Professional Documents
Culture Documents
MSDS Portland Cement PDF
MSDS Portland Cement PDF
For
PORTLAND CEMENT
Section 1 - IDENTIFICATION
Product Names: Nevada Portland Cement - Type I/II
MSDS Information
This MSDS was revised January 5, 2010 and supercedes and replaces any prior versions.
Product Code
Standard Industrial Classification: 3241
Chemical Family
Calcium compounds. Calcium silicate compounds and other calcium compounds containing iron and aluminum make up the majority of this
product. Major compounds:
Formula
This product consists of finely ground portland cement clinker mixed with a small amount of calcium sulfate.*
Supplier/Manufacturer
Section 2 - COMPONENTS
OSHA PEL ACGIH TLV-TWA NIOSH REL
Hazardous Substances (8-Hour TWA) (1995 - 1996) (8-Hour TWA)
Portland Cement Clinker (CAS#65997-15-1) 50 million particles/ft3 10mg total dust/m3
Nominal 95% by weight
Magnesium Oxide (CAS #1309-48-4) 15mg total dust/m3 10mg total dust/m3
< 5% by weight
1
Crystalline silica (CAS#14808-60-7 10mg of respirable dust/m3 0.10mg respirable quartz/m3 0.05mg respirable
(%SiO2 +2) quartz/m3
Emergency Overview:
Portland cement is a light gray powder that poses little immediate hazard. A single short-term exposure to the dry powder is not likely to cause
serious harm. However, exposure of sufficient duration to wet portland cement can cause serious, potentially irreversible tissue (including skin or
eye) destruction in the form of chemical (caustic) burns, including third degree burns. The same type of tissue destruction can occur if wet or
moist areas of the body are exposed for sufficient duration to dry portland cement.
Exposure to dry portland cement may cause drying of the skin with consequent mild irritation or more significant effects attributable to
aggravation of other conditions. Dry portland cement contacting wet skin or exposure to moist or wet portland cement may cause more severe
skin effects including thickening, cracking or fissuring of the skin. Prolonged exposure can cause severe skin damage in the form of (caustic)
chemical burns.
Some individuals may exhibit an allergic response upon exposure to portland cement, possibly due to trace amounts of chromium. The response
may appear in a variety of forms ranging from a mild rash to severe skin ulcers. Persons already sensitized may react to their first contact with
the product. Other persons may first experience this effect after years of contact with hydraulic cement products.
Exposure to portland cement may cause irritation to the moist mucous membranes of the nose, throat, and upper respiratory system. It may also
leave unpleasant deposits in the nose.
Carcinogenic Potential:
Portland cement is not listed as a carcinogen by IARC, the State of California, NTP or OSHA. It does, however, contain trace amounts (<0.1%)
of a substance listed as a carcinogen by some of these organizations. Crystalline silica is now classified by IARC as a known human carcinogen
(Group 1). It is known by the State of California to cause cancer. NTP has characterized respirable crystalline silica as “reasonably anticipated to
be (a) carcinogen”.
Eyes
Immediately flush eyes thoroughly with water. Continue flushing eyes for at least 15 minutes, including under lids, to remove all particles. Call
physician immediately.
Skin
Wash skin with cool water and pH-neutral soap or a mild detergent intended for use on skin. Seek medical treatment in all cases of prolonged
exposure to wet cement, cement mixtures, liquids from fresh cement products, or prolonged wet skin exposures to dry cement.
Ingestion
Do not induce vomiting. If conscious, have the victim drink plenty of water and call a physician immediately.
2
Section 5 - FIRE & EXPLOSION DATA
Collect dry material using a scoop. Avoid actions that cause dust to become airborne. Avoid inhalation of dust and contact with skin. Wear
appropriate personal protective equipment as described in Section 8.
Scrape up wet material and place in an appropriate container. Allow the material to “dry” before disposal. Do not attempt to wash portland
cement down drains.
Keep portland cement dry until used. Normal temperature and pressure do not affect the materials.
Promptly remove dusty clothing or clothing which is wet with cement fluids and launder before reuse. Wash thoroughly after exposure to dust or
wet cement mixture or fluids.
Skin Protection
Prevention is essential to avoiding potentially severe skin injury. Avoid contact with unhardened (wet) portland cement products. If contact
occurs, promptly wash affected area with soap and water. Where prolonged exposure to unhardened portland cement products might occur, wear
impervious clothing and gloves and boots to eliminate skin contact.
Respiratory Protection
Avoid actions that cause dust to become airborne. Use local or general ventilation to control exposures below applicable exposure limits. Use
NIOSH/MSHA-approved respirators in poorly ventilated areas when dust causes discomfort or irritation, or where there is an applicable exposure
limit (Advisory: Respirators and filters purchased after July 10, 1998 must be certified under 42 CFR 84).
Ventilation
Use local exhaust or general dilution ventilation to control exposure below applicable limits.
Eye Protection
When engaged in activities where cement dust or wet cement or concrete could contact the eye, wear safety glasses with side shields or goggles.
In extremely dusty environments and unpredictable environments, wear unvented or indirectly vented goggles to avoid eye irritation or injury.
Contact lenses should not be worn when working with portland cement or fresh cement products.
Stability
Stable
3
Conditions To Avoid
Unintentional contact with water.
Incompatibility
Wet portland cement is alkaline. As such it is incompatible with acids, ammonium salts and aluminum metal.
Hazardous Decomposition
Will not spontaneously occur. Adding water results in hydration and produces (caustic) calcium hydroxide.
Hazardous Polymerization
Will not occur.
Ecotoxicity
No recognized unusual toxicity to plants or animals.
Section 13 - DISPOSAL
Dispose of waste material, including bags, according to local, state, and federal regulations.
Section 14 - TRANSPORTATION DATA
Hazard Category Under SARA (Title III) Section 311 and 312
Portland cement qualifies as a “hazardous substance” with delayed health effects.
Prepared By
Nevada Cement Company
I-80 East @ Exit 46
Fernley, Nevada 89408
Revision Date
January 5, 2004
4
intermediate products of this reaction (that is, those present while a portland cement product is “setting”) pose a far more severe hazard than does
portland cement itself.
While the information provided in this material safety data sheet is believed to provide a useful summary of the hazards of portland cement as it
is commonly used, the sheet cannot, and does not, anticipate and provide all of the information that might be needed in every situation. In
particular, the data furnished in this sheet does not address hazards that may be posed by other materials mixed with portland cement products.
Users therefore, should review other applicable material safety data sheets before working with this portland cement or working on portland
cement products, for example, portland cement concrete.
NEVADA CEMENT COMPANY MAKES NO WARRANTY, EXPRESS OF IMPLIED, CONCERNING THE PRODUCT OR THE MERCHANTABILITY OR FITNESS
THEREOF FOR ANY PURPOSE OR CONCERNING THE ACCURACY OF ANY INFORMATION PROVIDED BY NEVADA CEMENT COMPANY, EXCEPT THAT
THE PRODUCT SHALL CONFORM TO CONTRACTED SPECIFICATIONS. THE INFORMATION PROVIDED HEREIN WAS BELIEVED BY NEVADA CEMENT
COMPANY TO BE ACCURATE AT THE TIME OF PREPARATION OR PREPARED FROM SOURCES BELIEVED TO BE RELIABLE, BUT IT IS THE
RESPONSIBILITY OF THE USER TO INVESTIGATE AND UNDERSTAND OTHER PERTINENT SOURCES OF INFORMATION, TO COMPLY WITH ALL LAWS
AND PROCEDURES APPLICABLE TO THE SAFE HANDLING AND USE OF PRODUCT, AND TO DETERMINE THE SUITABILITY OF THE PRODUCT FOR ITS
INTENDED USE. BUYER’S EXCLUSIVE REMEDY SHALL BE FOR DAMAGES AND NO CLAIM OF ANY KIND, WHETHER AS TO PRODUCT DELIVERED OR
FOR NON-DELIVERY OF PRODUCT, AND WHETHER BASED ON CONTRACT, BREACH OF WARRANTY, NEGLIGENCE, OR OTHERWISE SHALL BE GREATER
IN AMOUNT THAN THE PURCHASE PRICE OF THE QUANTITY OF PRODUCT IN RESPECT OF WHICH DAMAGES ARE CLAIMED. IN NO EVENT SHALL
NEVADA CEMENT COMPANY BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES, WHETHER BUYER’S CLAIM IS BASED ON CONTRACT,
BREACH OF WARRANTY, NEGLIGENCE OR OTHERWISE.