MSDS Portland Cement
MSDS Portland Cement
For PORTLAND
CEMENT
Section 1 - IDENTIFICATION
Product Names: Zuari Portland Cement - Type I/II 43 OPC, 53 OPC ,PPC &,PSC
MSDS Information This MSDS was revised January 5, 2004 and supersedes and
replaces any prior versions.
Chemical Family Calcium compounds. Calcium silicate compounds and other calcium compounds containing iron and aluminum make up the
majority of this product. Major compounds:
Formula This product consists of finely ground port land cement clinker mixed with a small amount of calcium
sulfate.*
Supplier/Manufacturer
*Trace Elements Portland cement is made from materials mined from the earth and is processed using energy provided by fuels; and therefore may
contain trace amounts of naturally occurring materials which might be detected during chemical analysis. For example: Portland cement may
contain up to 0.75% insoluble residue, of which <0.1% may be free crystalline silica. Other trace constituents may include potassium and sodium
sulfate compounds, chromium compounds, and nickel compounds.
Section 2 - COMPONENTS
OSHA PEL ACGIH TLV-TWA NIOSH REL
Hazardous Substances _ (8-Hour TWA) (1995 -1996) (8-Hour TWA)
3 3
Portland Cement Clinker (CAS#65997-15-1) 50 million particles/ft 10mg total dust/m
Nominal 95% by weight
3 3
Calcium sulfate (CAS#7778-18-9) 5mg respirable dust/m 10mg total dust/m
3
[Gypsum (CAS#13397-24-5)] 10mg total dust/m
Nominal 5% by weight
3 3
Calcium Oxide (CAS#1306-78-8) 5mg/m 2mg/m
(Free Lime) < 4% by weight
3 3
Magnesium Oxide (CAS #1309-48-4) 15mg total dust/m 10mg total dust/m
< 5% by weight
1
3 3
Crystalline silica (CAS#14808-60-7 10mg of respirable dust/m 0.10mg respirable quartz/m 0.05mg
respirable (%SiO2 +2) Quartz/m 3
Emergency Overview:
Portland cement is a light gray powder that poses little immediate hazard. A single short-term exposure to the dry powder is not likely to cause
serious harm. However, exposure of sufficient duration to wet portland cement can cause serious, potentially irreversible tissue (including skin
or eye) destruction in the form of chemical (caustic) burns, including third degree burns. The same type of tissue destruction can occur if wet or
moist areas of the body are exposed for sufficient duration to dry portland cement.
Potential Health Effects: Potential effects resulting from eye contact; Exposure to airborne dust may cause immediate or delayed irritation or
inflammation. Eye contact by larger amounts of dry powder or splashes of wet portland cement may cause effects ranging from moderate eye
irritation to chemical burns and blindness. Such exposures require immediate first aid (see Section 4) and medical attention to prevent significant
damage to the eye.
Potential effects resulting from skin contact: Discomfort or pain cannot be relied upon to alert a person to a hazardous skin exposure.
Consequently, the only effective means of avoiding skin injury or illness involves minimizing or avoiding skin contact, particularly contact with
wet cement. Persons exposed to wet cement may not feel discomfort until hours after the exposure has ended and significant injury has
occurred.
Exposure to dry portland cement may cause drying of the skin with consequent mild irritation or more significant effects attributable to
aggravation of other conditions. Dry portland cement contacting wet skin or exposure to moist or wet portland cement may cause more severe
skin effects including thickening, cracking or fissuring of the skin. Prolonged exposure can cause severe skin damage in the form of (caustic)
chemical burns.
Some individuals may exhibit an allergic response upon exposure to portland cement, possibly due to trace amounts of chromium. The response
may appear in a variety of forms ranging from a mild rash to severe skin ulcers. Persons already sensitized may react to their first contact with
the product. Other persons may first experience this effect after years of contact with hydraulic cement products.
Potential effects resulting from inhalation: Portland cement may contain trace amounts (<0.1%) of free crystalline silica. Prolonged exposure to
respirable free crystalline silica may aggravate other lung conditions. It also may cause delayed lung injury including silicosis, a disabling and
potentially fatal lung disease.
Exposure to portland cement may cause irritation to the moist mucous membranes of the nose, throat, and upper respiratory system. It may also
leave unpleasant deposits in the nose.
Potential effects resulting from ingestion: Although small quantities of dust are not known to be harmful, ill effects are possible if larger
quantities are consumed. Portland cement should not be eaten under any circumstances.
Carcinogenic Potential:
Portland cement is not listed as a carcinogen by IARC, the State of California, NTP or OSHA. It does, however, contain trace amounts (<0.1%)
of a substance listed as a carcinogen by some of these organizations. Crystalline silica is now classified by IARC as a known human carcinogen
(Group 1). It is known by the State of California to cause cancer. NTP has characterized respirable crystalline silica as “reasonably anticipated
to be (a) carcinogen”.
Eyes
Immediately flush eyes thoroughly with water. Continue flushing eyes for at least 15 minutes, including under lids, to remove all particles. Call
physician immediately.
Skin
Wash skin with cool water and pH-neutral soap or a mild detergent intended for use on skin. Seek medical treatment in all cases of prolonged
exposure to wet cement, cement mixtures, liquids from fresh cement products, or prolonged wet skin exposures to dry cement.
Ingestion
Do not induce vomiting. If conscious, have the victim drink plenty of water and call a physician immediately.
2
Section 5 - FIRE & EXPLOSION DATA
Scrape up wet material and place in an appropriate container. Allow the material to “dry” before disposal. Do not attempt to wash portland
cement down drains.
Keep portland cement dry until used. Normal temperature and pressure do not affect the materials.
Promptly remove dusty clothing or clothing which is wet with cement fluids and launder before reuse. Wash thoroughly after exposure to dust or
wet cement mixture or fluids.
Skin Protection
Prevention is essential to avoiding potentially severe skin injury. Avoid contact with unhardened (wet) portland cement products. If contact
occurs, promptly wash affected area with soap and water. Where prolonged exposure to unhardened portland cement products might occur, wear
impervious clothing and gloves and boots to eliminate skin contact.
Respiratory Protection
Avoid actions that cause dust to become airborne. Use local or general ventilation to control exposures below applicable exposure limits. Use
NIOSH/MSHA-approved respirators in poorly ventilated areas when dust causes discomfort or irritation, or where there is an applicable exposure
limit (Advisory: Respirators and filters purchased after July 10, 1998 must be certified under 42 CFR 84).
Ventilation
Use local exhaust or general dilution ventilation to control exposure below applicable limits.
Eye Protection
When engaged in activities where cement dust or wet cement or concrete could contact the eye, wear safety glasses with side shields or goggles. In
extremely dusty environments and unpredictable environments, wear unvented or indirectly vented goggles to avoid eye irritation or injury.
Contact lenses should not be worn when working with portland cement or fresh cement products.
Stability
Stable
3
Conditions To Avoid
Unintentional contact with water.
Incompatibility
Wet portland cement is alkaline. As such it is incompatible with acids, ammonium salts and aluminum metal.
Hazardous Decomposition
Will not spontaneously occur. Adding water results in hydration and produces (caustic) calcium hydroxide.
Hazardous Polymerization
Will not occur.
Section 13 - DISPOSAL
Dispose of waste material, including bags, according to local, state, and federal regulations.
Section 14 - TRANSPORTATION DATA Hazardous
Hazard Category Under SARA (Title III) Section 311 and 312
Portland cement qualifies as a “hazardous substance” with delayed health effects.
Portland cement
Status Under is considered to be a hazardous material under the Hazardous Products Act as defined by the Controlled Products regulations
WHMIS
(class E - corrosive material) and is therefore subject to the labeling and MSDS requirements of the workplace hazardous materials information
system (WHMIS).
Section 16 - OTHER INFORMATION
Prepared By
Zuari Cement Limited
Krishna Nagar – 516 311
Kadapa Dist. A.P.
Revision Date
January 5, 2004
4
intermediate products of this reaction (that is, those present while a portland cement product is “setting”) pose a far more severe hazard than does
portland cement itself.
While the information provided in this material safety data sheet is believed to provide a useful summary of the hazards of portland cement as it is
commonly used, the sheet cannot, and does not, anticipate and provide all of the information that might be needed in every situation. In
particular, the data furnished in this sheet does not address hazards that may be posed by other materials mixed with portland cement products.
Users therefore, should review other applicable material safety data sheets before working with this portland cement or working on portland
cement products, for example, portland cement concrete.
ZUARI CEMENT COMPANY MAKES NO WARRANTY, EXPRESS OF IMPLIED, CONCERNING THE PRODUCT OR THE
MERCHANTABILITY OR FITNESS THEREOF FOR ANY PURPOSE OR CONCERNING THE ACCURACY OF ANY INFORMATION
PROVIDED BY ZUARI CEMENT COMPANY, EXCEPT THAT THE PRODUCT SHALL CONFORM TO CONTRACTED
SPECIFICATIONS. THE INFORMATION PROVIDED HEREIN WAS BELIEVED BY ZUARI CEMENT LIMITED TO BE ACCURATE
AT THE TIME OF PREPARATION OR PREPARED FROM SOURCES BELIEVED TO BE RELIABLE, BUT IT IS THE RESPONSIBILITY
OF THE USER TO INVESTIGATE AND UNDERSTAND OTHER PERTINENT SOURCES OF INFORMATION, TO COMPLY WITH ALL
LAWS AND PROCEDURES APPLICABLE TO THE SAFE HANDLING AND USE OF PRODUCT, AND TO DETERMINE THE
SUITABILITY OF THE PRODUCT FOR ITS INTENDED USE. BUYER’S EXCLUSIVE REMEDY SHALL BE FOR DAMAGES AND NO
CLAIM OF ANY KIND, WHETHER AS TO PRODUCT DELIVERED OR FOR NON-DELIVERY OF PRODUCT, AND WHETHER BASED
ON CONTRACT, BREACH OF WARRANTY, NEGLIGENCE, OR OTHERWISE SHALL BE GREATER IN AMOUNT THAN THE
PURCHASE PRICE OF THE QUANTITY OF PRODUCT IN RESPECT OF WHICH DAMAGES ARE CLAIMED. IN NO EVENT SHALL ZUARI
CEMENT COMPANY BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES, WHETHER BUYER’S CLAIM IS BASED ON CONTRACT, BREACH OF
WARRANTY, NEGLIGENCE OR OTHERWISE.