Professional Documents
Culture Documents
Quality Assessment of Unbranded Palm Oil Distributed in Five Local Markets in Port Harcourt, Rivers State Nigeria
Quality Assessment of Unbranded Palm Oil Distributed in Five Local Markets in Port Harcourt, Rivers State Nigeria
e-ISSN: 2319-2380, p-ISSN: 2319-2372. Volume 8, Issue 4 Ver. II (Apr. 2015), PP 27-32
www.iosrjournals.org
Absracts: The study was carried out to assess the microbiological and physicochemical characteristics of palm
oil sold in 5 major markets (Rumuokoro, Choba, Oil mill, Mile 1, Mile 3) within Port Harcourt metropolis. A
total of 50 samples were collected from the five different markets in sterile bottles. The bacterial and fungal
loads were obtained by standard plate count method and isolates were tentatively identified based on their
cultural, morphological and biochemical characteristics. Physicochemical parameters such as; free fatty acid
value, iodine value, peroxide value, relative density and pH values were also determined using standard
protocols. The mean Total heterotrophic bacterial count (THBC) ranged from 1.7010 9 to 9.0108 cfu/ml.
Samples from Oil mill market had the highest bacterial load and samples from the Mile 1 market had the least.
The mean value for lipid utilizing bacteria (LUB) ranged from 2.0107 to 9.0107 cfu/ml with Rumuokoro
market having the lowest and Oil mill having the highest value. The total heterotrophic fungal count (THFC)
ranged from 1.00106 to 8.60105 cfu/ml. Samples from the Mile 1 had the least fungal load and Samples from
Choba market had the highest fungal load. The total lipid utilizing fungal count ranged from 1.0105 to 8.0105
cfu/ml. Samples from Choba market had the least value and Rumuokoro market had highest fungal load. Total
coliform counts was; 7.0106cfu/100ml (Oil mill Market), 3.0105cfu/100ml ( Choba Market),
8.8106cfu/100ml (Mile 1 Market), 7.0106cfu/100ml( Mile 3 Market) and 4.0105cfu/100ml (Rumuokoro
Market). isolated microorganisms found to be in associated with the palm oil samples were Enterobacter sp,
Micrococcus sp, Pseudomonas sp, Klebsiella sp, Staphylococcus sp, Aspergillus niger, Aspergillus fumigatus ,
Fusarium sp and Mucor sp. Results obtained on the physicochemical quality of samples were as follows; Iodine
value wijis 16.98-16.86, Relative density (g) 0.939-0.874, Peroxide value(meq/kg) 19.94-19.87, free fatty acids
(mgKOH/g) 16.92-16.40 and pH 5.4-4.80. The bacterial load of palm oil samples from most of the markets and
physicochemical qualities were found to greatly exceed the stipulated maximum acceptable linits compared to
standards.
Keywords: Palm Oil, Unbranded, Microbial Load, Quality.
I. Introduction
Oil palm is a common name for ornamental and economically valuable palm tree, native to Western
Africa and widespread throughout the tropics. The oil palm and the American oil palm are members of the
family Arecaceae formerly known as Palmae. The oil palm is classified as Elaeis guineensis and the American
oil palm as Elaeis Oleifera.
The oil palm grows up to 9m (30ft) in height. It has a crown of feathery leaves that are up to 5m (15ft)
long. The flower clusters is on a short thick spike at the base of the leaves. Flowering is followed by the
development of a cluster of egg shaped, red, orange or yellowish fruits. Each fruit is approximately 3cm (1inch)
long and contains from one to three seeds embedded in a reddish pulp.
Palm oil is derived from the mesocarp of the fruits of West African oil palm (Elaeis guineensis) or of E.
Oleifera and E.odora which are natives of South America. The extracted oil contains a considerable proportion
of water as well as soil, fibre and debris Palm oils rich content of saturated and monounsaturated fatty acids has
actually been turned into an asset in view of current dietary recommendations. The use of palm oil in
combination with other oils and fats facilitates development of a new generation of fat products that can be
tailored to meet most current dietary recommendations (Sundram, 2003). Palm Vitamin E (30% tocopherols and
70% tocotrienols) has been extensively studied for its nutritional and health properties, including antioxidant
activities, cholesterol lowering, anti-cancer effects and protection against artherosclerosis. A relatively new output from the oil palm fruit is the water soluble phenolicflavonoid rich antioxidant complex, which has potent
antioxidant properties coupled with beneficial effects against skin, breast and other cancer. Its water solubility is
being currentlytested for use as nutraceutical and in cosmetics with potential benefits against skin aging
(Sundram, 2003).
DOI: 10.9790/2380-08422732
www.iosrjournals.org
27 | Page
Quality Assessment Of Unbranded Palm Oil Distributed In Five Local Markets In Port
Various microorganisms have been implicated in the deterioration of palm oil and other vegetable oils
e.g. Aspergillus flavus, A. niger, A fumigatus, Penicillum frequentans, Rhizopus stolonifer etc. These moulds
have lipolytic activities and their growth results in lipolysis (spoilage) of the palm oil. In general the rate of
lipolysis is proportional to the amount of the free fatty acid already present in the oil. (Okechalu et al 2011)
Frying and cooking of the oil can reduce the microbial load to the minimum level, but the fact that
some individuals consume this product raw is of concern as this may result in health problems in such
individuals when the microbial load is high.( Okechalu et al., 2011)
DOI: 10.9790/2380-08422732
www.iosrjournals.org
28 | Page
Quality Assessment Of Unbranded Palm Oil Distributed In Five Local Markets In Port
were maintained on nutrient agar (yeast extract) NaCl, peptone and 2% agar, pH 7.0) and were sub cultured
every 15 days.
Isolation of Lipid Utlizing Fungi (LUF)
Modified composed media (mainly 15g peptone, 5g NaCl, Ig CaCl2, 10ml palm oil, 15g agar) was
employed. An aliqout of the sample was plated onto the medium which has palm oil as the sole source of carbon
and incubated for four days at 370C (Sirisha and Narasu. 2010)
Screening Fungi for Lipase Activity Using The Rhodamin-B Agar Dye
Modified method by Savitha et al 2007. This method involves measurement of fluorescence caused by
the fatty acid released due to the action of lipase on olive oil. The quantitative fluorescence assay is based on the
interaction of Rhodamin B with fatty acid released during the enzyme hydrolysis of olive oil.
The fungal isolates were inoculated in media of the following composition (g/L). Potate dextrose agar,
sodium chloride 4.0. The medium was adjusted to pH 7.0, autoclaved and cooled to 60 0C. Olive oil (13.25ml)
and 10ml of Rhodamin B solution (0.001% w/v) was added with stirring and emulsified by mixing for 1 min.
The medium was allowed to stand for 10min at 600C to reduce foaming. 20ml of the medium was poured into
sterile petri dishes.
Screening Bacteria for Lipolytic Using The Rhodamin Bdye Agar
A solid medium composed of 0.5% (w/v) peptone, 0.3% (w/v) yeast extract, 1% olive oil and 10ml of
Rhodamin-B stock, 0.001% (w/v). The mixture was well homogenized by mixing. Cultures were incubated for
18-2hrs. For Rhodamin-B medium at 360C the lipolytic activities of isolates was monitored by fluorescence with
UV light at 350nm. The isolates that produce extracellular lipase would hydrolyze the substrate and produce
halo zone surrounding the holes of the gar plates (Sirisha et al., 2010).
Identification Of Isolates:
Identification of Bacterial Isolates
All bacterial isolates on the PCA plates were identified based on biochemical characteristics as described by
Cheesbrough, (2000) and U.S.FDA manual online (2001).
Identification of Fungal Isolates
All fungal isolates were identified based on their macroscopic and microscopic appearance with
reference to manual of Barnett and Hunter, (1972), Larone (1995) and Mycology online of Ellis (2006).
Physico-Chemical Analyysis Of Samples:
Peroxide value, Iodine value, relative density Free-fatty acid and pH of each sample was analyzed
using methods employed by Pearson (1976) Ohimain et al., (2013) and Ohimain et al., (2012).
OIL MILL
2.72109
1.5106
7.0106
CHOBA
2.30108
8.6105
3.0105
MILE 1
1.7109
1.00106
8.8106
MILE 3
9.0108
1.64106
7.0106
RUMUOKORO
2.0108
3.3105
4.0105
OIL MILL
MARKET
9.0107
CHOBA
MARKET
4.0107
MILE
1
MARKET
3.1108
MILE 3 MARKET
6.5108
RUMUOKORO
MARKET
2.0107
1.56106
8.60105
1.00106
1.64106
3.30105
DOI: 10.9790/2380-08422732
www.iosrjournals.org
29 | Page
Quality Assessment Of Unbranded Palm Oil Distributed In Five Local Markets In Port
The presence of coliform is an indication of faecal contamination which could be become as a result of
mishandling and poor processing of palm oil. The orange halo around the colonies on the Rhodamine B plates
shows the presence of lipolytic organisms capable of liberating extracellular lipases.
The detection of free fatty acids(FFA) in palm oil is an indication of degree of spoilage.
MILE 1
+
_
_
MARKETS
OIL MILL
_
+
_
CHOBA
+
+
_
RUMUOKORO
_
_
+
MILE 3
+
_
_
FREQUENCY OF
OCCURENCE(%)
60
40
20
The presence of moulds in some of the samples may be because some of the palm oil sample are sold
openly in the market exposed to the spores of the organism which are dormant and are highly resistant to the
lethal effects of heat drying and ultraviolet radiation.
DOI: 10.9790/2380-08422732
www.iosrjournals.org
30 | Page
Quality Assessment Of Unbranded Palm Oil Distributed In Five Local Markets In Port
Table 4: Physicochemial Quality Of Samples.
The maximum acceptable limit for free fatty acis( FFA) is 5% (Ngondo et al.,2011; Ohimain et al.,
2012). Results obtained from the free fatty acid analysis is far above the maximum acceptable limit. The high
(FFA) values obtained may be due to the exposure of samples to normal temperature at the market stores
(Okechalu et al.,2011) or even due to the presence of very high load of both lipid utilizing fungi bacteria ( Table
2) liberating extracellular lipases, which break down ester bonds in lipid molecules to liberate diglycerides,
monoglycerides, glycerols and free fatty acids ( Bora and Kalitha.,2007 ). Egan et al, (1981) stated that
glycerides in oil can be decomposed by lipases or other actions and that decomposition can be accelerated by
light heat.
Peroxide value determines the degree of oxidation in oil as well as an indication oof level of
deterioration of oil and fats (Nwanekezi and Onyeagba 2007; Okechalu 2011) . The high Peroxide value of the
samples indicates an onset of oxidation, which agrees with the reports by Ekpa and Ekpe (1996) who stated that
lipid degrading enzymes such as peroxidases and lipooxygenases ( Onyeka et al., 2005). Oxidation takes place
also, when microorganisms are capable of utilizing fatty acids in the absence of other simple sources of carbon
through a catalytic pathway known as -oxidation.
Iodine value is an index for detecting adulteration in Palm Oil and other vegetable Oil ( Okechalu et al.,
2011). Ekwenye reported that high iodine value is an indication of greater degree of unsaturated fatty acid and
higher tendency to get rancid on the other hand low IV obtained is far lower than the minimum acceptable limit
by codex standards; an indication of the presence of saturated fat and low tendency to get rancid.
Relative density.
The pH of samples was generally acidic and can be attributed to the presence of high FFa liberated by
lipid utilizers. Relative index of samples was within the acceptable limits by international standards
IV.
Conclusion
Most Palm oil distributed in Port Harcourt are produced by traditional extractors, according to Ngondo
et al.(2011) it has been demonstrated that oil produced by traditional oil extraction methods re of lesser quality
when compared with oil produced from industrial oil mills.
In general, samples from markets in Palm Oil samples from the local markets in Port Harcourt
metropolis do not meet NAFDAC standard for food and International standards for oil and vegetable
The limits exceeded by the microbiological and physic-chemical characteristics of the oil sample
purchased from these markets indicates the poor processing and poor handling of palm oil by extractors and
local sellers.
Improvement in the production procedures and processes as well as good seed selection, good handling
practices and clean environment can go as far improving the standard of palm oil sold in Port Harcourt.
V.
Recommendation
Due to the importance and necessity of Palm oil as a food source and its Industrial value. I recommend
that more stringent regulatory policies be enforced by Regulatory agencies such as Food and Agricultural
organization(FAO), World health organization(WHO),National Agency for Food and Drug administration and
control(NAFDAC) concerning its production, distribution and Quality control majorly in countries of its(Palm
oil) International trade. Also (FAO) should create workshops for local manufacturers on the aseptic measures to
employ during processing, handling, storage and transportation of Palm oil.
DOI: 10.9790/2380-08422732
www.iosrjournals.org
31 | Page
Quality Assessment Of Unbranded Palm Oil Distributed In Five Local Markets In Port
References
[1].
[2].
[3].
[4].
[5].
[6].
[7].
[8].
[9].
[10].
[11].
[12].
[13].
[14].
[15].
[16].
[17].
[18].
[19].
[20].
Bora, L. and M.C, Kalita (2007). Production and Optimization of Thermostable lipase from thermophilic Bacillus sp. LBN4.
Internet Journal of Microbiology Churchill, Livingstone. 507-546
Barnett H.L and Hunter, B. B. Illustrated Genera of Imperfect fungi. Burgess Publishing Company, Minneapolis, 1972; Pp 62 63
Chabiri, S.A., Hati, S.S.,Dimari, G.A. and Ogugbuaja, V.O.(2009). Comparative Quality Assessment of Branded and Unbranded
Edible Vegetable Oils in Nigeria. Pacific Journal of Science and Technology,10(2):927-934.
Cheesbrough, M. District Laboratory Practice in Tropical Countries part 2 Cambridge. Cambridge University Press. 2000; Pp 290320.
Egan H, Kirk RS, Sawyer R (1981). Pearsons Chemical Analysis of Food. 8th ed. New York, Churchill, Livingstone. 507-546
Ekpa OD, Ekpe UJ (1996). Effect of coconut oil concentration on themelting point profile and free fatty acid formation of palm oil.
Nig. J.Chem. Res. 8:12
Ekwenye UN (2005). Chemical Characteristics of Palm Oil biodeterioration. Chem. Soc. Exper. Bio. 18:141-149
Ellis.D. Mycology online. The University of Adelaide, Australia. 2006.
Larone. D.C Medically Important Fungi: A guide to identification. American Society of Microbiology. Washington, DC. 3rd Ed.
1995
Ngando EGF, Mpaondo MEA , Dikotto EEL, Koona P (2011).Assessment of the quality of crude palm oil from smallholders in
Cameroon. J. Stored Prod. Postharv. Res. 2 (3):52-58
Nwanekezi EC, Oyeagba RA (2007). Effect of Spoilage Microorganisms on the physicochemical properties of African Pear Fruit
Oil. J. Food Agri. Environ.5:90-93
Okechalu JN, Dashen MM, Lar PM, Okechalu B, Gushop T (2011). Microbiological quality and Chemical Characteristics of Palm
Oil sold in Jos Metropolis, Plateau State, Niger. J. Microb. Tech. Res. 1(2):107-112.
Ohimain E.I, Daokoru-Olukole C.,Izah S.C and Alaka E.E (2012). Assesment of quality of crude paim oil, produced by small
holdernprocesses in River State. Nigerian Journal of Agriculture, Food and Environment. 8(2)20-24.
Ohimain E.I, Izah S.C and Famari A.D(2013). Quality Assesment of crude Palm oil produced by semi-mechanised processes in
Bayelsa State Nigeria. Discourse Journal of Agricultural and Food Sciences. 1(11):171-181.
Onyeka EU, Onugbu NI, Onuoha NU, Ochonogor F (2005). Effect of extracting pre-treatment on the Composition and
Characteristics of seed and pulp oil of African Black pear ( Dacryodes edules ). Nig.Food J. 23:13-20
Pearson D (1976). The Chemical Analysis of Food. Churchill Livingstone, Edinburgh, London 121-150
Savitha. J.; S. Srividya, S, R. jeyat, Pauyal, S. Priyanki, G.W. Rashmi, K.T Roshini and Y.M Shantala (2007). Identification of
potential fungi strains for the production of Inducible, extracellular and alkalophilic lipase. African Journal of Biotechnology.
Sirisha E, N. Rajasekar and M.Lakshmi Narasu (2010) Isolation and Optimization Of Lipase Producing Bacteria from oil
contaminated soil. Adv. Bio, Res 4(5) 249-252.
Sundram K. Palm oil: Chemistry and Nutrition updates. Kuala Lumpur Malaysian Palm Oil Board. 2003; Pp 1-17
United States Food and Drug Administration, Bacteriological Analytical Mannual Online. FDA/Center for Food Safety and Applied
Nutrition. 2002.
DOI: 10.9790/2380-08422732
www.iosrjournals.org
32 | Page