P6124 Titan T 130 PowerPlant Scope of Supply
P6124 Titan T 130 PowerPlant Scope of Supply
P6124 Titan T 130 PowerPlant Scope of Supply
Special nameplates are provided.Labels for the package are to be provided in phenolic
material. In lieu of etched aluminum, package nameplates for all equipment located
indoors in ventilated air-conditioned environment or outdoor applications for on-skid
gauge boards, control panels and junction boxes shall be white phenolic background
with black letters. The warning nameplates shall be red phenolic background with white
letters and orange or yellow phenolic background with black letters as applicable for
danger, warning, caution, respectively. The warning nameplates on pumps and motors
that can start automatically shall be red phenolic background with white letters to
indicate danger. All labels shall be attached with double back tape and stainless steel
screws where practical. Note: For NEMA 4X junction boxes or other equipment where
screws would penetrate the enclosure, a permanent adhesive (without screws) shall be
used.
Brass, bronze, or aluminum alloy parts will not be used in hydrocarbon service or where
in contact with hydrocarbon (oil or gas) on the package. Accepted are bronze or brass
parts used as bearings, or bushings.
ELECTRICAL SYSTEM TYPE
NEC, Class I, Group D, Division 2
3 PHASE AC POWER RATING
600 Volts / 60 Hz
1 PHASE AC POWER RATING (Battery Charger)
600 Volts 50/60 Hz
1 PHASE AC LIGHTING AND HEATER POWER
208 Volts, 60 Hz
APPLICATION CHECK SHEET (ACS)
Titan 130 Generator Set
TURBINE MODEL
SoLoNOx Titan 130-20501S
INLET ORIENTATION
Up
EXHAUST ORIENTATION
Axial
SOLONOX GAS FUEL
25 ppm NOx Emissions, Gas Fuel
MAIN REDUCTION DRIVE
1800 RPM 60 Hz
GENERATOR SUPPLIER
ABB
GENERATOR RATING
6900 Volt, 60 Hz, F Insulation, B Rise
CF: Custom Generator
[0000000892 Ver. -.8] Brushless synchronous generators are suitable for gas turbine Titan 130. Custom
features include:
-Frame Code: AMS 900 LH
-Machine Type: 4 Pole / 3-Phase / 1800 RPM / 6 Wire, WYE Connection / Insulation
Class F with VPI
-Machine Rating: 6,900 Volt /60 Hz / 17,500 kVA @ 40°C / 0.8pf / B-Rise (80°C Rise)
-(6) Stator RTDs, PT 100 (Single Element), (2 per Phase)
-(4) Bearing RTDs, PT 100 (Single Element), (2 per Bearing)
-(3) Cooling Air RTDs, PT 100 (Single Element), (2 in cold air, 1 in hot air)
-Proximity Type vibration detection (2 probes per bearing)
-Black Heat anti condensation space heaters in the Stator & Exciter (208V, 60Hz, 1-
Phase)
-Bearing prepared for Jacking
-IP 54 Ingress protection when connected to ducting (otherwise IP 20)
-ABB Epoxy industrial coating, according to ISO 12944 C5i. Color code is RAL7032.
-Ambient temperature -30degC to 40 degC
-AUX BOX location, RSFVEE (Stainless steel)
CF: Fuel Shut Down The customer will provide shutdown valve (SDV) status to Solar which will be displayed
Valve Status on the HMI.The customer will provide a single contact for the gas fuel SDV status.
[0000000623 Ver. A.5] When the contact is closed, it indicates a closed valve and when a contact is open, it
indicates an open valve. Solar will display on the HMI an indication of the position of
the valve. Start permissive logic will be provided for the off skid fuel gas shutdown
valve (provided by the customer). The fuel supply valve must be confirmed to be open
prior to start.
CF: Generator Alarms The alarms and unit shutdowns are modified as follows:
and Shutdowns Alarm and trip turbine breaker on generator under voltage without turbine shutdown.
[0000001239 Ver. -.2]
CF: Generator Load Provide a Load Shed Panel. The load shedding panel (contained in a NEMA 4 box) is
Shed Panel a programmable controller-based system, primarily intended to protect a power plant
[0000000991 Ver. -.17] from real power overload. The panel monitors power generation, plant loads, power
flow, circuit breaker status, and operator inputs including load priority settings.
CF: Interface with Solar will add one each ControlNet interface module to the unit controller rack to
Solar Station Control provide for dedicated communication to a Solar Station Control or to provide unit to unit
[0000035262 Ver. -.5] communication. This CF adds the ControlNet module and the supporting software for
communication to the Load Shed Panel.
CF: Unit Based Solar will supply Unit Based Generator Load Sharing. This feature will allow Solar units
Generator Load with Logix PLCs to have unit based generator real and reactive load sharing in a
Sharing [0000043680 multiunit installation via a digital communication network (ControlNet). It will change
Ver. -.7] and simplify the design, eliminate the use of external analog load sharing circuitry and
will substantially increase the possible distance between the load sharing units.
GENERATOR SEQUENCING
Auto Start and Synchronizing
KW CONTROL
Kilowatt Control (Single Unit)
VIBRATION MONITORING SYSTEM - GENERATOR
2X and 2Y Proximity Probes, 4 Channels
AIR SUPPLY - SELF CLEANING FILTER
Turbine Compressor Bleed Air
120 VDC CONTROL AND ACCESSORY POWER SUPPLY
120 Vdc Power Supply with NiCd Batteries
ENGINE CLEANING SYSTEM
On-Line / On-Crank Cleaning System
ENGINE CLEANING SYSTEM TANK
Cleaning Tank - ASME Certified (Quantity 1, to be shared by both units)
PREPARATION FOR SHIPMENT
Long Term Preservation
OMI LANGUAGE
English Language OMI
OMI MANUALS FORMAT & QUANTITY
CD-ROM OMI, Standard Quantity
PACKAGE & CONSOLE LABELS, LANGUAGE
APPLICATION CHECK SHEET (ACS)
Titan 130 Generator Set
Solar shall provide an electrical device certification list and individual certificates for all
devices listed on the electrical device certification list. Solar is to include these
certificates in the manual.
CRN Certificates Obtain a Certificate number for all project pressure vessels.
[Technical Note]
Self Cleaning Barrier Filter, Oversized, Updraft, Synthetic Spiderweb Media, Cold Weather
ACCESSORIES FOR AIR FILTRATION SYSTEMS
CF: Custom turbine air Includes:
Inlet system -Leg Kit w/Maintanence Platform, Ladder, for TTD 160, with Manual Clean Switch
maintenance platform -Insect Screen Kit for TTD-160 Leg Kit
and ladder -Cold Weather design (-45C)
[0000000216 Ver. -.10]