Professional Documents
Culture Documents
Food Safety Hazards and Controls For The Home Food Preparer
Food Safety Hazards and Controls For The Home Food Preparer
AND CONTROLS
FOR THE HOME FOOD
PREPARER
Copyright 1994
by
Hospitality Institute of Technology and Management
670 Transfer Road, Suite 21A; St. Paul, Minnesota 55114
TEL 651 646 7077 FAX 651 646 5984
http://www.hi-tm.com [email protected]
(June 2006 edition)
PREFACE
Food and water are necessary to keep the human body functioning. People
must have a balanced diet that includes a complex range of nutrients to provide
energy, promote growth, maintain health and resist disease or illness, and
promote longevity.
It is also known that food and water can carry, or be sources of, harmful
microorganisms, chemical compounds and particulate matter. This booklet
will discuss the hazards that are present in food and water, and how it is
possible to control or eliminate these hazards by using correct methods of food
selection, preparation, service and storage.
Government agencies and regulations at the local, state and national level have
been established to institute the rules to produce a safer supply of food.
However, government regulations and inspections are not always accurate and
cannot guarantee that all food that is currently for sale in retail food markets
and foodservice units is safe for consumption. Therefore, consumers become
the focal point for controlling food safety hazards. This means that consumers
must know the hazards in the food supply and must use correct hazard controls.
Many consumers have no formal training in proper methods of safe food
preparation. Most consumer knowledge is based on what they learned from
their family members, the media (television, radio and newspapers), and
occasionally from government publications. Some of these food preparation
methods do control hazards, and some are incorrect and are very dangerous.
The purpose of this book is to provide home food preparers, who are the
"critical hazard controllers," with an accurate assessment of the hazards that
exist in food and water, and to provide them with correct knowledge that is
necessary to prepare food safely for themselves, their families and friends, by
applying the principles of Hazard Analysis and Critical Control Points
(HACCP).
Many food safety facts such as safe food cooking times and temperatures differ
from the old, out-of-date information found in government food publications.
The facts in this booklet are based on current food science research reports by
noted scientists. References are available. The government has not disputed
these facts, but has not made changes based on the facts.
ii
Poison. A compound that is capable of causing illness, injury and even death. Poisons do
not come from microorganisms. They are not controlled by heat. In a few cases, such as
pesticides, they can be washed off of food.
Risk. The likelihood of the degree of illness response to a given hazard, up to and
including death.
Sanitize. Making a food surface safe from pathogenic microorganisms for food contact.
Cleaning with soap / detergent and clean water is the critical control to have a safe surface.
Thermal or chemical procedures, as used in the food industry, are not necessary. The
surface will not be sterile. Informal public health standards accept 100 microorganisms per
8 square inches of food contact surfaces as safe. Chemical sanitizers are very sensitive to
organic matter and if the surface is not clean, chemicals will not be effective in reaching the
microorganisms on the surface and inactivating them.
Spore. Some bacterial cells have the ability to form spores. The spore state is a period of
no growth, similar to hibernation, in which the cell dries up, and the cell wall becomes
thickened. Spores are very resistant to heat and chemicals.
Sterilize. The reduction of all multiplying vegetative microorganisms and dormant but
viable spores to a safe level. This is accomplished by heating the food to 250F for 2.4
minutes, which reduces the probability of the survival of the spores of Clostridium
botulinum 1012 to 1. This is the process used to create room temperature-stable canned
food.
Vegetative cell. In contrast to the dormant spore, which has no metabolic activity until
activated when food is cooked, the vegetative cell is in an active metabolic state in which
the bacteria are growing and multiplying at a rate depending on the food temperature,
acidity, water, additives, etc.
GLOSSARY
The following terms are used in this text as indicated.
Clean. Free from litter or clutter, loose dirt, food particles and grease. This is the critical
step in sanitizing surfaces and equipment. Visual cleanliness is not a guarantee of safety
because a surface that has been wiped with a rag, for instance, can look clean, but leave a
film of microorganisms. When a surface is washed clean, as described in this booklet, the
dangerous microorganisms will have been reduced to a safe level.
Control. The act of preventing, eliminating or reducing hazards to a safe level.
Critical control point. A point, step or procedure at which control can be applied and a
food safety hazard can be prevented, eliminated or reduced to acceptable levels. This can
include a person who washes his/her hands prior to handling food or handles food properly,
a step in preparing a recipe or a procedure such as proper refrigeration, or the growing of
chickens in a environment free of illness-causing microorganisms (i.e., pathogens).
Feces. Excrement, solid metabolic waste products of humans, animals, birds and insects.
Food contact surface. The surface of equipment and utensils that any food touches during
storage, preparation, cooking, holding and serving (e.g., bowls, knives, grills, ports, steam
table pans and utensils).
Food spoilage. Food that has decayed or decomposed. Rate of spoilage depends on
surrounding environmental factors such as temperature, atmosphere and moisture. Spoiled
food does not cause foodborne illness. There must be a sufficient level of hazardous
material to cause such an illness.
Hazard. A biological, chemical or physical (hard foreign object) property that may cause
an unacceptable health risk to the consumer.
Hazard Analysis and Critical Control Points (HACCP). A method of determining the
hazards in a food or process and to control them. It reduces the risk of foodborne illness by
training food preparers to recognize the hazards and use scientifically validated controls.
HACCP includes knowing the current causes of foodborne illness in the United States,
growth conditions of hazardous microorganisms, application of shopping and storage
procedures, and kitchen processing procedures, necessary for safe and quality food.
Pasteurization. A thermal treatment of food that effectively reduces numbers of
pathogenic microorganisms in food to a safe level.
Pathogen. A microorganism in food and water that is capable of causing disease or illness
in humans. They may be grouped into the 2 basic categories:
Infective pathogens cause illness when they multiply within the body. Examples
include Salmonella spp., Campylobacter jejuni and hepatitis A virus. They cause
illness, at least diarrhea, no sooner than 8 hours after ingestion. The time period for
onset of symptoms may be many days.
Toxin-producing pathogens produce toxins when they multiply in food. These toxins
are not usually inactivated by cooking. Any food in which there is a possibility of toxin
formation must be discarded. Examples of pathogenic bacteria that produce toxins
include Staphylococcus aureus, Clostridium botulinum and Bacillus cereus. Illness
from intoxication can result in at least vomiting, in less than 30 minutes. It might be
delayed up to 8 hours.
References
Canada, J.C., Dryer, J.M., and Mauder, D.J. 1979. Canned foods: Test for commercial sterility. In
Compendium of Methods for the Microbiological Examination of Foods. M.L. Speck, ed. American
Public Health Association. Washington, D.C.
Frazier, W.C. and Westhoff, D.C. 1988. Food Microbiology. 4th edition. McGraw-Hill. New York, NY.
Jay, J.M. 1996. Modern Food Microbiology. 5th edition. Chapman & Hall. New York, NY.
iii
TABLE OF CONTENTS
Preface....................................................................................... ii
Glossary ................................................................................... iii
I. Is There Really a Food Safety problem?...............................1
II. The Food System Hazard Control Points ..................................1
At home
When shopping
After shopping, unloading groceries in the home
Preparation
Serving
Leftovers
References .........................................................................................24
Appendix A: Chemical Hazards ....................................................25
Appendix B: Physical Material Hazards.......................................25
Appendix C: Pathogens in Food ....................................................26
Appendix D: Illnesses or Diseases Attributed to Food.................27
Appendix E: Food Safety Products and Services .........................29
Temperature Summary Tables.......................................................30
Plant and animal food sources that are grown, harvested and handled on the
farm are subject to contamination from various sources. The soil and
fertilizers in which plants are grown contain safe and unsafe vegetative
microorganisms, pathogenic spores, chemicals and hard foreign objects.
People who harvest food from the fields may be contaminated with pathogens
that they transfer to the food. Their hands may be contaminated with various
pathogens for several reasons. Perhaps they did not wash their hands after
using the toilet and prior to harvesting the food, or they have infected cuts on
their hands. They may cough or sneeze on the food. They may have open
sores on their skin. Their hands can become contaminated as they handle the
crops because of pathogenic microorganisms remaining on the plants from the
soil and organic fertilizers. Fields are not usually equipped with hygienic
facilities such as toilets and fingertip washing stations, etc., where workers can
maintain a safe level of personal hygiene. There are no government
regulations to adequately control these problems.
In order to make sure that no one is made seriously ill, hazards must be
prevented and/or controlled through correct knowledge of how to safely grow,
harvest, slaughter, deliver, handle, prepare, serve and store food ingredients
and products, and how to perform these tasks correctly 100% of the time.
Today, because of the way food is grown, harvested and supplied to the
consumer, the person who prepares the food, the cook, becomes the hazard
control point. Lack of hazard control at the source of supply in the food
system is so severe that the food preparer will remain the hazard control point
for many years to come. This booklet informs the home food preparer about
hazards in food from the wholesale system and how to control these hazards
so that the food can be made safe with as little over-processing as possible.
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
Staphylococcus aureus
Clostridium perfringens
Campylobacter jejuni
Escherichia coli O157:H7
Bacillus cereus
Listeria monocytogenes
Yersinia enterocolitica
Vibrio spp.
Giardia lamblia and
Norovirus
Source
Raw poultry
Raw pork
Raw shellfish
Raw chicken
Raw pork
Raw beef
Raw pork / chicken
Raw chicken / turkey
Raw beef / pork /
poultry
Raw ground beef
Raw rice
Fresh potatoes
Fresh radishes
Raw pork
Raw milk
Raw vegetables
Raw seafood
Water
known that Salmonella enteritidis can infect the oviduct of laying hens, and
may be present in the eggs produced by these chickens. Approximately 1 in
20,000 intact shell eggs (no cracks or checks) in the retail food system can
contain hazardous levels of Salmonella enteritidis. It is also a common
practice to wash poultry during processing, and to wash eggs to remove
obvious fecal material. While this washing procedure slightly reduces the
number of pathogens on the poultry and eggs, it does not make these products
safe to eat without further processing (i.e., pasteurization or acidification).
Percent
contaminated
40 to 100
3 to 20
16
73
13 to 33
16
39 to 45
45 to 64
1.5 to 3.7
Fish and fish products can pose a threat to consumers, because the waters in
which fish are caught may be contaminated. The water used in "fish farms" to
breed and raise fish may be more controlled than uncontrolled environments
of lake or seawater, but this is no guarantee that the fish will be free of
harmful pathogens and substances. On fish farms, environmental
contamination will depend on the pathogen content of the feed that the fish are
given and pathogens from wild birds if they are allowed access to the water.
43 to 63
100
26
30
49
48
46
33 to 46
30
Fish are often taken from "unsafe waters" or held and stored improperly after
being caught. Ciguatoxin is present in some species of ocean fish that have
fed on dinoflagellates. Fish such as tuna, mahi mahi, and amberjack are
sometimes held too long on the decks of boats and as a result, partially decay,
allowing histamine to form before the fish reach a processing facility.
Ciguatoxin and histamine are not destroyed when the fish are processed in
canneries or cooked at home and in retail food operations. When fish is
cooked, the food preparer has to hope that the fish was taken from "safe"
waters and handled correctly by the fisheries and processing industries
according to HACCP (Hazard Analysis and Critical Control Points)
procedures.
Sometimes foods, particularly plant foods such as grains and nuts, if held too
long on the farm before they are sold and distributed, spoil due to mold
growth. Some molds produce toxins when they grow. Consumption of
products containing these mold toxins (aflatoxins) is now known to cause
liver cancer. There are government standards and methods for measuring the
amount of mold toxin in food. At the present time, this type of mold
contamination of food seems to be adequately controlled by the government.
When tree nuts and grains are stored at correct low humidity for approved
periods of time, mold growth is controlled.
Shellfish are a particular problem, because many people like to eat them raw.
Shellfish taken from polluted waters can carry pathogenic bacteria and viruses.
They should NEVER be eaten raw. Some shellfish contain dangerous toxins
that can cause death if consumed.
Poultry and eggs are good, nutritious foods. However, there is sometimes a
lack of control of pathogens in the environment in which chickens are raised
and eggs produced. For example, poultry feed and water become
contaminated from cockroaches, flies, birds and rodents (mice and rats) in
poultry houses. As a result, the poultry becomes diseased, and occasionally
eggs become contaminated. Two types of pathogenic bacteria often associated
with eggs and poultry are Salmonella spp. and Campylobacter jejuni.
Although there are government regulations that have some control over the
growing and harvesting sites for shellfish, they are inadequate and often
unenforceable. These regulations do not deal with hazards such as viruses and
parasites common in water that can contaminate the shellfish. Government
regulations require a shellfish tag on the shipping container and the
identification of the shipper. However, because there are no regulations that
require correct testing of the water from which the shellfish were harvested,
the shellfish tag has virtually no safety value.
The poultry and eggs can appear to be wholesome, but until they are processed
so that the pathogens are killed, these food items can be dangerous. It is now
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
Fishermen who catch fish and harvest shellfish must be aware of possible
hazards and use the best methods available to ensure the sale of safe
commodities. Raw fish and shellfish can never be expected to be totally free
of pathogens. However, consumers should and do expect these products to be
safe for consumption after cooking or proper methods of preservation.
levels of nitrites and nitrates to water systems. If the water is properly tested
and treated, nitrites and nitrates are not a threat and can be controlled, but the
farmer must test and know that the water is safe.
There is also the problem of wood, metal and rocks in fruits and vegetables.
This is understandable, considering the growing and handling process.
When food animals and plant products leave the farms, waters and fields, they
are taken to food processing plants. Some products, such as locally grown
fruits and vegetables, are taken directly to the consumer marketplace.
Contamination of raw meat, poultry and fish in slaughtering and processing
plants is difficult to control or prevent. The outside of the animal is
contaminated, and it is difficult or impossible to slaughter the animal without
getting pathogens on the muscle tissue. If slaughtering is not done precisely
and with care, the pathogens found on the hides and in the intestines of
animals can cross-contaminate the immediate vicinity, including other
already slaughtered animals, food handlers and equipment.
An incident was documented a few years ago when apples in an orchard fell
on the ground and became contaminated with Escherichia coli O157:H7,
because diseased cows were allowed to roam the orchard and spread manure
on the ground. These apples picked from the ground were then used to make
unpasteurized, natural cider. (The apples were not washed before they were
placed in the cider press.) Over 100 people consuming this cider became ill.
The source of the illness was traced to the cow manure in the orchard.
When there is a big rainstorm, ground water from a dairy farm with sick cows
can flow across the road and contaminate the lettuce-growing field of another
farm. Hundreds of people can become ill after consuming this contaminated
lettuce. Water used for farm irrigation systems is usually not treated to reduce
pathogens. If 2 to 3 weeks pass after fruits and vegetable fields are irrigated,
pathogenic microorganisms on plants tend to decrease in numbers. However,
if the fruits or vegetables are harvested soon after irrigation with contaminated
water, there will be some transfer of pathogenic microorganisms.
Note: Pathogenic bacteria begin to grow, very slowly, at about 30F. Unsafe
food storage temperatures are actually 30 to 130F. Spoilage bacteria begin
to multiply at 23F. Therefore, as raw food thaws, it actually begins to spoil.
Bacteria generally multiply 5 times faster at 40F than at 30F. This means
that the colder food is maintained, the longer it will remain safe and be of
higher quality.
before handling the food and when they do not refrigerate or store the
products correctly. Hazards are also created when buttons from their uniform,
or gum or jewelry fall into food. At the present time, no retail food market is
required to have a hazard control program and train their employees to control
hazards.
Handling by packagers, drivers and other workers increases the risk of quality
loss and the possibility of pathogen cross-contamination. Truckers are known
to turn off refrigeration units to save costs. They sometimes back-haul
hazardous chemicals in the same truck used for transporting food. There is
very little government surveillance to ensure food safety during distribution.
One out of 50 people who is feeling fine, each day, is actually a carrier of
pathogens and passes billions of illness-producing microorganisms in his/her
fecal material and urine. Government regulations recommend, as a control,
that food handlers should stay home and not handle food when they feel ill.
This control method is ineffective because many people in early stages of an
infection are shedding pathogens in their feces and feel fine.
It is impossible to produce food with zero pathogens. Therefore, the aim for a
safer food supply is to produce food with a level of pathogen contamination
that provides a scientifically "acceptable risk", such as 1 person in a million
people dying per year. People need to be aware of the risks involved in
consuming food, and to handle food to reduce these risks.
Foods begin to spoil the minute they are harvested or slaughtered. The shelf
life of various foods differs due to food composition, processing and storage
methods. Canned goods and dried foods, such as uncooked beans and pasta,
are more stable than fresh fruits and vegetables or refrigerated meats and dairy
products. Canned goods, after 20 years of storage at room temperature, can be
as nutritious as fresh canned products, assuming the container is sound.
However, quality deteriorates. Old canned food is soft in texture, and has offcolor and a poor flavor. It should be eaten only in an emergency.
Toxic compounds in food. Most food will cause death if consumed in excess
and not as a part of a balanced diet. Appendix A (Chemical Hazards) is a
table listing common chemical hazards. Toxic compounds are present in
grains, legumes, fruits and vegetables. When a variety of foods in moderate
amounts are consumed as a part of a normal diet, these toxic compounds do
not accumulate in the body and hence, cause no problems. Some toxic
compounds, such as hemagglutins in kidney beans and soybeans, are
inactivated by moist heat. These items should not be eaten without cooking.
Sometimes food products are prepared at the grocery stores deli or bakery.
Aside from the hazards associated with raw food ingredients, there are the
additional hazards introduced by food handlers who may mishandle the food.
This occurs when workers do not wash their hands and fingertips correctly
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
Nutritional considerations. Another vital aspect of chemical hazards is overor under-nutrition. Vitamins and minerals in food are chemicals. It is
important that each person eat a balanced diet as defined by current U.S.
dietary guidelines. Most Americans consume too much red meat and fat.
Being overweight is a hazard to one's health. Current dietary guidelines in the
United States recommend that both fat and red meat consumption be reduced,
and that consumption of fruits, vegetables, and whole grains and cereals be
increased. It is said that 75% of the human diseases stem from food. If a
people want to live a long, disease-free life, choosing and consuming the right
types of food in moderation and preparing food correctly are essential to the
control of this hazard.
However, the presence of large particles and foreign objects (rocks, pieces of
metal and plastic, bones, nut shells, stems from raisins, etc.) in food is a
hazard. Whole bay leaves can also be a problem because they do not soften
when cooked, and people can choke on them if they are left in food products.
To prevent injury from foreign objects, objects in food should be kept smaller
than 1/16 inch. Foods should be inspected for the presence of foreign objects
by the food preparer. These objects can be removed by picking them out of
food and/or by washing food items in flowing water, if this is applicable.
Microbiological Hazards
Especially on raw food such as fruits and vegetables, people eat millions of
spoilage microorganism and some pathogens in a meal. Each individual's
state of health affects his/her resistance to or tolerance of these pathogenic
microorganisms. If you grew up on a farm, or in a contaminated environment,
you probably developed a resistance to moderate levels of pathogenic
microorganisms. Resistance to diseases is also gained from vaccinations, if
not acquired naturally. If you take antacid medications, your body's first line
of defense can be broken when the acid pH of the stomach is raised. Normal
levels of acid in the stomach dissolve most pathogens before they can reach
the small intestine. If you are taking antibiotic medications, you can reduce
your body's second line of defense, good intestinal microflora. When there are
few competitive microorganisms in the gut, pathogenic bacteria such as
Salmonella, Shigella, E. coli, etc., if they survive the stomach, can easily
multiply. The body's third defense is the immune system. Pregnant women,
elderly people, very young children, and other individuals with compromised
immune systems must choose food carefully to avoid being made ill by low
levels of pathogens that penetrate into the blood and can infect the body. The
immune system is reduced in patients with organ transplants in order to
prevent organ rejection. These patients are thus more susceptible to illness. In
addition, there are auto-immune diseases such as AIDS that make one more
susceptible to illness.
developed. Because of this, often the best treatment for foodborne illness
bacterial infections in humans may be bed rest and allowing each individual's
immune system time to combat the source of infection.
Viruses. Viruses are not true living cells and are much smaller than bacteria.
Viruses are composed of a protein coating around genetic material (DNA or
RNA) and are unable to reproduce unless they are inside a living cell. Viruses
do not multiply in food. They do multiply in cells in various organs or tissues
of the body. For example, Hepatitis A virus replicates in cells of the liver. It
is quite difficult to isolate viruses on or in food. Normally, the best treatment
for viral infections is allowing time (bed rest) for each individual's functioning
immune system to combat the virus.
The longer raw, high-moisture foods are on display, the greater the amount of
deterioration and spoilage. Most microorganisms grow best at high levels of
moisture. Spoiled food does not necessarily mean hazardous food. It is
merely unattractive and undesirable. In fact, there is no government standard
for "spoiled". The American consumer who smells and tastes the food
determines whether or not a food item is spoiled. Appearance and smell are
indicators of freshness. Some foods are produced using spoilage organisms.
This is called fermentation. Examples of fermented products include aged
cheese, yogurt, cured salami, buttermilk, sour milk, sauerkraut, kimchi, wine
and sourdough starter for bread. All of these foods are prepared from raw,
contaminated ingredients, and proper fermentation creates distinctive flavor in
these products and makes them safe to consume, because the fermentation
process destroys the pathogens. It is common to consume 10,000,000 (107)
spoilage microorganisms per gram (there are 28.35 grams per ounce) of a
fermented food product. Foods such as fresh bean spouts and fresh
mushrooms can contain from 100,000 to 20,000,000 spoilage microorganisms
per gram because of the way they are grown. Non-pathogenic spoilage
microorganisms do not cause illness or disease.
Yeasts. Yeasts are much larger than bacteria. Most yeasts are not pathogenic
(do not cause foodborne illness or disease). However, Candida albicans,
which causes thrush in infants, is the exception. The growth of some types of
yeast is used to produce fermented food products. Undesired growth of some
yeast in food products causes spoilage.
Molds. Molds are larger than bacteria. The presence of mold in food can be
seen as a cottony, powdery or fuzzy patch on the surface of food that may be
gray, white or highly colored. The presence of mold in products causes
spoilage. When some types of mold grow on grains and nuts of high moisture
content, aflatoxins may form. These toxins are thought to cause liver cancer
and are not easily inactivated by heat achieved during baking. Extremely
moldy food should be discarded. If mold growth is not extensive, it should be
removed from the surface of the food in a way that assures complete removal
of the mold-affected area without contamination of other parts of the food,
such as cutting off the area and about 1/4 inch below it.
Parasites. Parasites are organisms that live at the expense of the hosts
(humans, animals, fish and birds). Parasites in food generally refer to the
presence of protozoa (microscopic single-celled animals) and helminths (small
worms and their larvae). In the United States, there are far fewer documented
cases of foodborne disease and illness due to parasites than due to bacteria.
Parasites can be found in irrigation water, in cat feces in the farm yard, in the
muscle tissue of improperly fed and maintained cattle and swine, and in fish
muscle. Humans become infected when they eat undercooked meat, poultry,
fish and vegetables. Parasites are hard to detect. Early symptoms of parasitic
illness include loss of appetite and weight loss. Some parasitic illnesses may
be treated with medication. The medication causes the parasites to die and
they are excreted. In some cases, parasites may need to be removed
surgically.
Two basic forms of foodborne illness result from the presence or growth of
microorganisms in food: foodborne infection and foodborne intoxication.
Foodborne infection. Foodborne infection occurs when humans consume
low numbers (1 to 100) of pathogenic pasteurization-sensitive microorganisms
that then multiply in the body. Symptoms of illness can occur in no less than
8 hours, but usually 2 or 3 days to weeks are required for infectious
microorganisms such as Salmonella and Shigella (bacteria), norovirus or
hepatitis A virus, or Giardia and Cryptosporidium (parasites) to multiply in
the body, causing the development of illness or disease.
Sometimes people complain that they became ill with diarrhea immediately
after consuming a food. This type of immediate illness is not due to ingestion
of infective microorganisms, but is more likely due to a food intolerance. For
example, some people tolerate little or no fat in their diet and have a rapid
onset of diarrhea (within 30 minutes to an hour) after they consume a food or
meal high in fat.
Observe use-by-dates. Choose items that will be used within the period of
time suggested by the use-by-date. Manufacturers set the sell-by / use-by
dates assuming that the food is always less than 40F, and sometimes less than
35F. They can choose any sell-by / use-by date they wish because there are
no government rules that they must follow. Sometimes they guess at the shelf
life and do not actually do tests. It is always better to purchase items with an
unexpired date. But, if the food has been even slightly temperature abused
(kept above 40F during distribution or selling), the sell-by / use-by-date has
no meaning and the product can be spoiled when you get it home. Then, you
have to waste your time exchanging the item. Sometimes food such as cheese
and fruit is moldy when you open the package. Almost all cheese, raw fruits
and vegetables, deli salads, etc. are contaminated with mold, but you cannot
see it. Given time, it grows enough to be seen. The only control is to buy
food as fresh as possible, store it correctly, and prepare and consume it
promptly.
It is now clear that all raw food, moist or dry, (spices, dried peas and beans,
rice, etc.), must be assumed to be contaminated with microorganisms,
chemicals and hard foreign objects, and capable of causing illness, injury,
or death if not properly handled.
Choose fresh produce. Control begins when you select produce items that
appear to be as fresh as possible. Avoid items that are too wet, have bruises
and blemishes, and appear wilted, limp or slimy. Worms you may see on
fruits and vegetables, while unappealing, will not hurt you. This type of
contamination can be removed by washing, cutting out affected parts, and by
cooking. Remember, just because food looks fresh, this is no guarantee of
safety.
Check dates on dairy items. These products (milk in cartons, cottage cheese,
sour cream, etc.) usually have use-by dates. Observe them and make your
selections based on how soon you can use the product. Use-by dates on dairy
food containers assume a constant temperature of 40F. If the dairy items are
at 50F, the time in which you must use the item is reduced 3 times. In other
words, 12 days storage at 40F becomes about 4 days at 50F. When milk is
put in a refrigerator, it should not be stored on the refrigerator door. This area
is especially warm, and the shelf life of the milk will be reduced. Place the
most perishable food, such as fresh milk, fish, meat and poultry, against the
back wall of the refrigerator where the refrigerator air temperature is 10 to
15F colder than on the door. Food that is good for 10 days at 40F, is good
for 20 days at 35F. When preparing food for a meal and you take refrigerated
food (e.g., milk, meat for a sandwich) out, put it away immediately, because
30 minutes at room temperature can shorten quality shelf life considerably.
Check packaging. Choose packages that do not have obvious holes in them
or show obvious signs of leakage. If a package of fresh meat or poultry is
somewhat leaky, carefully wrap the package in another plastic bag to prevent
drip or juices from cross-contaminating other raw food items in your shopping
cart. Wiping your hands with a clean paper towel will reduce some of the
pathogens that probably got on your hands, but it will not make your hands
totally safe. Always shop for fruits and vegetables first, and place these items
in plastic bags before going to the meat, poultry and fish counters. Customers
who do not understand food safety sometimes open food such as salad
dressing to smell and taste the food to determine if they like it. If you find a
container that has been opened or the seal of which is broken, give it to one of
the store personnel.
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
Check egg storage. Eggs in the grocery store should always be stored in a
cooler at 40F. Do not purchase eggs that have been sitting out at room
temperature. Occasionally, chickens lay eggs containing Salmonella
enteritidis, not only on the shell, which is quite common, but also inside the
egg. Uncracked, perfectly fine-looking eggs that are washed still have low
levels of chicken fecal bacteria such as Salmonella on the shell. Throughout
the United States, it is estimated that 1 in 20,000 eggs contains Salmonella on
the inside. If eggs are colder than 45F, the Salmonella enteritidis will not
multiply in the egg. (It will not multiply on the shell because there is not
enough moisture. However, it can cross-contaminate other food or the egg
itself when the shell is cracked to open it.) Check the eggs to make sure that
there are no broken, cracked or dirty eggs, because these eggs can carry a high
number of pathogens. Observe the sell-by / use-by dates if this information is
printed on egg cartons. Eggs are usually graded for quality at the time they
are packed. If grade AA eggs are temperature abused or old, they can have
deteriorated to a grade B classification by the time they are used. You can
judge the quality (not the safety) of the egg when you use it, by cracking it
open and looking at how much it spreads when put into a frying pan, for
example. The egg should have a white that does not spread beyond 3 inches
in diameter, and the yolk should be 3/8 to 1/2 inch high. If the eggs are
temperature abused in the store where you shop, shop at a store that controls
temperature and stock rotation.
turn brown and remain a brownish red color, even when cooked to the welldone temperature range. This is most likely due to the myoglobin in meat
becoming exposed to residual nitrates from fertilized root vegetables. The
only way to know positively that the food is safe is to measure the temperature
in the food.
Selecting fresh meat, fish and poultry. The red color of meat is caused by a
protein pigment called myoglobin. Red meats such as mutton and beef
contain more myoglobin than do lamb, veal and pork. There is less
myoglobin in turkey and chicken breasts than in the legs and thighs. Meat that
has only a small amount of myoglobin is called "light" or "white" meat; "dark"
or "red" meat is significantly higher in myoglobin. A bright, cherry-red color
in meat such as beef is often used as an indication of freshness. Again, this
has no relation to safety of the meat.
Selecting frozen and refrigerated food items. Select refrigerated and frozen
items toward the end of your shopping time to prevent these items from
getting too warm. Deli and cold display items should be cold (40F). Always
select only those foods that are below the load line. The load line is indicated
on the inside wall of the storage unit. The load line is the point where the air
flows across the top of the food. If the food is above the load line, you have
no idea of the food's temperature. Do not trust the thermometers in the cold /
frozen cases because they can be manipulated to indicate a colder temperature.
If there are ice crystals in bags or boxes of frozen food, it is because the food
has been held too long in freezer cases. Temperatures fluctuate 15F or more
during automatic defrost cycles of freezer display cases. While the period of
time for a defrost cycle is short, perhaps 30 minutes, it allows the surface of
frozen food to warm up, and when the temperature decreases, the free water
on the surface of the food forms ice crystals and the surface becomes
dehydrated. This condition, called "freezer burn", is a quality problem, not a
safety problem. Do not hesitate to complain to the store's management.
A color change also occurs in myoglobin when meats are "cured". Sodium
nitrite, salt and heat are used during the curing process. The nitrite combines
with myoglobin to form the stable pink color of cured meats. This cured meat
pigment is unstable in the presence of light and the color will fade. But,
additional cooking has no effect on color. The addition of the correct amount
of nitrites to cured meats (e.g., sausages and ham) also prevents the growth of
Clostridium botulinum. Too much nitrite can cause death.
Sometimes the area around the bones of fried chicken or chicken cooked by
other methods is quite dark. This often occurs in the drumsticks and thighs of
young chickens, and particularly in those chicken carcasses that have been
frozen. The hemoglobin in the blood from the chicken's porous bones leaks
into the muscles near the bones, and it darkens when heated. There is no
safety problem with this condition, if a proper, tip-sensitive thermometer is
used during cooking to check the temperature of the chicken muscle near the
bone to assure that an adequate pasteurization temperature was reached during
cooking.
Selecting hot deli items. These items should be hot (above 150F). Again,
purchase them at the end of your shopping time. Pathogenic spores survive in
9
meal may cause illness in some people. When you use MSG, never use more
than 1/4 teaspoon per 4 pounds or 2 quarts of food.
When buying non-food items such as household cleaners, insecticides and
laundry supplies, check to make sure that the lids are closed firmly to avoid
leakage of the chemicals onto food items.
Bagging groceries. When bagging your groceries, pack cold and frozen items
together to keep them as cold as possible (40F). Keep hot foods away from
cold items. Put raw meat and poultry items on the bottom of the bag.
Remember, the outside of meat and poultry packages is contaminated.
Chemicals should be packed in bags, separate from any food items. If
someone packages the groceries for you, ask him/her to pack them as
described above.
Selecting pasta, cereal products and other dry, shelf-stable food. These
food products should be free of visible insects. Note: the eggs of insects are
present in grain, pasta and cereal products. If flour and bakery mixes are
stored in warm, moist storage areas, the eggs may hatch into Tribolium
("confused flour weevils") and other grain insects. Look for insects on store
shelves. If the store does not rotate stock, you will see evidence of them. The
presence of these insects is usually not a safety problem. It is a quality
problem. All grains and cereal products, dried potatoes, rice and other dried
foods such as dry milk solids are contaminated with spores. When water is
added to these items and they are cooked and then allowed to remain at room
temperature for 9 to 12 hours, it is almost assured that there has been spore
outgrowth and toxin production. Reheating, which does not inactivate the
toxin, will not make the food safe.
Keeping food cold on the way home. If you live an hours drive or more
from the food market, or if the chilled food will warm up to more than 50F
on the way home, you may want to bring a portable cooler with ice. Pack cold
food in this ice chest in order to maintain its temperature when transporting
cold food to your home or destination. Keeping food at 50F for a short
period of time, say 1 hour, is a spoilage problem, not a food safety problem.
Selecting canned food. Check the cans you purchase for dents (along top,
bottom and side seams). Use of defective canned food can cause death. Look
for swelling or puffing, and bulging tops or bottoms. If you spot a bulging can
of food, return it to a store manager. Usually, swollen cans of food are due to
"hydrogen swell" (acid in food gets through the can liner and reacts with the
metal in the can to release hydrogen gas). However, there is also the
possibility that a swollen can of food indicates growth of Clostridium
botulinum and production of its deadly toxin. If you have such a can, return it
to the grocery store. NEVER open the can because the liquid could squirt up
into your face.
In order to prevent and control food safety hazards and minimize spoilage, do
the following.
1. Store refrigerated and frozen food as soon as possible, preferably before
refrigerated food warms to 45F and frozen food to 10F. Cover and place
raw refrigerated food on bottom shelves in the refrigerator, below cooked
food. Place refrigerated items near the back. The back of most
refrigerators is 10 to 15F colder than the door. Do not store any
perishable items, such as milk, on the refrigerator door shelves. When
storing food in the freezer or freezer compartment, move the older items to
the front so that they will be used first. Date items before placing in the
freezer.
2. Date products stored at room temperature before storage. This includes
canned food items, spices, cereals and other dry, shelf-stable food items.
While these products will be safe for years, the quality of the products
slowly decreases. The dry storage area for canned goods should be at or
below 70F, 60% relative humidity. For highest quality, canned products
should be eaten or used within 2 or 3 months after purchase.
Chemicals. Read food product labels to make sure they do not contain
ingredients that cause allergic reactions.
The amount of monosodium glutamate (MSG) in commercial food is
controlled and is used at a safe level. However, there are no FDA guidelines
for amounts of MSG added to food in retail foodservice operations such as
restaurants. Because some cooks or chefs have no education about using
MSG, it may be used in excessive amounts that may make some people ill.
The FDA has now stated that more than 3 grams of free glutamic acid in a
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
10
30
35
40
41
45
50
55
60
65
70
75
80
85
90
95
100
105
110
115
120
125
>130
123.8 days
19.3 days
7.5 days
6.5 days
4.0 days
2.4 days
1.7 days
1.2 days
21.6 hours
16.9 hours
13.6 hours
11.2 hours
9.3 hours
7.9 hours
6.8 hours
5.9 hours
5.2 hours
4.7 hours
4.6 hours
5.6 hours
31.0 hours
Safe
Before preparing food, wash your fingertips and hands thoroughly using the
double hand wash method. Since fingertips that hold the toilet paper are so
difficult to clean, this method involves using a fingernail brush during the first
wash to remove transient bacteria, such as fecal pathogens, from your
fingertips. You can put soap on the fingernail brush, and this way, get the
soap to the fingertips to remove the fecal pathogens. This procedure should be
done in the bathroom, because you do not want to wash the possible high
levels of fecal bacteria on your fingertips into the sink where you prepare food
and wash dishes.
Holding Time
Safe
11
4.
5.
6.
7.
8.
spread the fecal microorganisms on the fingertips all over the hands. As
you wash and brush your fingertips, do so under the water. The
microorganisms come off in the running water.
Rinse the soap and pathogenic microorganisms off of the brush and fingers.
When the soap is rinsed off, so are the microorganisms. It is best not to use
antibacterial soaps. They destroy the very important natural resident
microflora in the skin of the hands. These resident microflora keep the
hands healthy, and tend to destroy in 2 to 4 hours, any foreign
microorganisms such as fecal pathogenic bacteria that get onto the skin.
Set the brush down, with bristles up. Allow the brush to air dry. Do not
worry about sanitizing the brush. Rinsing the brush in flowing water also
removes the microorganisms from the brush, just as rinsing your hands in
flowing water removes microorganisms.
Soap the hands up to the wrists a second time with enough soap to build a
good lather.
Work up a good lather.
Thoroughly rinse soap off of the hands and wrists.
Dry hands using paper towels. Drying reduces the number of
microorganisms even further. Do not use a common cloth towel that other
people have used to dry their hands or to wipe up spills of meat juice, etc.
grocery store). Apply it to the washed and rinsed food contact surface,
spreading it with a single-use paper towel. Discard the towel. Let the vinegar
solution air dry on the surface to get the best reduction of surface
microorganisms. Household bleach solutions have been used in the past for
sanitizing purposes. However, bleach is slightly toxic and vinegar is a safer
sanitizing solution. When a surface has less than 100 microorganisms per 8
square inches, it is considered to be sanitized. Note: It is the thorough
washing that makes the difference, not the vinegar solution. Worldwide,
cleaning practices are inconsistent, yet, if food contact surfaces are washed
clean, there is no demonstrated food safety problem.
Slicing or grinding machines must also be cleaned before you use them to be
sure that few microorganisms remain on the surface of the equipment.
When putting away clean equipment, the most important final step is to allow
surfaces and equipment to air dry. Do not lay one wet cutting board on top of
another. The water is trapped and there is always enough food left on food
contact surfaces for the microorganisms to multiply. All utensils and dishes
should be allowed to air dry before they are put away. When surfaces are dry,
there is no moisture present to foster pathogen multiplication and numbers of
pathogens are further decreased.
If you suspect that your equipment and utensils such as knives and cutting
boards became contaminated during storage, it would be wise to wash them
just prior to use, even though you already cleaned, perhaps sanitized, and put
away these items.
Make sure that your knives and cutting boards are clean before use. To clean
dirty knives, serving utensils and cutting boards, first, rinse equipment and
utensils in flowing warm water to remove excess food soil. This step is very
important to reduce microorganisms as much as 1,000 to 1. If you put a dirty
knife or cutting board into a dishpan or sink of detergent water, high levels of
microorganisms are transferred to the water and simply recontaminate other
items being washed. Actually, microorganisms begin to multiply in soapy
warm water after a couple of hours. After utensils and cutting boards are
rinsed, to further remove the microorganisms, wash them by placing them into
a lot of fresh, hot sudsy water. Use a scrub brush to clean the cutting boards,
knives and utensils or any other food contact surfaces that have been
contaminated with raw food. (Do not use a sponge because they tend to
harbor microorganisms and when not in use, permit microorganism growth
due to retention of soil and moisture.) Once the surface is washed and rinsed,
it is safe.
The best way to thaw meat, poultry and fish is to remove the frozen item from
the freezer and place it in the refrigerator on the bottom shelf or lower rack
(i.e., not above cooked-pasteurized or washed food to avoid drippings getting
into the food). Make sure you allow enough thawing time. The food will
begin to spoil during thawing because the spoilage bacteria begin to multiply
slowly at 23F and meat, fish, and poultry thaw at about 28F. This is not a
hazard. Spoilage will continue at a more rapid rate after thawing is completed.
Many people thaw food on the kitchen counter during the day. Food can be
thawed on the counter or in the sink if you make sure that no part of the food
gets above 50F before it is returned to the refrigerator or cooked. Food can
also be thawed in a microwave oven or in water. Food thawed by either of
these methods should be cooked or used within an hour because it gets warm
on the surface.
If you want to sanitize equipment and utensils, the best sanitizer for these
items is very hot (171F or above) water. If you want to sanitize a clean wood
or plastic cutting board or a clean counter, use diluted vinegar. In a small
container, mix 2 parts water and 1 part 5% vinegar (as purchased from the
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
12
It is dangerous to cook partially thawed food because the middle might still be
frozen or unpasteurized, even though the food looks cooked on the outside.
Therefore, it is best to cook food that is completely thawed or still completely
frozen. It is important to measure the interior temperature of food cooked in
this manner, especially if it is a large cut of meat or a casserole. Food may be
safely cooked from the frozen state without loss of quality, however, cooking
time is usually doubled. Do not thaw frozen vegetables prior to cooking. It is
not necessary and spoilage microorganisms will multiply during thawing.
Studies have shown that one can thaw food to 40F and refreeze it as many
times as desired, and then pasteurize it with no safety problems. However, the
quality of these refrozen foods will be reduced.
Washing Fruits and Vegetables
It is rare, but, raw fruits and vegetables can carry dangerous levels of
chemicals (because of pesticides or herbicides applied at the wrong time).
Normally, the hazard is contamination by microorganisms from human and
animal fecal material. Always wash fruits and vegetables before eating them
or using them to prepare other food items. Do not wash them with soap or
chemicals. While some processors use a few chemicals as an aid, these
chemicals only extend refrigerated shelf life. This is why vegetables can be
prepared in California, for example, and sold up to 14 days later throughout
the United States. There is no evidence that chemically washed food is any
safer.
High numbers of spoilage bacteria in raw food will NOT make you sick.
When food spoils microbiologically, the spoilage microorganisms grow on the
surface until they totally cover the surface, perhaps 2 to 3 layers deep. At this
point, surfaces of foods such as meat, poultry or fish feel "slimy", and there
can be 20,000,000 to 50,000,000 microorganisms per gram or per square inch
of food. This is when hamburger smells sour and turns brown, and fish and
chicken turn slimy and have very objectionable odors. The growth of spoilage
bacteria on green onions harvested during a wet growing season causes the
onions to become slimy, and yellow onions to become soft.
If you question whether or not your water is safe, heat it to 160F or above
before washing the vegetables * . Do not wash and wet fruits and vegetables
until just a few hours prior to use, or at most, a day before use. If the surface
of fruits and vegetables is dry, the growth of slime bacteria and mold is
reduced. Do not cut fruits and vegetables until shortly before serving them.
Cutting fruits and vegetables 8 hours or longer prior to use allows
microorganisms to multiply on cut surfaces, and as a result, spoilage occurs
more rapidly.
When spoiled food is cooked above 160F to make it safe, it may have a foul
odor. For this reason, spices and herbs have been added to food throughout
the centuries to mask the off-flavors and off-odors of rotting or partially
spoiled food.
Studies have shown that even double washing does not do much to reduce the
microorganisms on the fruits and vegetables. They may be reduced 100 to 1.
Nonetheless, this must be enough because there is no evidence that people
become ill from eating washed fruits and vegetables.
Most people throughout the world do not have refrigeration units in their
homes. They purchase food at the market in the morning, and cook it well
done, seasoning the food with spices and herbs to mask off-flavors and offodors. The food is eaten at midday. They eat food that does not require
refrigeration for supper. These people do not have food safety problems as a
result of this routine.
To do a good job washing fresh fruits and vegetables, first soak them in a
clean container with clean, cold water. To maintain freshness, use ice water.
Using a clean container is preferable to placing fruits and vegetables directly
into the kitchen sink because the sink may be contaminated. If necessary, a
vegetable brush may be used to scrub the surfaces of fruits and vegetables.
For the second wash, place the items in a colander and run flowing water over
the surface to remove and dilute the microorganisms on the surface. Soaking
without using flowing water is not recommended because microorganisms that
float off of the surface into the water only contaminate the water, and may
reattach on the surface of the food items.
It is only in societies such as ours in the U.S., which have refrigeration and the
practice of cooking ahead and serving days later, that we have complicated our
lives with many more opportunities for foodborne illness. The household that
cooks (especially using a thermometer) and serves fresh food and has no
leftovers has fewer risks and has fewer spoilage problems than a household
that cooks, stores and reheats food days to weeks later. Remember, the
hazardous microorganisms that cause illness or death normally leave no
evidence of their presence in the cooked food, such as off-flavors or off-odors.
Refreezing Food
* If you suspect that your water is unsafe, have it inspected by the proper agency in your area. If it
is unsafe for washing vegetables, it is unsafe for drinking. Probably over 30% of the water in the
U.S. has some microbiological risk, according to the American Water Works Association.
13
Microwave Ovens
To control spoilage, remove as much water as possible from washed fruits and
vegetables. The closer you can get to the natural condition of the fruit, the
better. After washing, delicate fruit (fresh berries) can be placed on an
uncovered tray in the refrigerator where the fruit will get cold, and the surface
will dry, slowing down microbial multiplication. If the surface is wet, the
microorganisms multiply quickly, even in the refrigerator. This breaks down
the food's structure and it becomes mushy.
Always store raw meat, poultry and fish below fresh fruits and vegetables and
any ready-to-eat items. This practice is essential to prevent drip from raw
foods of animal, poultry or fish origin from contaminating any other food
items.
Do not wash raw meat, fish or poultry. Studies have shown that only a few
pathogens and spoilage microorganisms are removed by washing raw meat,
fish and poultry. Because of drip or splash, there is also the danger of
spreading illness-causing microorganisms around the kitchen. A way to
almost double the refrigerated shelf life of fresh meat, fish or poultry is to
blanch the surface for 10 to 15 seconds.
Cooked meat, fish, poultry products and other combination items can be
reheated, covered, with microwave energy. The center temperature of
reheated microwave items should reach 165F. Remember, make sure that
your food is safe before you begin to reheat in the microwave because of the
non-uniform heating and possible survival of vegetative pathogens.
Some people do not have a normal functioning immune system. They are
immune compromised. People with this condition include pregnant women,
infants and young children, the elderly, people taking antibiotics or
undergoing medical treatments such as chemotherapy and radiation, and
people with AIDS. It is important that these people avoid foods that might
contain even low levels of pathogens. Immune-compromised people must
make sure that raw fruits and vegetables have been washed and are fresh, or
they should not eat them.
When you cook food, you are really pasteurizing it to make it safe. Our
ancestors learned to cook food well done because they did not have
thermometers, and if they did not cook their food well, they became ill. They
cooked meat until evidence of the red color was gone, which is above 165F.
As mentioned previously, it must be assumed that all raw food is
contaminated. Pigs are carnivores and may eat rodents in the farmyard, and
thus become infected. They can get into many other sources of pathogens.
Both caged and free-range chickens eat anything on the ground or in the feed
trough, including rodent and insect feces and other bacterially contaminated
objects. Fish and seafood come from contaminated sources. Illnessproducing, infective organisms that are on and in raw meat, poultry and fish
must be inactivated (killed) to a safe level if the food is to become safe for
consumption.
There are a variety of familiar cooking methods that, when used correctly, will
adequately destroy pathogens. These methods include oven cooking, frying,
microwave cooking, wok cooking, grilling and pressure cooking.
Microorganisms can multiply when food is heated too slowly. It is necessary
for safety to cook food from cold to 130F or hotter within 6 hours to prevent
the multiplication of Clostridium perfringens. Covering food during cooking,
as in a roasting pan, prevents what is called evaporative cooling and heat loss
from the surface and ensures that the food is heated evenly. Cooking a whole
pig or cow on a spit over a fire for 12 hours or more is highly risky. Food
cooked in this manner may be cooked safely, if it is cooked well done (all
parts above 160F).
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
Salmonella 100,000 to 1, to a safe level, about less than 1/25 grams. When
preparing food, it is prudent to apply a sufficiently high temperature for a
specified period of time so that Salmonella will be reduced by 5 decimal (5D)
reductions, or 100,000 to 1 per gram of food (105 to 100). Since there are
probably no more than 100 Salmonella per gram, this reduces the Salmonella
to 1 organism per 1,000 grams of food. Note: Some pathogens will always
survive (because there is no "zero" in microbiology). But, they will not be at a
level that poses a real risk if the food has received a 5D destruction.
pasteurization temperature and time. The question then becomes, how to hold
hamburgers at 140F for approximately 8.6 minutes to get a 5D destruction.
This is very easy to accomplish in an oven, but it is difficult to accomplish
with grilled foods.
If you cook a rare hamburger or a soft poached or sunnyside-up egg, your
food item probably will not be adequately pasteurized. Only 1 or 2 grams of
food need to be undercooked to have enough surviving pathogens to cause
diarrhea one or two days later. Be aware of the risk involved in eating undercooked foods. If you eat raw meat regularly, you might have built up a high
tolerance for pathogens such as Salmonella and E. coli. But, do not serve it to
anyone else.
Time, 5D kill
(Hamburger)
86.42 minutes
27.33 minutes
8.64 minutes
2.73 minutes
51.85 seconds
16.40 seconds
5.19 seconds
1.64 seconds
Cook thin, fast-cooked food such as eggs to above 150F, and hold at 150F
for about 52 seconds. Cooking food to over 160F is not necessary for safety.
These are quality issues. For example, cooking turkey dark meat to 185F is
necessary to tenderize the muscle and produce a characteristic odor and flavor.
If poultry reaches a temperature of 160F for a few seconds, it becomes safe.
Each one of the times and temperatures is equivalent. For example, if you
want your food very rare, you can cook it to 130F and hold it at that
temperature for approximately 112 minutes. The food will be exactly as safe
as that food cooked to 160F and held for approximately 5 seconds.
The temperatures and times listed in the table are also sufficient to also
destroy E. coli O157:H7 in food (e.g., ground beef). The FDA recommends
cooking all ground meat products, particularly ground beef, to a temperature
of 155F for 15 seconds. At this temperature, the interior of the ground beef
patty is still slightly pink if the meat is fresh. Juices can be any color. If the
ground beef patty is old, the color of the meat can be brown at 140F. Visual
characteristics should not be used to judge doneness of any product. Center
food temperatures must be measured with a good electronic thermometer.
When foods thinner than 2 inches are cooked on a typical grill, broiler or
griddle to less than medium rare (150F), the data in the table, INTERNAL
TEMPERATURES AND TIMES FOR FOOD PASTEURIZATION, show that it will
require holding the products a few minutes so that the center gets a proper
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
15
beyond the center, not at the center, so that the middle of the coil will be at the
center of the roast.
Note: Many people who sell food thermometers have no idea how they work
and their limitations. We can provide you with a thermometer suitable to your
needs and provide precise information how to use it. See Appendix E (Food
Safety Products and Services) at the end of this booklet if you are interested
in ordering either a thermistor thermometer or a thermocouple thermometer.
To measure food temperature, use a device that will measure the temperature
of thin foods correctly. A device called a thermistor thermometer works
adequately for this purpose. It can measure the center temperature of a thick
item such as a roast or a large casserole. It is important to measure the center
temperature of a thick food because the center will cook slower than the
portions nearer the food's surface. A thermistor thermometer can also measure
the center temperatures of thin foods such as a hamburgers, steaks, fish fillets
or a breast of chicken. The temperature measuring zone at the tip extends
about 1/2 inch up from the tip. The food should be about 1 inch thick and the
thermistor thermometer must remain in the food for about 20 seconds in the
food to get an accurate center temperature reading. The thermistor
thermometer is not always practical when cooking food because waiting 20
seconds for the unit to accurately indicate temperature is usually too long to
wait to get a reading and decide if cooking should or should not continue.
Acidifying foods. Organic acids present in vinegar and lemon juice are very
effective preservatives. Commercial mayonnaise and salad dressings made in
the U.S. are very safe products because of the amount of acid in these
products. These products actually improve the safety of foods to which they
are added. When home-prepared mayonnaise is made with raw ingredients
such as eggs, the final pH (acidity) of the mixed product must be below 4.1.
The acid (vinegar or lemon juice) is used to inactivate any Salmonella from
raw eggs that may get into the mayonnaise. To be on the safe side, buy
mayonnaise and salad dressing from commercial producers who have quality
control departments to assure safety. If you make your own mayonnaise,
make sure that the pH is always less than 4.1. The pH must be less than 4.1
because Salmonella will multiply down to this level of acidity. In order to
allow destruction of Salmonella, the mayonnaise or other acidified food must
be held for 2 days at room temperature before it is used. If the mayonnaise is
held in the refrigerator, it can take from 2 to 3 weeks for the same destruction
of Salmonella, because the acid does not work as quickly.
Mixing foods. Once they are washed and cut, some food ingredients are
ready to be mixed together to make a cold food item, or they are ready to be
cooked or pasteurized. If cooked foods (e.g., macaroni or potatoes) are to be
used in a cold recipe item, they should be cooled to 40F after pasteurization,
before they are combined. If they are cooked and pasteurized and cut up
while still warm, they will be slightly contaminated with Staphylococcus
aureus from the food preparer's hands. If the ingredients are mixed while
warm, the microorganisms will be able to grow as the food cools from, for
instance, 95 to 50F. The hazards associated with this process can be avoided,
if first, the food is correctly cooled to 40F. The food can then be taken from
the refrigerator and mixed with other ingredients. If the temperature of the
entire mixture remains below 50F, Staphylococcus aureus, which may be
present on the hands of the food preparer and get into the mixture, will not be
a problem because it does not produce toxin below 50F. Other pathogens
To get the correct temperature of thin foods like a hamburger being cooked,
the hamburger should be turned over 3 or 4 times during cooking so that it
heats from both top and bottom. When it appears that the hamburger is close
to being at the desired degree of doneness (i.e., 150F center temperature),
turn the hamburger over and immediately push the thermocouple into the food
at a 45 angle. As you push the thermocouple in, take readings. For example,
you will see the temperature go from 170F to 160F to 150F to 140F, and
then start back up again as the tip goes through the center of the food. This is
the correct way to judge the core temperature of food. Do not merely put a
thermometer in food and hope that you have found the cold spot.
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
16
Thick Foods
Raw protein items, more than 2 inches thick and at least 1 inch from
center to surface. Examples of this type of food include prime rib of beef,
turkey, whole poached salmon and a basket of crab. These foods must be
cooked at lower temperatures (225 to 325F) for longer times (1 to 8 hours)
than thinner foods to prevent undesirable factors such as surface burning,
unnecessary shrinkage and water loss before the center reaches a safe
temperature. As a rule, the thicker the food, the lower the cooking
temperature, because there is enough time for the food to brown. Examples
are:
that might get into the food grow very slowly and are not considered to be a
problem if the refrigerated food is consumed within specified times. This
procedure should be used for meat, poultry, fish and vegetable salads. Salad
dressings, because of their acidity, contribute to the safety of mixed salads.
Salad dressings should be cool before being mixed into products in order to
keep the product temperature as low as possible.
Marinades, salad dressings and sauces are often used on raw meat, fish,
poultry or vegetables for flavor. In this process, the marinades will become
contaminated with pathogens from the raw food. Cross-contamination can
occur if this contaminated marinade is used on other food items that will not
receive further cooking. If marinades used on raw foods are to be used as a
sauce to flavor other food items, the marinades must be heated to 160F to
inactivate any potential pathogens before the marinades are added to any other
cooked or raw food items.
1.
2.
3.
4.
When raw foods such as pieces of chicken or fish are dipped in a batter prior
to frying, the batter should be discarded within 4 hours. Raw batters become
contaminated and provide a good media for pathogen multiplication.
Take only small amounts of food out of the refrigerator at a time. Return
these ingredients to the refrigerator to re-cool if you are not going to use them
or cook them within an hour. Keep cold food ingredient temperatures below
50F (as close to 40F as possible), especially when you cut or mix
ingredients several hours prior to serving and eating (e.g., salad ingredients).
This is very important when you prepare large quantities of food.
Spores survive most cooking processes. Large roasts and turkeys are often not
served immediately. If they are held for more than 4 hours below 130F prior
to serving, the spores of the pathogen Clostridium perfringens will have a
chance to germinate and multiply, and can cause diarrhea about 8 hours after
the food is ingested. If the food is held for more than 4 hours above 130F,
the quality deteriorates. Leftovers of thick foods such as large roasts are
difficult to cool and reheat later. Slice large cuts of cooked leftover meat less
than 2 inches thick or 1-inch cubes, and chill the meat to 40F in less than 14
hours. Be very careful of cross-contamination from hands, cutting boards or
utensils after the food is cooled and while it is being converted into a leftover
dish. There will be some contamination of the surface of the food, but if the
food is correctly cooled, this inhibits pathogenic bacteria multiplication.
Thick foods
Thin foods
Stocks, sauces and brews
Fruits, vegetables, starches, cereals, nuts and fungi (mushrooms)
Batters and doughs
Hot combination dishes
Cold combination dishes.
Stuffed meat, poultry and fish products must be prepared very carefully in
order to prevent any foodborne illness due to growth of pathogenic bacteria
(notably Salmonella) in the stuffing. If a raw meat, poultry or fish is to be
stuffed for later cooking, the stuffing should be prepared from cold ingredients
and be at a temperature of 40F before it is placed in the meat, fish or poultry
product. If the product (e.g., a turkey) is to be cooked immediately, it can be
stuffed with warm stuffing. When cooking stuffed meat, poultry and fish
products, both the internal temperature of the stuffing and the meat must
reach pasteurization times and temperatures. For safety and quality, it has
been recommended that stuffings be cooked in a separate casserole or
17
container and then served with meat, poultry, or fish. Unstuffed poultry cooks
faster than stuffed poultry. The time required to cook whole, large poultry
may also be reduced by removing the legs and thighs, and cooking them
separately. Thus, the cavity of the bird is opened up and cooking time is cut in
half because heat can get to the middle.
Hot items can be mixed and heated rapidly. The temperature reached should
always be higher than 160F simply for quality reasons. Heating to this
temperature destroys the vegetative cells. However, the spores survive. If
these types of foods are to be held for a long time after cooking, they should
be held at 130F or more to assure that pathogenic spores are controlled.
Usually, this food is held at 165F for quality considerations. This is the
temperature preference of most people for hot soup and coffee. Hot soups and
beverages should be kept covered to prevent surface cooling and moisture
loss.
Thin Foods
Raw protein items, less than 2 inches thick. Examples of thin items include
small fish and fish fillets, chicken pieces, steaks, shallow pans of casseroles,
pancakes, eggs and grilled sandwiches. These items can be solid or a mix of
ingredients. They can be heated quickly, and therefore are cooked at high
temperatures (250 to 400F) for short periods of time (2 to 40 minutes). The
key to safety is to heat them to an adequate center temperature for sufficient
time to achieve pasteurization and destruction of possibly high levels of
vegetative pathogens. Some of these items require a lot of handling prior to
cooking and can be contaminated with many pathogens. Pasteurize these
foods according to the table, INTERNAL TEMPERATURES AND TIMES FOR
FOOD PASTEURIZATION, on page 15.
Egg and heavy cream sauces, however, do not tolerate long hot holding times.
The quality of these products is best if they are kept hot in a double boiler.
Again, the temperatures are 130F for safety and 165F for quality.
Do not thicken soup and sauce items until about 10 minutes before service
because it is difficult to keep thickened sauces at a uniform temperature. Hot
stew, stocks, soups, and sauces are difficult to cool, so the goal is to minimize
leftovers. Any leftovers must be cooled from 135 to 41F in less than 6 hours
(FDA recommendation). The USDA recommendations state that, if the food
is cooled from 120 to 55F in 6 hours, followed by further continuous cooling
to 40F, the food will be safe. This is about 14 hours from 120 to 40F. To
accomplish either the FDA or USDA standard, food should be cooled in
containers at a depth of less than 2 inches.
Fresh fruits and vegetables must be washed to remove dirt, chemicals and
contamination from soil, irrigation water and human handling. Once washed,
these food items should be cooked in 1 hour or dried and chilled if they are to
be used raw in cold salads and fruit dishes. Most fruits are sufficiently acidic
to prevent the survival and growth of most pathogens. Items to be cooked or
served later and that do not contain much acid (i.e., some melons and many
vegetables) need to be kept cold (less than 40F) and/or dry, and packaged
loosely so that they are not air tight. Cooked and uncooked vegetables that are
stored air-tight, or more than 1 inch deep, above 50F, can become hazardous
due to the growth of Clostridium botulinum and subsequent toxin production
(e.g., vacuum packaged cole slaw or chopped broccoli mix). Some packages
of produce such as mushrooms have 2 1/8-inch holes in the plastic wrap. The
holes allow oxygen in the air to get inside the package and prevent the growth
After cooking, thin food items should be held above 150F or eaten within 30
minutes, for quality. (For safety, it is above 130F for as long as you want.)
Otherwise, place the items in the refrigerator within 2 hours in layers less than
1 inch thick so the food will cool before spores within the food grow out and
multiply.
Stocks, Sauces and Brews
This category includes hot items such as beef broth, gravies, soups, tomato
sauce, stocks, jams, jellies and custards, and cold items such as icings, cold
salad dressings, sauces, batters, eggnogs, ices and ice cream.
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
18
of Clostridium botulinum, which grows without air. After cooking fruits and
vegetables and cereal items such as pasta, keep them above 150F for quality,
130F for safety, if you need to hold them, or cool the food to 40F in less
than 14 hours (USDA) [to 41F in 6 hours (FDA)]. When most grains and
cereals are cooked, the spores survive, and if the food is allowed to sit at 80 to
120F for 9 to 12 hours, the food may cause foodborne illness resulting in
diarrhea and vomiting. All cooked cereal products should be eaten within 2
hours after preparation to ensure safety. Be aware that nuts and seeds,
although not typically washed, might contain shell fragments, low levels of
pesticides, and mold toxins. Also, coconut can be contaminated with
Salmonella.
cool to 40F in less than 14 hours. Food prepared for use later, or leftover
foods, should be stored at 40F and used within 5 days.
Cold Combination Dishes
These items are made of the same food items as hot combinations but are
prepared with cold ingredients, are kept cold, and are mixed with an acidified
dressing (pH less than 4.1). Examples include tuna salad, egg salad, macaroni
and ham salad, cold meat and cheese sandwiches. Items that require cooking
prior to mixing, such as pasta, potatoes or meat items, should be cooked
separately and chilled separately to 40F. Uncooked items such as fruits
should be washed and kept at 40F prior to mixing.
Cold combinations can become very hazardous if not handled and stored
properly to limit the growth of pathogens. Prepare salads with ingredients that
have been pre-cooled to 40F. Many ingredients, such as pasta and potatoes,
can be cooled in ice water. If warm ingredients are used, there is a high risk
for growth of illness-producing and spoilage microorganisms when mixed
ingredients cool because they are usually prepared in large amounts and in
very large containers. Mixing should be done quickly so that the ingredients
do not warm above 45F. During preparation, use sanitized utensils and
containers. Contaminated spices and herbs will not cause a problem if mixed
into cold ingredients. Avoid having leftovers by making small batches. Once
prepared, cold combination dishes should be refrigerated at 40F. These items
can be stored easily in zipper-type plastic bags, which will give maximum
surface cooling.
Unbaked batters and doughs can be hazardous if not handled properly. Most
of the ingredients, particularly raw eggs, contain infective microorganisms and
spores. Batters (i.e., pancake or dipping batters), if not acidified to a pH of
less than 4.1, must be stored until used at less than 40F to prevent
multiplication of pathogens. Do not eat raw batters. They may contain high
levels of Salmonella. Once baked, these items pose little threat because they
lose moisture, and the center of the food reaches temperatures that decrease
the number of pathogens to a safe level. Fillings containing milk, meat or
other high-protein foods need to be cooled to 40F in less than 14 hours before
using them with baked goods. Egg white meringue on pies can be hazardous
because of Salmonella in the eggs. During baking, the point where the
meringue touches the pie surface must reach 160F for more than 1 second.
Both pie and meringue need to cool to 40F within 14 hours (USDA) [to 41F
in 6 hours (FDA)].
When you prepare cold salads with pasteurized ingredients, it is quite easy to
get a final pH of below 5.3. Add a little lemon juice, vinegar, or red or white
wine. While this pH does not assure safety, microorganisms grow much
slower at this pH range vs. a more neutral pH range of 6 to 7. Items that are
acidified to less than pH 4.1 with vinegar, lemon juice and other additives can
be stored for long periods of time. In fact, they are room-temperature safe.
Since there is no safety threat, only quality problems will occur due to the
multiplication of spoilage microorganisms.
These dishes are prepared with combinations of meat, fish, sauce, starch,
vegetables and/or fruit. Examples include beef stew, chicken a la king, chili,
lasagna meat pies, spaghetti sauce and meatballs. When preparing these items,
follow the cold food temperature rules and keep ingredients at less than 40F
until they are ready to be cooked. When cooked, they must get over a center
temperature of 130F in less than 6 hours and then be heated to an adequate
pasteurization time and temperature. When these items are created from
multiple ingredients and handled for extended times in a warm kitchen
environment, they can become hazardous if they are below 130F. Once these
items are prepared, they should be kept at 150F. (A temperature of 130F is
safe, but the temperature is too cool to please most people.) Serve and eat
food items within 2 hours for quality, or cover less than 2 inches thick and
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
the food covered. Otherwise, evaporative cooling from the food will drop the
food temperature about 10F below the heat source temperature. For quality,
people like their hot food hot, so keep hot entrees above 150F, and soups and
gravies above 165F. Food that is above 170F can cause burn injury to the
mouth. Warn people about hot food that is at or above this temperature.
put it in a zipper-type plastic bag and pack it so that it is less than 2 inches
thick.
Do not put food to be cooled on a solid shelf in the refrigerator, or stack pans
or packages of hot food in a pan; 75% of the heat comes from the bottom of
the pan, and cooling time is almost doubled if cold air does not flow across the
bottom of the pan.
Remember to prepare food progressively, that is, as you need it, to avoid long
holding times. Holding hot food too long at high temperatures deteriorates the
quality of the food and reduces the nutritional value. For example, holding
broccoli and cauliflower for 30 minutes at 150F can reduce the vitamin C
content of these vegetables by as much as 50%. Hot food will maintain
optimum quality and nutrient value if eaten within 30 minutes after
preparation. It is always a good idea to keep hot food covered to prevent
evaporative cooling and heat loss. Keep serving utensils in the hot food to
maintain sanitation of the utensils.
You can start by cooling food on the counter until it reaches 130F, the
temperature at which spores begin to germinate and multiply. Food will cool
to this temperature within a short time, usually 15 to 30 minutes. As soon as
the food reaches 130F, it should be placed into the refrigerator for cooling.
Try to put the food to be cooled in a area of the refrigerator where there is
maximum air flow. Glass, metal, paper (not thick cardboard) or plastic
containers may be used. The thickness or depth of the food being cooled is
the most important factor.
Avoid touching hot, pasteurized or ready-to-eat food with your hands. If you
must, be sure to first wash your hands, fingertips and under the fingernails to
remove pathogens. Note: To avoid contamination when tasting or evaluating
foods, use a clean spoon or fork to serve or dip into the product. Place the
sample in a bowl or on a plate. Taste using a clean spoon or fork.
Cover the food if you can. If you leave the food uncovered, it cools faster, but
the surface becomes contaminated with mold and bacteria, and will spoil more
rapidly.
Ice can be used very effectively for cooling. If you are making a gravy or
cream sauce that you want to use later, make it with half the amount of liquid.
After it is cooked and thick, add the other half of the liquid as ice or frozen
liquid such as milk. Stir. The sauce will come to a safe 40F temperature in 5
minutes as the frozen liquid melts. Then, it can be stored safely in any size
container in the refrigerator. When cooling ingredients such as chicken breast,
noodles, diced potatoes, etc. for salad, you can cool them in iced water very
easily and effectively. After these items are cold in a few minutes, shake off
the excess water and make the salad.
Serve cold foods cold, below 50F (preferably at 40F). To maintain a cold
temperature as long as possible, use a cold or ice-lined container if you are
serving cold foods in a warm, ambient temperature (i.e., on a warm summer
day). Do not let cold foods remain out of the refrigerator too long. Use
progressive service and serve only what will be eaten in the next hour.
Measuring surface temperatures of food is useful if you have a hot or cold
food item that you are holding hot or cold, and if you want to find out if the
surface is losing its heat or cold. You can do this with a thermocouple
thermometer.
Many of these points have been covered, but let's review them because they
are critical. After food is pasteurized, there is still the critical problem of
spores that survive cooking. All cooked or pasteurized food (e.g., vegetables,
pasta, rice, meat, poultry, fish, etc.) is contaminated with pathogenic spores
that will outgrow and multiply if food is not cooled to 40F in less than 14
hours (USDA) [to 41F in 6 hours (FDA)]. A very easy way to cool food is to
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
For both quality and safety, refrigerated leftovers at 40F must be eaten within
7.5 days. If the food temperature is 45F, then leftovers should be eaten
within 4 days.
A very simple, effective way to cool and store hot leftovers, to include soup
and gravy, is in zipper-type plastic bags. The closure needs to be absolutely
20
secure for liquids, but if you handle the bags carefully after filling and closing,
the bags cool very well because they have such a large surface exposed to the
refrigerated air when laid flat.
If the food will not be consumed within this period of time, it should be
thrown out. Again, this is an estimation of when the pathogens could have
multiplied 10 times.
Never mix leftover food with fresh food in the same container because the
bacteria in the leftovers can contaminate the fresh food. As a result, the
combined food item spoils even faster. If there are even a few pathogenic
bacteria in the leftover food, they have a chance to grow again.
Hot items will be more of a problem. If they are at more than 130F when
they come from the hot picnic storage chest, the spores have not started to
germinate and grow out. If the hot food is in the sun on a table, it may be
between 105 and 115F, the fastest pathogen-multiplying temperatures. After
4 hours, the food should be thrown out. If the food is 75F, you have 11
hours. If you want to save hot leftover food that has been left out, handle it
the best you can. Eating these leftovers is not recommended. Do NOT serve
them to children or elderly people, or anyone who is immune compromised.
IX. Cleaning Up
Use cleaning procedures previously described in Use Clean Equipment,
beginning on page 12. Remember to first rinse or flush all soiled or dirty
surfaces with water so that major amounts of soil are removed. This practice
keeps the detergent solution used to wash equipment and surfaces cleaner,
with lower bacteria levels. Surfaces will be no cleaner than the detergent
solution used to wash them.
Dry items such as cookies, potato chips, etc. do not need to be kept cool.
Their quality may deteriorate, but they will remain safe. Iced desserts, on the
other hand, should be treated as perishable items.
X. Picnicking
If you have a normal immune system, you need not worry about eating at
someone else's home, unless you have a reason to suspect that the food was
not prepared according to the rules in this booklet, or if the food has been left
at room temperature for more than 4 hours. The quality will have deteriorated
during that time, and some foods could have become unsafe. Get your food
the first time through a buffet line, and do not go back 4 hours later unless you
know there is fresh food. Food that is intended to be hot should be HOT,
150F. If it is intended to be cold, it should be COLD, less than 45F. If in
doubt about a food item, eat something else. Remember, the person preparing
and serving the food is legally responsible for the safety of the food.
If you are going to take cold food to a picnic, follow these food safety rules:
1. Make sure the food time and temperature have not exceeded the limits
shown in the table, MAXIMUM HOLDING TIMES AND TEMPERATURES, on
page 11, when you begin to serve.
2. Eat it or throw away food within 4 hours after it is put out. This time is an
estimated limit based on the time and temperature factors that can cause 10
multiplications of pathogenic microorganisms.
Pack the food in ice and transport it in a cooler to keep it at 40F or below. A
typical cooler with 1 pound of ice per pound of food should remain cold
enough for about 24 hours. Raw meat, poultry and fish should be packed so
that juices will not leak onto ready-to-eat food.
If you want to save leftover picnic food, put out as little as possible at one
time and use it up before more is taken out of the cooler. Again, a zipper-type
plastic bag is a good package to use for this food because it is thin.
You can check the temperature of what is left. Follow the guidelines for safe
food shown in the table, MAXIMUM HOLDING TIMES AND TEMPERATURES, on
page 11. If the food is at 60F or less and there is ice in the cooler, you can
safely repack it less than 1 inch thick, provided you can get it home and in the
refrigerator in less than 1 hour. It should be eaten the next day at the latest, or
frozen immediately. Remember, salad with mayonnaise (and acid) will be less
of a problem than cold, sliced beef, chicken or turkey.
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
21
If you need a longer time period to get food home or before the food is
consumed, choose cold food (less than 40F) that you can eat cold or can
reheat. If this is the case, keep the food as close to 40F as possible and eat it
within 7.5 days for quality.
1. Their attitude toward food safety (i.e., all raw and dried food has pathogens
that they must control). Safety must be their first concern.
2. They know and can describe how to control the hazards.
a. They have a thermocouple and use it to assure safe food.
b. How to wash fecal pathogens off of their fingers.
c. How to clean cutting boards and knives.
d. How to pasteurize food. How to keep food hot.
e. How to cool food.
f. How to make cold mixed recipes such as chicken salad.
g. How to "clean as they go."
3. They have trained their employees to perform with zero food safety
defects.
4. They coach, supervise and continually improve employee performance.
People usually do not think about food safety when they dine out, unless they
have had a number of bad experiences. Certainly, they are less likely to return
to a restaurant that they suspect caused them to become ill.
Most restaurants have no HACCP food safety programs. They follow the
FDA Food Code and state and local food codes, and they look clean, but that
has little to do with food safety. If the outside of the restaurant is not
maintained, the toilet facilities are dirty, and the dining area is dirty, it is a risk
to eat at that restaurant. While these factors have nothing to do with safety,
they show that the owner and manager do not understand the basics of good
foodservice management. If they do not know how to meet these basic
requirements for customer satisfaction, there is a poor chance that they will
serve safe food. Even when you go into a clean facility, if the hot food is cool
and the cool food is warm, stop. Do not eat this food unless you really do not
care about becoming ill.
Having completed this food safety booklet, you know as much about food
safety as many restaurant managers. Ask the manager of your favorite
restaurant if the restaurant has a HACCP food safety assurance program. Just
as with the HACCP criteria listed in XII. Catered Food, on page 22, the
restaurant operator or manager on duty should tell you about the restaurant's
employee training program. When you talk with employees, they should
know the information in this booklet. If they say that management gave them
no food safety training, dine elsewhere. Remember, the food employee, just
as you are when you prepare food at home, is the critical control point for food
safety.
If you ask to take your leftover food home in a "doggie bag," remember, the
food is already somewhat cool. Eat it within 2 hours, or put it into the
refrigerator in a thin layer less than 1 inch thick as soon as you get home.
Remember, spores are outgrowing in this food.
Be aware of any allergies you may have. Ask the wait person about
ingredients used to prepare food items that you may want to order. This
includes food chemical ingredients such as monosodium glutamate or
aspartame, or the presence of specific foods such as milk, eggs, wheat flour,
* A program whereby the manager, through employee training, support and enforcement, assures
that the food produced by his/her organization is consistently safe and provides customer
satisfaction.
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
22
fish or nuts, which can cause violent reactions and even death for some
people. The wait person should not guess at ingredients. It would be wise for
people with specific allergies to ask the cook, who should then look at the
recipe or ingredient lists on the labels of the food used in the recipe.
e. Store raw meat, fish and poultry items in the refrigerator below washed,
pasteurized and ready-to-eat items.
f. Store chemicals in a separate area, away from food items.
g. Look for hard foreign objects in the food.
4. Preparation
a. Make sure that all food contact surfaces such as knives and cutting
boards are washed before use.
b. Wash your hands using the double hand wash method with a fingernail
brush prior to handling food.
c. Make sure that raw fruits and vegetable items are safe by double
washing them in safe water prior to cutting, mixing, serving or eating
them.
d. Food items that require cooking must be cooked so that they reach
pasteurization temperatures for a given period of time. The lower the
pasteurization temperature, the longer the food must be held at that
temperature. Use a thermistor or preferably a thermocouple
thermometer to verify pasteurization temperatures.
e. Food items that need to be cold must be no more than 2 inches thick
and returned to the refrigerator as soon as possible after preparation.
f. Make cold combination items such as tuna salad with ingredients precooled to 40F. Immerse food such as hot macaroni or cubed potatoes
for potato salad in water with ice for rapid cooling.
g. Avoid cross-contamination of food products. Keep work surfaces and
equipment clean by using the "clean-as-you-go" method. Use a scrub
brush as much as possible. Avoid sponges. Always clean food contact
surfaces when working with different food items, particularly between
preparing raw and cooked food items. Keep your hands clean with a
single hand wash, particularly after handling unwashed or
unpasteurized raw food.
h. For cooked foods, pasteurize to sufficient times and temperatures to
ensure the destruction of pathogenic vegetative cells. Cover foods
cooked in a microwave oven to ensure uniform heating of the surface.
5. Serving
a. Serve food as soon as possible after cooking. Keep food above 130F
for safety and 150F for quality. If the temperature is less than 130F,
in the 80 to 120F temperature range, use it within 4 hours or throw it
out. Follow the table, MAXIMUM HOLDING TIMES AND TEMPERATURES,
on page 11.
b. Avoid cross-contamination of ready-to-eat food by using clean serving
utensils and by keeping your hands clean.
If you are immune compromised, and the food establishment has no HACCP
program, do not eat cold buffet food or from salad bars. Eat these foods as
home, where you know how they are prepared. Eat hot food when you dine
out, or cold food such as cheese and commercially prepared deli meat on a
sandwich.
XV. Summary
This booklet has described in detail what you must do to control the
pathogenic substances in food, and why. Below is a brief summary.
1. At home
a. Make sure that you use tested, safe water, or get tested, safe water.
b. If you use a septic system, be sure that it cannot leak into the water
system.
2. When shopping
a. Choose raw produce items that appear fresh. They should not be
overripe, too limp, too wet, or bruised or injured.
b. Choose raw meat, fish and poultry that appear fresh (good color, firm
texture, absence of slime and strong odor). Observe sell-by / use-bydates on these products. Place these items in a plastic bag to prevent
drippings from getting on other purchases.
c. Observe the use-by date on all products, including frozen items.
d. Do not purchase unsealed, broken packages or cans with swollen or
dented seams.
e. Make certain that all chemical items (cleaners, soaps, air fresheners,
etc.) are tightly sealed to avoid leakage. Pack chemical items
separately from food items.
f. Pack frozen and refrigerated items together in order to maintain their
cold temperature.
g. If you have a long ride home, you may want to bring a cooler in which
to pack cold items in order to maintain their temperature.
3. After shopping, unloading groceries in the home
a. Store items as soon as possible.
b. Freeze or refrigerate cold items.
c. Keep unwashed produce separate from washed produce.
d. Do not wash fruits and vegetables until you are ready for them.
C&F:homecook/home-2006-2col-clr-forpdf- rev 10/30/08 print 10/30/08 HITM 1994 Jun 06 edition
23
c. Cover hot foods to keep the surface hot and to prevent surface
evaporation.
REFERENCES
6. Leftovers
a. Cool and store leftovers as soon as possible. Very hot items can be
cooled at room temperature for approximately 30 minutes, to 130F,
prior to being refrigerated. Frequent stirring accelerates the cooling at
this stage.
b. Place hot items in a thin layer, no more than 2 inches (1 inch center to
surface), in a shallow container so that they will cool safely in the
refrigerator, preventing spore outgrowth. Place the container on wire
refrigerator shelves to allow air to flow across the bottom of the
container of cooling food. This practice allows food to cool twice as
fast as sitting on a solid shelf. It is best to cover hot food to keep the
surface clean. If the temperature on your porch or in your garage is 25
to 40F, and you have a fan, you have a "blast cooler." Put covered
food about 4 inches away from the front of the fan in this cold spot, and
food will cool 3 times faster than it would cool in your refrigerator.
c. Never add leftover food to fresh food.
d. Use ready-to-eat foods and leftovers if they have been handled
carefully, within 7.5 days when stored at 40F in a refrigerator.
e. If you reheat food, remember, if toxin was produced in the cooked food
due to improper handling, reheating will not make it safe. "If in doubt,
throw it out," if you are unsure about how it was handled. NEVER use
your nose, eyes or taste buds to judge the safety of food. Use them to
judge the taste, texture and overall quality.
Baker Jr., A.R., E.D. Ebel, R.M. McDowell, R.A. Morales, W.D. Schosser, and R.
Whiting, Salmonella Enteritidis risk Assessment Team, Salmonella Enteritidis
Risk Assessment: Shell Eggs and Egg Products. Washington, D.C. United
States Department of Agriculture, June 12, 1998.
Benenson, A.S., ed. 1995. Control of Communicable Diseases in Man. 16th edition.
American Public Health Association. Washington, D.C.
CAST (Council for Agricultural Science and Technology). 1994. Foodborne
Pathogens: Risks and Consequences. Task Force Report No. 122. CAST. 4420
West Lincoln Way. Ames, IA.
Cliver, D.O., ed. 1990. Foodborne Diseases. Academic Press, Inc. New York, NY.
Doyle, M.P., ed. 1989. Foodborne Bacterial Pathogens. Marcel Dekker. New York,
NY.
FDA. 2001. Food Code. U.S. Public Health Service, U.S. Dept. of Health and
Human Services. Washington, D.C. http://www.cfsan.fda.gov/~dms/fc01toc.html.
International Commission of Microbiological Specifications for Foods (ICMSF).
1978. Microorganisms in Foods 1. 2nd edition. Their Significance and
Methods of Enumeration. University of Toronto Press. Toronto, Canada.
International Commission of Microbiological Specifications for Foods (ICMSF).
1986. Microorganisms in Foods 2. 2nd edition. Sampling for Microbiological
Analysis: Principles and Specific Applications. University of Toronto Press.
Toronto, Canada.
International Commission of Microbiological Specifications for Foods (ICMSF).
1986. Microorganisms in Foods 4. Application of Hazard Analysis Critical
Control Point (HACCP) System to Ensure Microbiological Safety and Quality.
Blackwell Scientific Publications. Palo Alto, CA.
International Commission of Microbiological Specifications for Foods (ICMSF).
1996. Microorganisms in Foods 5. Microbiological Specifications of Food
Pathogens. Blackie Academic & Professional. New York, NY.
International Commission of Microbiological Specifications for Foods (ICMSF) 1998.
Microorganisms in Foods 6. Microbial Ecology of Food Commodities. Blackie
Academic & Professional. New York, NY.
International Commission of Microbiological Specifications for Foods (ICMSF) 2002.
Microorganisms in Foods 7. Microbiological Testing and Food Safety
Management. Kluwer Academic Plenum Publishers. New York, NY.
Jay, J.M. 1996. Modern Food Microbiology. 5th edition. Chapman & Hall. New
York, NY.
Mead, P.S., Slutsker, L., Dietz, V., McCaig, L.F., Bresee, J.S., Shapiro, C., Griffin,
P.M., and Tauxe, R.V. 1999. Food-related illness and death in the United
States. Emerg. Inf. Dis. 5(5) 607-625.
(http:/www.cdc.gov/ncidod/eid/vol5no5/mead.htm).
24
Mossel, D.A.A., Corry, J.E.L., Struijk, C.B., and Baird, R.M., 1995. Essentials of the
Microbiology of Foods. John Wiley & Sons. New York, NY.
National Research Council. 1985. An Evaluation of the Role of Microbiological
Criteria for Foods and Food Ingredients. National Academy Press. Washington,
D.C.
Pierson, M.D. and Corlett, D.A. Jr., eds. 1992. HACCP Principles and Applications.
AVI. New York, NY.
Taylor, S.L. and Scanlan, R.A. 1989. Food Toxicology. A Perspective on the
Relative Risks. Marcel Dekker, Inc. New York, NY.
USDA FSIS. 1999 (June). Appendix B: Compliance guidelines for cooling heattreated meat and poultry products (stabilization).
http://www.fsis.usda.gov/oa/fr/95033F-b.htm.
25
APPENDIX A
APPENDIX B
CHEMICAL HAZARDS
Poisonous Substances
Toxic plant material
Intentional (GRAS) food additives (added in excess)
Chemicals created by the process
Agricultural chemicals
Antibiotic and other drug residues in meat, poultry, and dairy products
Unintentional additives
Sabotage
Equipment material leaching
Packaging material leaching
Industrial pollutants
Heavy metals
Radioactive isotopes
Material
Buckshot
Screening
Pits
Bones
Whole spices
and herbs
Glass
Metal pieces
Nutrition
Excessive addition of nutrients
Nutritional deficiencies and/or inaccurate formulation of synthesized
formulas
Anti-nutritional factors
Destruction and unnecessary loss of nutrients during processing and storage
Inaccurate nutritional labeling
Insulation
Plastic
Personal effects
26
Pieces of wood
Insects and
rodents, their
parts and
excreta
Potential Injury
Sources
Wild game, ground beef
Grain and cereal processing
Fruits (e.g., cherries, plums,
olives)
Vegetables, cereals (from
harvesting areas)
Meat, fish, and poultry
(improper processing)
Bay leaves, peppercorns, whole
all-spice left in products after
preparation
Bottles, glasses, light fixtures,
glass bowls and covers, etc.
Broken utensils; metal staples
and nails from cardboard boxes;
bolts, screws, and other
equipment parts; metal shavings
from cans caused by sharp can
opener; bits of steel wool
Toothpicks, wooden skewers,
pieces of building material,
twigs
Construction material
Packaging material, construction
material
Stones or settings from rings,
earrings, beads, or other jewelry;
buttons, pins, safety pins; tie
clips and tie tacks; gum,
cigarettes and ashes; hair; BandAids; artificial fingernails,
contact lens; pens, pencils;
threads of cloth
Entrance of insects and rodents
from surrounding environment
or in packaging material; failure
to keep facility clean
APPENDIX C
PATHOGENS IN FOOD
FOOD
Fin fish
Shellfish
Spices
PATHOGENS
Toxin and/or spore
Infective
producers
Salmonella spp.
Campylobacter jejuni
Escherichia coli
Yersinia enterocolitica
Listeria monocytogenes
Trichinella spiralis
Salmonella spp.
Vibrio spp.
Yersinia enterocolitica
Hepatitis A virus
Salmonella spp.
Vibrio spp.
Yersinia enterocolitica
Shigella spp.
Hepatitis A virus
Norovirus
Salmonella spp.
Listeria monocytogenes
Shigella spp.
Hepatitis A virus
Norovirus
Giardia lamblia
Salmonella spp.
Aflatoxins (mold)
Hepatitis A virus
Norovirus
Salmonella spp.
Salmonella spp.
Campylobacter jejuni
Escherichia coli
Yersinia enterocolitica
Listeria monocytogenes
Staphylococcus aureus
Clostridium botulinum
Clostridium perfringens
Bacillus cereus
Staphylococcus aureus
Clostridium botulinum
Microbial by-products
(Histamine poisoning)
Staphylococcus aureus
Clostridium botulinum
Microbial by-products
(Paralytic shellfish
poisoning)
Clostridium botulinum
Staphylococcus aureus
Bacillus cereus
Clostridium botulinum
Clostridium perfringens
Bacillus cereus
Clostridium botulinum
Clostridium perfringens
Bacillus cereus
Staphylococcus aureus
Clostridium perfringens
Bacillus cereus
Staphylococcus aureus
27
Median
Duration
(days)
Salmonella spp.
Usually 2 to 5
Abdominal pain, diarrhea, chills, fever, nausea, vomiting, feeling of days. Some 10
ill health, loss of appetite.
days or longer.
Onset time = 6 to 72 hours
APPENDIX D
ILLNESSES OR DISEASES
ATTRIBUTED TO FOOD
Cause of Illness or Disease, Symptoms and Onset Time
Shigella spp.
Abdominal pain, diarrhea, stools may contain mucous and blood.
Onset time = 1 to 7 days
Median
Duration
(days)
A day or less
Poisonous mushrooms
Both gastrointestinal and neurologic symptoms, may be fatal.
Onset time = a few minutes to hours
Days to weeks
Microbiological
Fish toxins (PSP, ciguatera and others)
Both gastrointestinal and neurologic symptoms, may be fatal.
Onset time = a few minutes to hours
Bacillus cereus (emetic toxin)
Nausea, vomiting, occasionally diarrhea. May resemble S. aureus
intoxication.
Onset time = 1/2 hour to 5 hours
Clostridium perfringens
Abdominal pain, watery diarrhea.
Onset time = 8 to 22 hours
Days to weeks
Streptococcus (Group A)
Sore throat, fever, nausea, vomiting, rhinorrhea, tonsillitis,
sometimes a rash.
Onset time = 1 to 3 days
Days to months
In those who
survive, respiratory
paralysis may
last weeks to
months
Days to a
weeks
Listeria monocytogenes
Fever, headache, nausea, vomiting, diarrhea precede complications
of stillbirths, meningitis, encephalitis, sepsis.
Onset time = 4 to 21 days
Vibrio cholerae
Abdominal pain, nausea, vomiting, diarrhea, fever, chills, and
headache.
Onset time = 1 to 3 days
Days to years
Vibrio parahaemolyticus
May cause profuse watery diarrhea and dehydration, fever.
Onset time = 2 to 5 days
Yersinia enterocolitica
Gastroenteritis with diarrhea, and/or vomiting; fever and abdominal
pain are common symptoms. May mimic appendicitis.
Onset time = 1 to 3 days
Viruses
Hepatitis A virus
Fever, general feeling of ill health, loss of appetite, tiredness,
nausea, abdominal pain, jaundice.
Onset time = 10 to 50 days
Norovirus
Nausea, vomiting, abdominal pain, diarrhea, low grade fever,
chills, general feeling of ill health, loss of appetite, headache.
Onset time = 16 to 48 hours
28
Less than a
week
Days
2 to 5 days
Days to weeks
Weeks to
months
48 hours
Median
Duration
(days)
Weeks to years
Weeks to years
References
Benenson, A.S. 1995. Control of Communicable Diseases in Man. 16th edition. American Public Health
Assoc. Washington, D.C.
CAST (Council for Agricultural Science and Technology). 1994. Foodborne pathogens: Risks and
consequences. Task Force Report No. 122. CAST. 4420 West Lincoln Way. Ames, IA.
Doyle, M.P., ed. 1989. Foodborne Bacterial Pathogens. Marcel Dekker, Inc. New York, NY.
FDA. 1993. HACCP. Regulatory Food Applications in Retail Food Establishments. Dept. of Health and
Human Services. Division of Human Resource Development, HFC-60. Rockville, MD.
IAMFES. 1987. Procedures to Investigate Foodborne Illness. 3rd edition. Ames, IA.
Murray, P.R., Baron, E.J., Pfaller, M.A., Tenover, F.C., and Yolken, R.H. 1995. Manual of Clinical
Microbiology. 6th edition. American Society for Microbiology. Washington, D.C.
29
APPENDIX E
30
F
250
165
160
155
150
145
140
135
130
Heat
<6 hrs.
Cool
<2 inches
deep
115
110
105
100
95
90
85
80
75
70
65
60
55
50
45
41
40
35
30
<30
28
23
14
170
161
160
150
140
130
115
97
DANGER
ZONE
59
50
44
41
38
30
28
25
15
0
-40
* Reduces Salmonella
in wet food 100,000 to 1
(105 to 100)
10 multiplications of pathogens
F
250
127.5
FOOD QUALITY
Commercial food
sterilization
31
FOOD SAFETY
Commercial sterilization of food
Clostridium botulinum types A and B spores
destroyed in 3 minutes
Skin instant burn
15-second holding; 10-day shelf life 40F
Salmonella 5D* pasteurization in 5.2 seconds
Salmonella 5D* pasteurization in 52 seconds
Salmonella 5D* pasteurization in 8.6 minutes
Food is safe
Salmonella 5D* pasteurization in 86 minutes
Cool food to 40F in 14 hours (USDA),
2 inches deep.
Highest growth temperature for a pathogen
(Clostridium perfringens)
Highest growth temperature for Salmonella
and most pathogens
Salmonella and Staphylococcus aureus
multiply once every 20 minutes
Clostridium perfringens begins to multiply
Clostridium botulinum types A and B, and
Staphylococcus aureus begin to make a
toxin
Cook food from this temperature to above
130F within 6 hours
Staphylococcus aureus begins to multiply
Salmonella begins to multiply
Clostridium botulinum type E begins to
multiply
Some pathogenic bacteria begin to multiply.