Professional Documents
Culture Documents
Syrups Jams and Marmalades
Syrups Jams and Marmalades
…………………………………………………………….
Jam is a product made by boiling fruit pulp with sufficient quantity of sugar to a
reasonably thick consistency, firm enough to hold the fruit tissues in position.
Apply, sapota, papaya, plums, mango, grapes, jack, pineapple, banana, guava and
pears are used for preparation of jam. It can be prepared from one kind of fruit or
from two or more kinds.
In its preparation about 45% of fruit pulp should be used for every 55% of
sugar.The FPO specification of jam is 68.5% TSS, 45% of fruit pulp and 0.5-0.6% of
acid (citric acid) per 100 gm of the prepared product.
Select good quality ripe fruits. Wash the fruits well in cold water.
Peel the fruits and remove the stones and corers present.
Cut the peeled fruit into small pieces with a stainless steel knife.
If the fruit is hard, it should be cut into very small pieces.
Pulp the fruits by using pulper.
c) Cooking
Cook the mixture slowly with occasional stirring.The fruit pulp should be crushed
with a laddle during cooking. Continue cooking till the temperature of the mass
reaches 105.5⁰C
Sheet (or) Flake Test A small portion of jam is taken out during boiling in a
spoon or wooden laddle and cooled slightly. It is then allowed to drop. If the
product falls off in the form of a sheet (or) flakes instead of flowing in a
continuous stream (or) syrup, it means that the end point has been reached and
the product is ready. Otherwise boiling is continued till the sheet test is positive
d) Packaging Fill the hot jam into clean dry sterilized jars. Allow the jam to
cool and fix the sterilized lid to the jar. Store in a cool place.
JELLY
Guava, sour apple, plum, karonda, wood apple, papaya and jack fruit are rich in
pectin and generally used for preparation of jelly. Pineapple, strawberry grapes
etc. can be used but only after addition of pectin powder, because these fruits
have low pectin content. Preparation of jelly is similar to that of jam.
MARMALADE
This is a fruit jelly in which slices of the fruit (or) its peel are suspended. The term
is generally used for products made from citrus fruits like oranges and lemons in
which shredded peel is used as the suspended material. Citrus marmalades are
classified into
Syrups
This type of fruit beverage contains 25% fruit juice (or) pulp, 65% TSS, 1.3 to 1.5%
acidity and 350 ppm of So2 or 600 ppm of KMS. It is diluted before serving, Fruits
like aonla, jamun, pomegrante, grape, lemon, orange and sometimes ginger can
be used for the preparation of syrup. It is also prepared from extracts of rose,
sandal almond etc.
Synthetic syrups
Heavy sugar syrup of 70-75 per cent strength is used as the base of all synthetic
syrups and they are flavoured and coloured with artificial essence/flavours and
colours. They never contain fruit pulp/juice. A large proportion of these syrups
can, however, be replaced by real fruit juices, squashes and syrups which are
more nutritious. Large quantities of synthetic syrups (orange, lemon, pineapple,
strawberry) are manufactured and sold in varius countries. These can be prepared
by using 1.5 kg of sugar, 500 ml of water 15 g of citric acid. Different colours and
flavours are added as required. Among colours, orange red, lemon yellow, green,
raspberry red etc. are mostly used, while artificial essence/flavours of rose,
orange, pineapple, strawberry, lemon etc. are added as flavouring substances.
SQUASH
This is a type of fruit beverage containing at least 25 per cent fruit juice (or)
pulp, 45% TSS, 1.0% acidity and 350 ppm of So2 (or) 600 ppm of sodium benzoate.
It is diluted before serving (13). Lime, mango, orange and pineapple are used for
making squash commercially using KMS as preservative or fruits viz. jamun,
passion fruit, raspberry, strawberry, grape fruit etc. with sodium benzoate as
preservative.
CORDIAL It is a sparkling, clear, sweetened fruit juice from which pulp and other
insoluble substances have been completely removed. It contains atleast 25%
juice, 30% TSS, 1.5% acid and 350 ppm of So2.This is very suitable for blending
with wines. Lime and lemon are suitable for making cordial.