Professional Documents
Culture Documents
Animashaun - Rasaq@lmu - Edu: A B A A B A
Animashaun - Rasaq@lmu - Edu: A B A A B A
Animashahun R. Aa*, Omoikhoje S. Ob, Alabi, O.O a, Shoyombo, A.Ja and Olawoye S.O.b.
a Department of Animal Science, Landmark University, P.M.B. 1001, Omu Aran, Kwara State,
Nigeria.
b Department of Animal Science, Ambrose Alli University, P.M.B. 14, Ekpoma, Edo State,
Nigeria.
ABSTRACT
An eight week feeding trial was conducted to assess the replacement value of instant noodle
waste meal (INW) on the performance characteristic, carcass and haematological parameters
of broiler chickens. Ninety, one-day old Anak 2000 chicks were randomly allocated to three
treatment groups namely, diet 1 (0% INW), diet 2 (50% INW) and diet 3 (100% INW) in a
completely randomized design (CRD). Each treatment group had three replicates of ten chicks
each. The inclusion of instant noodle in the diet did not have significant (P>0.05) effect on the
performance of the broiler chickens at both starter and finisher phases. The inclusion of instant
noodle waste had no significant (P>0.05) effect on the carcass traits and organ weights in
broiler chickens. No significant (P>0.05) effect was observed for the packed cell volume,
hematocrit, haemoglobin, leucocytes, and mean corpuscular haemoglobin concentration
among the treatments. However, mean corpuscular volume and mean corpuscular
haemoglobin were significantly (P< 0.05) influenced by the instant noodles inclusion, in the
diets. Based on the present results INW could replace maize fraction of the diet partially or
wholly without any adverse effect on performance, carcass and health status of broiler
chickens.
40
INTRODUCTION
The intake of animal protein in Nigeria was estimated to be 4.82g/head/day (Manary, 2013)
compared to the recommended minimum intake of 35g/head/day require for proper growth,
reproduction, lactation, health and survival (FAO, 2009) . The observed low level of animal
protein intake has its root cause in the high cost of feeding farm animals for optimum growth
and production (Durumaet al., 2006) as feed constitute up to 76, 74 and 73 % of the cost of
production for the small, medium and large scale producers (Olorunsanya, 2004). Hence, the
key to sustainable animal production is availability of cheap feed as feed is the major
determinant of livestock production in terms of quantity, and turnover rate ( Olorunsanya, 2004).
Poultry production especially the production of broiler chickens offers the greatest scope for
increasing the quality and quantity of protein intake in Nigeria because of the short generation
interval and prolificacy (Ezema and Eze, 2009). The chief source of energy in the diets for
monogastric animal in Nigeria is maize (Zea mays), but it is also required by man and
processing industries. There has been an increasing demand for maize in Nigeria and this has
resulted in the escalation in the price, and reduction in the amount used in diet for livestock;
this therefore calls for concerted effort in search of alternative cheap sources of feed ingredients
that have little or no competition from human consumption (Ukachukwu, 2005).
Agro industrial waste by-products in recent years have become popular feed components in
poultry diets in Nigeria (Eustace, 2005 and Adeyina et al., 2008). Examples of such products
include wastes from the kitchen, from the canning industries, potato pomace waste, citrus fruit
wastes, bakery waste, kolanut testa meal, cocoa kernel meal, pigeon pea meal, bambara
groundnut meal, cashew nut waste meal, etc. Adeyeye (2005) observed that the use of
decorticated cashew nut meal in place of soya bean meal in broilers feed enhanced the carcass
traits of broiler chickens. Leaves and tender stem of cassava have been incorporated into
broilers feed with encouraging result (Aderemi,et al., 2004). Oyedeji et al (2015) reported no
detrimental effect of blood rumen content mixture (BRCM) meal supplemented with yeast on
the performance and gut microbial populations of broiler chickens. Also Lamidiet al. (2008)
observed no adverse effect on the performance of chicken when 10% pineapple crush meal
was used to replace maize. Omoikhoje et al. (2010) reported enhanced growth, nutrient
digestibility and blood profile when corn flakes waste was incorporated into broilers diet to
replace 75% maize. Aderolu et al. (2011) also observed a better growth performance in African
catfish as a result of inclusion of instant noodle waste to replace 75% maize.
Since the introduction of instant noodle meal into Nigeria culinary, it has become popular, well
accepted and found in the kitchen of almost all Nigerian homes (Business News, 2006). This
has resulted in the great explosion of the industry and corresponding level of waste from this
41
sector. Instant noodle has several advantages over other non-conventional feed ingredients:
since instant noodle is meant for human consumption, it is hygienically packaged and this
removes the fear of contamination. Instant noodle waste has no known anti-nutritional factors,
and it also possesses higher metabolizable energy than maize (Laila et al., 2010; Eniolorunda,
et al., 2008). The proximate composition of instant noodle waste (INW) has been reported to
be comparable to that of maize (Laila et al., 2010) as shown in Table 1. Instant noodle waste
is a suitable energy source, it is not in direct competition with humans as food, need no further
processing before its inclusion in the diet, has a stable and affordable price when compared
with maize. With the recent increase in consumption and acceptability of instant noodles as fast
food in the country and the complementary increase in producers and production, a lot is being
discarded as waste. This study was therefore designed to determine the performance
characteristics and haematological indices of broiler chickens fed varying levels of instant
noodle waste meal.
42
Performance characteristic study:
Prior to the beginning of the experiments, the birds were weighed to obtain their initial body
weight and subsequently on weekly basis. The performance parameters measured were feed
intake, body weight gain and feed conversion ratio.
Feed intake: A known quantity of feed was given to the chicks on daily basis while the leftover
of feed was weighed to determine daily feed intake and consequently weekly feed intake. All
birds were fed ad libitum each day to ensure adequate access to feed.
Number of birds
Weight gain: The live weight gains were recorded on weekly basis. The initial live weight was
deducted from the final live weight and divided by the number of birds per treatment
compartment. Birds were usually weighed before feeding in the morning.
Number of birds/treatment/replicate
Feed conversion ratio: Feed conversion ratio of each group of birds was determined by
calculating the ratio of feed intake to weight gain and thus calculated as:
Feed intake
Weight gain
Carcass quality study
At the end of eight weeks feeding trial, the birds were fasted overnight and two chickens were
selected from each replicate and weighed. Thereafter, the birds were slaughtered, bled,
43
plucked and eviscerated. The weights of the plucked and eviscerated chickens were taken,
while the eviscerated weight relative to the live weight was used to estimate the dressing
percentage of the birds. Later, the dressed chicken was cut into parts such as: the thigh,
drumstick, breast, wing, shank, head, neck and back and their weights taken relative to the
eviscerated weights.
Blood sample collection and preparation: Three birds each were randomly selected from
each replicate on weight equalization basis and blood samples were collected terminally from
each of them through wing vein using syringe and needle. About 5ml of blood sample were
collected from each bird into a labeled ethylene diamine tetra acetic acid (EDTA) specimen
bottles for haematological indices determination.
Determination of haematological indices: Packed cell volume (PCV), red blood cell (RBC),
white blood cell (WBC), haemoglobin were determined using improved
Neubaurhaemacytometer after dilution and cyanomethaemoglobin methods respectively as
described by Dacie and Lewis (1991), while the standard ratios of the mean corpuscular volume
(MCV), mean corpuscular haemoglobin (MCH) and mean corpuscular haemoglobin
concentration were calculated according to Jain (1986).
Statistical analysis
The experimental design was a Completely Randomized Design (CRD) and data obtained were
subjected to Analysis of Variance (ANOVA). Significant differences among treatment means
were determined using Duncan Multiple Range Test as contained in SAS (2011) package.
The performance characteristics of broilers fed diet differing in INW are presented in Table 3.
At the starter phase, no significant difference (P > 0.05) was observed in all the growth
parameters tested for. However, highest daily feed intake was observed in diet 3, while least
value was obtained in diet 2. The values obtained for average daily weigh gain showed that
birds fed with diet 2 had the best weight gain compared to diets 1 and 3. The result also showed
that there was better utilization of diet 2 as indicated by the calculated feed conversion ratio. At
the finisher’s phase, there was no significant difference in the values obtained for average daily
feed intake and average live weight, there were significant differences (P < 0.05) in the values
observed for average daily weight gain and the feed conversion ratio at this phase. However,
the values obtained for diets 1 and 3 were significantly similar; higher feed intake observed in
diet 3 is in agreement with the findings of Olayemi (2007) and Eniolorunda, et al. (2008) who
reported an increase in feed intake as the INW increases from 0-100%.
44
Data on the carcass characteristics of broiler chickens are shown in Table 4. It was observed
that the inclusion of instant noodles did not have significant (P>0.05) effect on the carcass
characteristics of broiler chickens. The values obtained for the average live weight, defeathered
weight, eviscerated weight, dressing percentage, the drumsticks, breast, thighs and wings
numerically higher at diet 2 and reduced to the lowest at diet 3. Since the average live weight,
defeathered and eviscerated weights were not significantly (P>0.05) increased as the level of
inclusion of INW increased in the diets, it therefore implies that the quality of the test ingredient
in the diets is capable of effective tissue synthesis in finisher broiler chickens under the same
environmental condition. The dressing percentage of broiler chickens (ranged between 80.86
and 85.92) were significantly similar amongst the treatment groups and the values obtained are
consistent with the range of values reported by Lamidiet al (2008), Fapohunda et al., (2008),
and Adejinmi et al., (2011) for broiler chickens.
The results on haematological indices (Table 5) revealed that packed cell volume (PCV), red
blood cells (RBC), haemoglobin (Hb), white blood cells (WBC) and mean corpuscular
haemoglobin concentration (MCHC) were not significantly (P>0.05) different from one another,
while mean corpuscular volume (MCV), mean corpuscular haemoglobin (MCH) were
significantly (P<0.05) affected by the test diets.. This result was in agreement with Akinola and
Etuk (2015) and Mitruka and Rawnsley (1997). The haemoglobin values obtained in this study
indicate that the oxygen carrying capacity of the bird’s blood by haemoglobin was relatively the
same. It has also been established that an animal with decrease in the level of haemoglobin in
the blood is indicative of poor nutrition including dietary deficiency of iron, amino acid and
vitamins (Afolabi and Oladimeji, 2003; Mitruka, and Rawnsley 1997; Aletor, and Egberongbe,
1992). The WBC plays a major role in defending the body against disease-producing bacteria,
viruses and fungi; a deficiency in WBC may result in an increased susceptibility to infections. A
decrease in white blood counts is a reflection of the decline in the production of WBC for
defensive action against infection.
The results obtained in the study buttress the fact that INW had no detrimental effect on health
status of the birds and could be used as alternative feed resource in the diet of broiler chickens.
Mean corpuscular volume was significantly (P<0.05) highest in broilers maintained on diet 3,
followed by those that ate diet 1 and least in those maintained on diet 2. Mean corpuscular
haemoglobin was significantly (P<0.05) higher in birds maintained on the control diet (diet 1),
followed by those that ate 100% IWM (diet 3) and least in those maintained on the 50% INW
(diet 2) based diet. Blood is very vital to life and any abnormal variation in the haematology of
the cell impairs the primary physiological functions of the animal’s body (Akinmutimi, 2006;
Bamgbose et al; 2004; Omoikhoje et al; 2010). Esonu et al (2001) reported that haematological
constituents are reflection of animal’s responsiveness to both internal and external
45
environments which include feeds and feeding. The haematological parameters obtained
suggest that all the broiler chicken irrespective of the test diet inclusion level had normocytic
and normochromic red blood cells.This implies that the inclusion of INW up to 100% did not
affect the utilization of iron by the birds. The similarities in the values of PCV, RBC, Hb, and
MCHC among the birds irrespective of the test diets could be an indication that the test diet has
no adverse effect on the erytopoiesis activities of the chickens fed the test diet; since
haematocrit and haemoglobin are known to be positively correlated with protein quality and
protein level in the feed; the increase in the levels of MCV and MCH as the level of INW
increased indicates the high quality of the diets. All the haematological values including the
WBC fell within the normal range for healthy broiler chickens (Maxwell et al, 1990; CCAC, 1993;
Ikhimioya, et al., 2000; Banerjee, 2009; Nkwocha, et al., 2014)
CONCLUSION
Instant noodles waste meal (INW) could replace maize in the diet of broiler chickens. The
haematological indices and carcass yield of broiler chickens in this study revealed the
adequacy of the INW inclusion up to 100% level in broiler diets; however, better result was
achieved in birds fed diet containing 50% INW.
46
Table 2: Composition of experimental starter and finisher diets
Ingredients T1 T2 T3 T1 T2 T3
47
Average daily weight gain 29.30 32.06 29.81 0.72 55.83b 63.20a 55.56b 0.51
(g/bird)
Feed conversion ratio 2.16 1.96 2.21 0.18 2.44a 2.14b 2.55a 0.08
abMeans in the same row with differentsuperscripts differ significantly (P>0.05)
Diets
Diets
Indices 1 2 3 SEM±
48
MCV (fl) 128.80b 125.83c 132.50a 0.21
abc Means in the same row with different superscripts differ significantly (P<0.05).
REFERENCES
Adeyina, A. O., Annongu, A. A. and Awe, O.(2008). Effects of cocoa bean shell on the
performance, blood indices and organ characteristics of cockerels. Agrosearch 10 (1).
Pp: 11 - 19
Adejinmi, O. O., Okpeze, C.N.Obi, O.O.,Omole, A.J., Kehinde, A.S., Awe, O.A. (2011).The use
of chicken egg shell as an alternative source of calcium in the diet of cockerel chicken.
Journal of Agriculture and Social Sciences: pp. 34-38
Aderemi, F.A, Ladokun,O.A. and Tewe, O.O (2004). Study on haematology and serum
biochemistry of layers fed biodegraded cassava root sievate. Bowen Journal of
Agriculture.1 (1) Pp: 78-83
Aderolu, A. Z., Aarode, O.O. and Adigun, A (2011). Replacement of maize with graded levels
of noodle waste in commercial diet of African catfish. Nigerian Journal of Fisheries 8
(2)
Adeyeye, S.A. (2005). National significance of broiler chickens, (Anacardium occidentale) nut
meal in broiler chicken, M. Agric Tech Thesis, Department of Animal Production and
Health, Federal University of Technology, Akure Nigeria, Pp: 1-117.
Akinmutimi, A.H. (2006). Nutritive value of raw and processed jack fruit seeds (Articarpus
heterophilus).Chemical Analysis . 4: 266-271
Akinola, L.A.F and Etuk, M.O (2015). Haematological and Serum Biochemical Responses of
Broilers Fed Varying Levels of Indomie Waste-Based Diet. Journal of Agriculture and
Veterinary Science 8(3), Pp 66-70. e-ISSN: 2319-2380 DOI: 10.9790/2380-08316670
Aletor, VA. and Egberongbe, O.(1992).Feeding differently processed soybean and assessment
of haematological responses in chicken. Die Nahrung 36: 367 – 370.
49
Banerjee G.C.(2009) A textbook of Animal Husbandry 8th Ed. (Oxford and IBH Publishing Co.
PVT. Ltd., New Delhi, India,, 118- 139
Business news (2006). "The Noodles War | The NEWS – Nigeria's authoritative weekly
newsmagazine"Thenewsng.com.2008-07-21.
http://thenewsng.com/article/857?version=print. Retrieved 2009-05-29.
Dacie J.V and Lewis, S. (1991).Practical haematology 8th edition Longman group Ltd. Pp: 22-
68
Ezema, C. and Eze, D.C. (2009). Performance and Economic Benefit of Broilers Fed Palm
Kernel Cake-Based Diet Supplemented with Probiotic. International Journal of Poultry
Science 8 (10): 1003-1005, 2009 ISSN 1682-8356 © Asian Network for Scientific
Information
Duruma C. A., Udibie, A.B.I. and Etuk, E.B. (2006).Performance and organ characteristic of
broiler chickens fed graded level of Anthonatamacrophyla seed meal as replacement for
Arachis hypogeal meal. Proceeding of 11th Annual Conference of ASAN Pp: 211 -215
Eniolorunda, O.O., Taiwo, B. B. A., Oyewumi, O.O. and Adeyemi, O.A. (2008). Performance of
laying hens fed graded levels of indomie waste as replacement for maize in humid
Tropical environment. Research Journal of Animal Sciences 2 (5): 135-138.
Esonu, B. O., Emenalom, O.O., Udibibie, A.B.I., Herbert, U. Ekpor, C.F., Okoli, I.C and
Iheukwumere, F.C. (2001). Performance and blood chemistry of weaner pigs fed raw
Mucuna (Velvet bean) meal.Trop. Anim. Prod. Invest. 4:49-54
Eustace (2005). Effect of Enzyme supplementation on palm kernel meal and brewers dried
grain on the performance of broilers. International Journal of Poultry Science 4 (2):
76-80.
F.A.O (2009): Food outlook. Food and Agricultural Organization Corporate Document
Repository. http://www.fao.org/docrep
Fapohunda, J.B., Adejinmi, O.O.,Okpeze, C.N.,Owosibo, O.A. and Bamigbose, A.M. (2008)
Effect of replacing maize with biscuit waste in the diet of cockerels. Proceeding of the
13th Annual conference of the Animal Science Pp: 318-321
50
Ikhimioya, A. Arijeniwa, I. Oleku, T. and Ahmed, A,(2000). Preliminary investigation on the
haematology of the Nigerian indigenous chicken. Proceeding of 5th Annual Conference
of Animal Science Association of Nigeria, 10- 12
Jain N.C (1986): SchalmVeteniaryHaemotology. 4th edition philadephia, Lea and Febinger
Laila, A,O., Bamgbose, M. D., Eruvbentine M., Bemji, A.O. and Osundare,T.O. (2010): Effects
of Instant noodles waste based diets as a replacement for maize on
haematologicalparameters of broiler chickens. Proceeding of 15th Annual Conference of
Animal Science Association of Nigeria.(ASAN). Pp 5-7.
Lamidi, A.W., Famino, D. Eruvbetine, M and Biobaku, W.O. (2008). Effects levels of graded
pineapple (Ananascomosus L. Meer) Crush waste on the performance, carcass yield and
blood parameters of broiler chicken .Nig. J. Anim. Prod. 35(2): 168-170
Manary M. (2013). Inadequate dietary protein intake. Food and Nutrition Bulletin, Volume 34
No. 2 Pg. 248
Mitruka, H.M. and Rawnsley, S.K.(1997). Clinical, biochemical and haematology reference in
normal experimental animal. Mason, NY. Pp. 287 – 380.
Nkwocha G.A., Agbabiaka L.A., Anukam K.U. and Beketin T.O. (2014) Growth responses
carcass and blood characteristics of finisher broilers fed sorghum offal meal as dietary
supplement. International Journal of Agriscience. 4(7), 392-398
Olayemi T.D, Farin, G.O. and Ojebiyi, O.O. (2007).Replacement Value of biscuit waste on the
performance and egg quality parameters of laying hens.Proc.32nd Ann. Conf. Anim. Sci.
Ass.of Nig. (ASAN). Pp: 313-230.
Omoikhoje, and J.A.Imasuen, 2004. Response of broilers to dietary levels of processed pigeon
pea meal. Proc.Of 9th Ann. Conf. Anim. Sci. Ass. Of Nig. (ASAN).pp 23-25.
51
Omoikhoje S.O; D.OObasoyo; B.A Osifo and K.M.Iwaloye, (2010). Blood constituents of
broilers chickens as affected by cornflakes waste based diets. J. of Res.And policies.
5(1), 54-58.
OyedejI, J.O., Ajayi, H.I., Epoudo, I., Edem, I.I. and Sokondi, R.S (2015). The effects of blood
rumen content mixture (BRCM) meal supplemented with yeast on the performance and
gut microbial populations of broiler chickens. Agrosearch 15 (2). Pp: 93 – 105
SAS.(2011). Statistical Analysis Systems, Version 9.3, SAS, Institute Inc. Carry N.C. USA.
Ukachukwu, S. N. (2005). Studies on the nutritive value of composite cassava pellets for
poultry: chemical composition and Metabolizable energy. Livestock Research for
Development 17 (11)
52