Bhupal Case Study PDF
Bhupal Case Study PDF
hazardous gases such as MIC, chlorine, phosgene and monomethylamine. Hence these kinds of
occurrences were not uncommon in the UCIL plant and it was not a safe working place.
The leak and its effects
The UCC facility used three tanks to store 15000 gallons of liquid MIC produced which and it was to
be kept under pressure using inert nitrogen which helped the pumping of MIC when needed and also
kept impurities at bay. The safety regulations specified that the maximum50% of the tank should be
used for storage. Another disadvantage of using MIC was that it had to be stored at 0degree Celsius at
all times to keep it inert.
In the last days, October 1984, the E610 tank lost its ability to maintain the nitrogen pressure which
halted the production of MIC in the plant. The production was soon started again despite a failed
attempt of reestablishment of the system and the 42 tons of remaining MIC was ignored.
On the night of 2nd December 1984 around 10:30 pm, with the MIC safety systems not working to
their full efficiency, water from a connecting pipe was introduced in the E610 tank causing a
catastrophic exothermic reaction damaging the system and causing the leak of MIC. It did not take
long for the gas to spread over the city of Bhopal causing great panic among the residents.
The initial effects were breathlessness, severe irritation in the eyes, coughing, a feeling of suffocation
and burning of the respiratory tract. People realizing the symptoms ran away from the plant. Several
thousand people were victims and had died before the following morning. The primary factors causing
the deaths were choking, collapse of circulatory systems, changes in the lungs and improper
functioning of the kidneys are a few among many. The neo natal mortality rate rose manifold. The
Indian council of medical research (ICMR) was forbidden to give out the data to the public but
estimates say that more than 500,000 people were affected by it. The few implications known were in
eyes, respiratory tracts, neurological systems and psychological effects.
What caused the leak and how it could have been avoided?
The route chosen for the production of the pesticide sevin using mic as an intermediate, was itself a
major mistake as it had a lot of complications tagged with it. The liquid MIC had to be stored at 0
degree Celsius at all times even while transporting it in barrels from the storage to the production house
which is next to impossible. And for proper use it had to be kept at a high pressure using inert nitrogen
which was again required a strong technical system. Other manufactures were using an alternate MIC
free route for producing sevin.
The MIC supervisor ignored the complaint by the workers of a pollution caused by MIC leak and made
the decision to consider it after the tea time which gave the gas enough time to escape to the city. Even
after this mistake, the alarm for the residents near the plant was not used to its function and most of
the people figured it out when they started to feel its symptoms.
The safety specifications set up by the UCC were not implemented properly and were given a blind
eye whenever it caused a malfunction. The storage tanks were filled much over the specified limit of
50%.the refrigeration system used to maintain the temperature of liquid MIC was not in working
condition since January 1982. The flare tower used to burn the MIC was faulty and also of improper
size to deal with a leak of MIC. The storage system was lacking the specifications needed to control a
leak of this magnitude. The production workers were not trained properly about the safety procedures
to follow at all times. This was done to reduce the training time n costs of training being bared by the
company.
All the effects of the disaster could have been mitigated if the government had information about the
effects and composition of the chemicals used. The UCC used trade secrecy as a right to contain
information about the true composition of the leaked gases. Though it was known that upto 300 toxic
chemicals but insufficient research was done and that too only on animals. it was a clear case of
criminal negligence.
The diseases could have been managed if the government had been given the complete information
about the composition of chemicals used and their long-term effects on the human body. ICMR started
24 studies about the effects of MIC but unfortunately none of them were completed and were shut
down by 1994.
Will there ever be ever a closure?
It’s been more than 32 years since the disaster struck and yet an exact causative of the disaster has not
been established. The sufferings of the victims have continued to haunt their lives ever since. The
compensation has only been offered to 20% of the real number of victims and many of those have also
not been given the complete proposed composition. The paltry composition given is nothing in
comparison to their mounting medical bills. The victims continue to fight for justice and nobody pays
heed to their continuing struggle. The complete responsibility has been put upon the courts to decide
and the state and central government have taken a backseat. The government needs to step up and
complete all the promises made to the victims and help them mitigate the effects it has made on their
lives.
II. BHOPAL GAS TRAGEDY 2.0
The legacy of UCIL still is still haunting the people of Bhopal. The three pesticides produced by the
company, namely carbaryl (trade name Sevin), aldicarb (trade name Temik) and a formulation of
carbaryl and gamma-hexachlorocyclohexane (g-HCH). 15 years before the disaster it continued to
dump process waste and other hazardous by products in and around the area of the factory. Since then
350+ tonnes of waste has been kept leaking at the site and it is still lying there. Nobody is ready to pay
for the disposal of the waste and keep playing the blame game on each other. This has resulted in
adulteration of the ground water in a 3km radius around the premises of the factory. The test results
have been found toxic for the fish. If not taken proper care this Bhopal gas tragedy 2.0 threatens a
greater no of people than the first one as some of these chemicals can remain there up to 100 years
unless taken care of and the site is decontaminated.
The work does not end herein India we continue to see mini Bhopal like industrial disasters. Hazardous
waste piling up at factories. There are various industries in India where the waste has been dumped
improperly and hazardous chemicals like chromium, mercury waste and pesticide waste are lying and
no care is being taken.
There have been numerous laws and policies made by the government like the environment protection
act (EPA) of 1986 which gives direct authority to the Centre to close, prohibit or regulate any industry.
There were also amendments made in the factories act of 1948. Many other rules and regulations have
been put up but despite all this legislation India has never been able to overpower the problem of
hazardous waste management and environmental protection as a whole. We still do not have the proper
means and methods to decontaminate and purify these toxic sites. We not just need proper rules and
regulations but also some higher authorities to ensure that those rules are being implemented and
followed to prevent another Bhopal like tragedy from happening ever again.
Conflict of interest: The authors declare that they have no conflict of interest.
Ethical statement: The authors declare that they have followed ethical responsibilities
REFERENCES
[1] Management in India", Water Global Common and Global Problems, 2006.
[2] Available at: www.kractivist.org
[3] Available at: www.downtoearth.org.in
[4] Available at: www.en.wikipedia.org