2 Document Reality PDF
2 Document Reality PDF
Additionally, if we don’t know where we’re starting from we’ll have no way of knowing how
much, if any, improvement we’ve made.
Finally, the abilities to document reality and to “go see” which enables us to then manage by
facts are important guiding principles of lean.
Next, we can go and see things for ourselves while doing our best to document what we’re
seeing.
Or, we can use one of the most powerful tools in the quick changeover toolbox to help us
out – the video camera.
The reason using a video camera can be so useful is it captures everything and allows us to
scroll back through the setup slowly and consistently. We can fast forward, rewind, and pause
to discuss what’s happening. In short, used correctly, the video camera can be one of the best
weapons you have at your disposal to radically reduce changeover times.
2. Document Reality
The “dos” of Video Taping
First of all, we must be safe. Having a video camera in the work
area is not normal so care should be taken that everything is done
safely.
Next, another powerful tip is to have one of the operators’ colleagues record the changeover
instead of the continuous improvement practitioner. Since these people work together and
know each other well anxiety levels are often decreased when colleagues record one another.
This can also be a lot of fun for the operators to do so give them a little training on how to
use the camera and turn them loose.
Additionally, if there won’t be a lot of movement you might decide to use a tripod to hold the
camera. But if there is a lot of movement involved it might be best to have a person hold the
camera. And to avoid a lot of jerky movement it’s important for the person holding the
camera to move slowly and smoothly.
Next, the position of the camera during the recording session is very important. And while
it’s impossible to give accurate instructions on how to do this since every process is
different… generally speaking you want to be close enough to really see what’s happening but
not so close that the person doing the taping is in the way.
Additionally, if there won’t be a lot of movement you might decide to use a tripod to hold the
camera. But if there is a lot of movement involved it might be best to have a person hold the
camera. And to avoid a lot of jerky movement it’s important for the person holding the
camera to move slowly and smoothly. Lastly, a few technical tips, be sure you have enough
room on your camera’s hard disk or tape to capture the entire changeover and be sure your
battery will last if you won’t be able to plug the camera in.
Lastly, make sure you have enough room on your camera’s hard disk or tape to capture the
entire changeover and be sure your battery will last if you’re not planning to use a power
source.
2. Document Reality
The “don’ts” of Video Taping
First, don’t video tape in a dimly lit area as it’ll make it difficult to
see what’s happening. In areas where lighting is poor a few flood
lights from a hardware store can be used to brighten things up. Just
be careful as these lights get extremely hot and can be a fire hazard.
Another don’t is pressing the pause button during the changeover. You see, once the
changeover has started the stop or pause button should only be pressed once the entire
changeover is complete. If the operator has to leave his or her work area to get some tools
or parts go ahead and capture this since this is most definitely part of the changeover process.
There’s always a tendency for people to say a particular action rarely happens so it should be
ignored… but if pressed the person will likely admit this thing has happened before and could
happen in the future. So, be sure to video tape the entire changeover from start to finish.
Lastly, in some cases video taping others may not be allowed for a variety of reasons. If this is
the case don’t worry as you can still improve the situation by observing a changeover in
person and carefully documenting what you see. This method may take a little longer but can
be done. After all, I am not sure Dr. Shingo was sporting a new Canon HD video camera back
in the day!
If you have questions for how to use the template please refer to the Document Reality Part 2
video or email me us [email protected].
2. Document Reality