Professional Documents
Culture Documents
Chatney and Sauses PDF
Chatney and Sauses PDF
Introduction
The preparation of chutneys and sauces is a well known method of preserving fruit and
vegetables. The basic principles of the preservation method are the addition of sugar and
acid (acetic acid or vinegar) combined with concentration of the mixture by heating to reduce
the water content. This technical brief describes how to make chutneys and sauces. Other
technical briefs describe how to make lactic acid-fermented pickles.
A range of fruit and vegetables can be used to make chutneys and sauces. Often tomatoes
are used as a base ingredient as they are acidic. You can add other fruit and vegetables
and a range of herbs and spices according to local taste and availability.
Chutneys and sauces are safe products that have a fairly long shelf life due to the
combination of high acidity and low moisture content. They can be made without any
specialist equipment so are suitable for preparation at the home level. A pulper or juicer is
needed to make sauces. Both a pH meter and refractometer are useful pieces of equipment
that are used to test for the acidity and total solids content of sauces. However they are not
essential for making sauces and chutneys.
Chutneys
Chutneys are thick, jam-like mixtures that are made from a variety of fruit and vegetables,
with added vinegar, sugar and spices. They tend to be sweeter than pickles. The mixture is
heated to reduce the moisture content. Any edible sour fruit or vegetable can be used to
make chutney.
Vinegar and sugar are often quite expensive ingredients, which make the chutney expensive
to make. Sometimes it can be more cost effective to make lactic acid fermented pickles that
are made by adding salt to vegetables and allowing them to ferment (see the technical brief
on lactic fermented pickles).
Quality control
When preparing a chutney or sauce, it is important that the correct levels of acidity and total
sugar content are achieved, to ensure that the product does not spoil during storage. The
preservation index is a measure of the combined acidity and total solids. It is calculated
according to the following formula:
Added ingredients
Spices
You can add a range of spices to chutneys and sauces to suit your taste. Any spices you use
should be clean and in good condition. Some need to be roasted before use. If you are
making products for sale, you need to make sure that you use the same recipe formulation
and add EXACTLY the same amount of spice to each batch that you make. Always use the
same measuring spoon or container.
Chemical preservatives
Sodium benzoate is sometimes added to sauces and purees to help preserve the products
after the bottle has been opened. Some consumers do not like additives such as this, so
prefer to buy products that do not contain them. Make sure that you do not add too much
benzoate as it gives the product a bad taste. All countries have maximum permitted levels
for preservatives. The recommended level for benzoate is 0.2%.
Heat treatment
Heat the mixture of pulp and added ingredients in a large open pan over a low heat. An open
pan is best as it allows moisture to evaporate more quickly. Once you have softened the fruit
or vegetables, add the sugar and heat slowly to dissolve it, before increasing the heat to boil
the mixture. Stir continuously with a wooden spoon during heating to prevent burning. The
bright red colour of tomato sauces can be preserved by very slow heating.
Pasteurisation
Pasteurisation is an optional stage. It is not necessary if the chutney has a high
concentration of sugar and has been boiled for sufficient time to reduce the moisture content.
Sauces that are packed in glass bottles or jars can be pasteurised once they have been
bottled to extend the shelf life. Immerse the jars or bottles in a large pan or water bath and
heat. Both the time and temperature of pasteurisation are critical to achieve the correct shelf
life and to retain the colour and flavour of the sauce.
2
Chutneys and sources Practical Action
Tamarind chutney
Tamarind chutney is a sour, spicy pickle that is eaten as an accompaniment to curries and
other main meals. It is a mixture of tamarind and spices with a layer of oil on the surface.
The product will store well for several months.
Ingredients
Tamarind 1kg
Sugar 1kg
Spices (per kg pulp):
Coriander 40g
Cumin 50g
Black cumin 30g
Cloves 3-4 pieces
Cardamom 3-4 pods
Cinnamon 3-4 pieces
Chillies 10-12
Salt 30g
Vegetable oil 250ml
Caraway seeds 15g
Pepper 30g
Process details
Select fresh mature but unripe tamarind fruits. Discard fruits that are ripe, over-ripe,
infected or damaged. Rinse well in clean water.
Crack the pods by hand and separate the pulp from the broken shells.
Peel and remove the fibres, shell pieces and seeds from the pulp. For dried
tamarind, soak the fruit in water for up to 12 hours until the fruit has softened.
Remove the stones and fibres and drain off the excess water.
Add sugar to the pulp (1kg sugar per kg pulp).
Heat the pulp and sugar. Stir continuously to prevent it burning at the base of the
pan.
Dry roast the individual spices and grind. Mix with the oil and salt to make a paste.
Add the spice paste to the thick tamarind pulp. Mix thoroughly and continue to heat
for 20 minutes.
Pour the hot pickle into pre-sterilised jars and seal. Cool to room temperature, and
label.
Tomato sauce
Ingredients:
Tomatoes (20kg)
Sugar (1.5kg)
Onions (finely chopped) (450g)
Salt (330g)
Vinegar (800ml)
Spices:
Mace (3.5g)
3
Chutneys and sources Practical Action
Cinnamon (9g)
Cardamom (11.25g)
Cumin (11.25g)
Ground black pepper (11.25g)
Ground white pepper (5g)
Ground ginger (5g)
A tomato chilli sauce can be made by adding 2.5g chilli powder to 10kg tomato pulp before
processing.
Processing notes
Mixing ingredients
Tie the spices in a small muslin bag, add to the tomatoes with 500g of sugar and the
chopped onions.
Heating
Heat the mixture of tomato and spices to below boiling point in a heavy pan. Stir it
continuously to prevent burning at the base of the pan. Continue to heat until the mixture has
reduced to half the original volume. Remove the spice bag and add the remaining sugar, salt
and vinegar. Continue heating for 5-10 minutes. Check the final total soluble solids (10-
12%) with a refractometer.
Filling
Let the sauce cool to about 80C and hot-fill the sterilised bottles or jars. Close the lids tightly
and cool to room temperature.
Label the product with the product name, date of manufacture, use by date, ingredients,
weight, brand name and name of manufacturer.
Store
If adequately packaged and stored in a cool place, the sauce can be stored for up to a year
without any loss of flavour or taste. It should be stored out of direct sunlight to avoid any
loss of colour.
Lapsi pickle
Lapsi is a small tree fruit that is found in Nepal and India. It can be used to make pickle. The
amounts of spices added can be varied according to local taste and preference.
Ingredients:
Peeled and stoned lapsi (1kg)
Sugar (1 kg)
Salt 30g
Vegetable oil (250ml)
Spices:
Coriander 40g
Cumin 50g
Cloves (3-4 pieces)
Cardamom (3-4 pieces)
Chillies (10-12)
Pepper (30g)
Ground ginger (5g)
Processing notes
4
Chutneys and sources Practical Action
Filling
Let the pickle cool to about 80C and hot-fill into sterilised jars. Close the lids tightly and cool
to room temperature.
Label the product with the product name, date of manufacture, use by date, ingredients,
weight, brand name and name of manufacturer.
Store
If adequately packaged and stored in a cool place, the pickle can be stored for up to a year
without any loss of flavour or taste. It should be stored out of direct sunlight to avoid any
loss of colour.
Vegetable chutney
Ingredients (makes 3kg chutney)
750g carrots 9 tea cups
600g cabbage 9 tea cups
100g capsicum 1 tea cup
450g onions 4 tea cups
120g chilli powder 3-9tbs
15g ginger powder 1 tbs
40g salt 3 level tbs
30g curry powder 6 level tsp
750ml sunflower oil 3 tea cups
300ml vinegar 1 tea cups
If you do not have weighing scales, you can use a teacup to measure out the ingredients.
tbs = tablespoon (next size up from a teaspoon or equal to three teaspoons)
tsp = teaspoon (5ml)
5
Chutneys and sources Practical Action
If you are using recycled plastic jars, clean them with a solution of chlorinated water
(100ppm). Turn upside down so all the water can drain out.
Mix ingredients
Mix the dry spices- chilli powder, ginger powder, salt and curry powder.
Heat
Heat the dry spices in some of the sunflower oil (about 50ml). Stir well to prevent the spices
burning. Add the onions to the spicy oil and fry until they are soft (about 5 minutes).
Add the rest of the oil and the vinegar. Stir well.
Add the cabbage and cook for 5 minutes. Stir to prevent burning.
Add the carrots and capsicum and cook for 5 minutes until the carrot is soft. Keep stirring to
make sure the chutney does not burn.
Slowly turn the jar upside down so that any bacteria on the lid of the jar or in the space at the
top are killed. Leave the jar upside down until it is cold. When the jars are cold test each lid
to make sure it has a good seal.
Storage
Store the chutney in a cool dry place away from direct sunlight. It will store for up to 6
months.
6
Chutneys and sources Practical Action
Equipment suppliers
Note: This is a selective list of suppliers and does not imply endorsement by Practical
Action.
This website includes lists of companies in India who supply food processing equipment.
http://www.niir.org/directory/tag/z,,1b_0_32/fruit+processing/index.html
7
Chutneys and sources Practical Action
Gardners Corporation
India (see above)
8
Chutneys and sources Practical Action
Practical Action
The Schumacher Centre for Technology and Development
Bourton-on-Dunsmore
Rugby, Warwickshire, CV23 9QZ
United Kingdom
Tel: +44 (0)1926 634400
Fax: +44 (0)1926 634401
E-mail: [email protected]
Website: http://www.practicalaction.org/
This document was produced by Dr. S Azam Ali for Practical Action in March
2008. Dr. S Azam-Ali is a consultant in food processing and nutrition with over 15
years experience of working with small-scale processors in developing
countries.