Saf102-Lecture 7: Industrial Hygiene
Saf102-Lecture 7: Industrial Hygiene
TERMINOLOGY
OSHA – Occupational Safety and Health Administration
o PEL – Permissible Exposure Limit
NIOSH – National Institute of Occupational Safety and Health
o REL – Recommended Exposure Level
ACGIH – American Conference for Governmental Industrial Hygienists
o TLV – Threshold Limit Value
UNITS OF CONCENTRATION
ppm – parts per million
Mg/m^3 – milligrams per cubic meter
mppcf – millionth of a particle per cubic foot
f/cc – fibers per cubic centimeter
INTRODUCTION
Industrial hygiene is the science or art that is devoted to the anticipation, recognition,
evaluation, and control of those environmental factors or stresses arising in or from the
workplace, that may cause sickness, impaired health and well-being, or significant
discomfort and inefficiency among workers.
ROUTES OF ENTRY
1. Inhalation – airborne contaminants
2. Absorption – penetration through skin
3. Ingestion – eating and drinking
TYPES OF EXPOSURE
1. Acute – short term period between exposure and onset of symptoms
2. Chronic – long-term, sometimes permanent, health effects due to repeated
exposure to certain chemicals. Sometimes, chronic effects can occur at
concentrations below which acute effects are experienced
ENVIRONMENTAL FACTORS OR STRESSES
Chemical Hazards
1. Gases
2. Vapors
3. Dusts
4. Fumes
5. Mists
6. Smoke
Physical Hazards
1. Non-Ionizing Radiation
2. Ionizing Radiation
3. Noise
4. Vibration
5. Extreme Temperatures
6. Extreme Pressures
Biological Hazards/Microorganisms
1. Insects
2. Molds
3. Yeast
4. Fungi
5. Bacteria
6. Virus
Ergonomic Hazards
1. Work Station Design
2. Repetitive Motion
3. Improper Lifting
4. Improper Reaching
5. Poor Visual Condition
Microorganisms
1. Insects
2. Molds
3. Yeast
4. Fungi
5. Bacteria
6. Virus
CHEMICAL EXPOSURE
There are three possible ways you can be exposed to chemical:
1. Inhalation or breathing chemical vapors
a. May cause reduced lung function
2. Skin and eye contact
a. Spraying two component SPF chemicals into the air that could pose
potential inhalation and skin exposure hazard
3. Ingestion
a. Avoid eating, drinking, or other hand-to-mouth contact near SPF
chemicals
b. Remove gloves and wash your hands after working with chemicals.
OSHA, U.S. Department of Labor
- Describes actions employers must take to reduce risk of chemical exposure in
the workplace
- Exposure Control Plan (ECP)