manufactures it. Even the workers I think are not aware of the effects of the silica dust on their health when they inhale it. At [company name removed] they are aware of this that’s why they see to it that all their workers are properly protected and oriented with the safety process in manufacturing this quartz countertops.
Thanks for sharing this article related to quartz worktops, keep posting more.
The outbreak of silicosis among engineered stone countertop workers is concerning. It’s crucial to ensure safety standards and proper precautions. [Company name removed] is committed to worker safety and provides high-quality, responsibly sourced materials. Let’s prioritize health and well-being together.