Safety Data Sheet: Product Name: MOBIL RARUS 829
Safety Data Sheet: Product Name: MOBIL RARUS 829
Safety Data Sheet: Product Name: MOBIL RARUS 829
______________________________________________________________________________________________________________________
PRODUCT
Product Name: MOBIL RARUS 829
Product Description: Synthetic Base Stocks and Additives
Product Code: 201560203020, 606269-85
Intended Use: Compressor oil
COMPANY IDENTIFICATION
Supplier: AMPOL AUSTRALIA PETROLEUM PTY LTD
ABN 17 000 032 128
29-33 Bourke Rd
Alexandria
New South Wales 2015 Australia
This material is not hazardous according to regulatory guidelines (see (M)SDS Section 15).
Health Hazards:
High-pressure injection under skin may cause serious damage. Excessive exposure may result in eye, skin, or
respiratory irritation.
Environmental Hazards:
No significant hazards.
Product Name: MOBIL RARUS 829
Revision Date: 06 Oct 2021
Page 2 of 9
______________________________________________________________________________________________________________________
NOTE: This material should not be used for any other purpose than the intended use in Section 1 without expert
advice. Health studies have shown that chemical exposure may cause potential human health risks which may vary
from person to person.
* All concentrations are percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. Other
ingredients determined not to be hazardous up to 100%.
INHALATION
Immediately remove from further exposure. Get immediate medical assistance. For those providing
assistance, avoid exposure to yourself or others. Use adequate respiratory protection. Give supplemental
oxygen, if available. If breathing has stopped, assist ventilation with a mechanical device.
SKIN CONTACT
Wash contact areas with soap and water. Remove contaminated clothing. Launder contaminated clothing
before reuse. If product is injected into or under the skin, or into any part of the body, regardless of the
appearance of the wound or its size, the individual should be evaluated immediately by a physician as a
surgical emergency. Even though initial symptoms from high pressure injection may be minimal or absent, early
surgical treatment within the first few hours may significantly reduce the ultimate extent of injury.
EYE CONTACT
Flush thoroughly with water. If irritation occurs, get medical assistance.
INGESTION
Seek immediate medical attention.
NOTE TO PHYSICIAN
None
EXTINGUISHING MEDIA
Appropriate Extinguishing Media: Use water fog, foam, dry chemical or carbon dioxide (CO2) to extinguish
flames.
Product Name: MOBIL RARUS 829
Revision Date: 06 Oct 2021
Page 3 of 9
______________________________________________________________________________________________________________________
FIRE FIGHTING
Fire Fighting Instructions: Evacuate area. Prevent run-off from fire control or dilution from entering
streams, sewers or drinking water supply. Fire-fighters should use standard protective equipment and in
enclosed spaces, self-contained breathing apparatus (SCBA). Use water spray to cool fire exposed surfaces
and to protect personnel.
Hazardous Combustion Products: Aldehydes, Incomplete combustion products, Oxides of carbon, Smoke,
Fume, Sulphur oxides
FLAMMABILITY PROPERTIES
Flash Point [Method]: >220°C (428°F) [ASTM D-92]
Flammable Limits (Approximate volume % in air): LEL: 0.9 UEL: 7.0
Autoignition Temperature: N/D
NOTIFICATION PROCEDURES
In the event of a spill or accidental release, notify relevant authorities in accordance with all applicable
regulations.
PROTECTIVE MEASURES
Avoid contact with spilled material. See Section 5 for fire fighting information. See the Hazard Identification
Section for Significant Hazards. See Section 4 for First Aid Advice. See Section 8 for advice on the minimum
requirements for personal protective equipment. Additional protective measures may be necessary, depending
on the specific circumstances and/or the expert judgment of the emergency responders.
SPILL MANAGEMENT
Land Spill: Stop leak if you can do so without risk. Recover by pumping or with suitable absorbent.
Water Spill: Stop leak if you can do so without risk. Confine the spill immediately with booms. Warn other
shipping. Remove from the surface by skimming or with suitable absorbents. Seek the advice of a specialist
before using dispersants.
Water spill and land spill recommendations are based on the most likely spill scenario for this material;
however, geographic conditions, wind, temperature, (and in the case of a water spill) wave and current direction
and speed may greatly influence the appropriate action to be taken. For this reason, local experts should be
consulted. Note: Local regulations may prescribe or limit action to be taken.
ENVIRONMENTAL PRECAUTIONS
Large Spills: Dyke far ahead of liquid spill for later recovery and disposal. Prevent entry into waterways,
sewers, basements or confined areas.
HANDLING
Avoid all personal contact. This material is not intended for use in air compressors for breathing applications.
Prevent small spills and leakage to avoid slip hazard. Material can accumulate static charges which may cause
Product Name: MOBIL RARUS 829
Revision Date: 06 Oct 2021
Page 4 of 9
______________________________________________________________________________________________________________________
an electrical spark (ignition source). When the material is handled in bulk, an electrical spark could ignite any
flammable vapors from liquids or residues that may be present (e.g., during switch-loading operations). Use
proper bonding and/or earthing procedures. However, bonding and earthing may not eliminate the hazard
from static accumulation. Consult local applicable standards for guidance. Additional references include
American Petroleum Institute 2003 (Protection Against Ignitions Arising out of Static, Lightning and Stray
Currents) or National Fire Protection Agency 77 (Recommended Practice on Static Electricity) or CENELEC
CLC/TR 50404 (Electrostatics - Code of practice for the avoidance of hazards due to static electricity).
STORAGE
The type of container used to store the material may affect static accumulation and dissipation. Do not store in open
or unlabelled containers.
Material is defined under the National Standard [NOHSC:1015] Storage and Handling of Workplace Dangerous Goods.
SECTION 8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Biological limits
ENGINEERING CONTROLS
The level of protection and types of controls necessary will vary depending upon potential exposure conditions.
Control measures to consider:
No special requirements under ordinary conditions of use and with adequate ventilation.
PERSONAL PROTECTION
Personal protective equipment selections vary based on potential exposure conditions such as applications,
handling practices, concentration and ventilation. Information on the selection of protective equipment for use
with this material, as provided below, is based upon intended, normal usage.
For high airborne concentrations, use an approved supplied-air respirator, operated in positive pressure mode.
Supplied air respirators with an escape bottle may be appropriate when oxygen levels are inadequate,
gas/vapour warning properties are poor, or if air purifying filter capacity/rating may be exceeded.
Hand Protection: Any specific glove information provided is based on published literature and glove
manufacturer data. Glove suitability and breakthrough time will differ depending on the specific use conditions.
Contact the glove manufacturer for specific advice on glove selection and breakthrough times for your use
Product Name: MOBIL RARUS 829
Revision Date: 06 Oct 2021
Page 5 of 9
______________________________________________________________________________________________________________________
conditions. Inspect and replace worn or damaged gloves. The types of gloves to be considered for this material
include:
Nitrile,Viton
Chemical resistant gloves are recommended.
Eye Protection: If contact is likely, safety glasses with side shields are recommended.
Skin and Body Protection: Any specific clothing information provided is based on published literature or
manufacturer data. The types of clothing to be considered for this material include:
Chemical/oil resistant clothing is recommended.
Specific Hygiene Measures: Always observe good personal hygiene measures, such as washing after
handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective
equipment to remove contaminants. Discard contaminated clothing and footwear that cannot be cleaned.
Practise good housekeeping.
ENVIRONMENTAL CONTROLS
Comply with applicable environmental regulations limiting discharge to air, water and
soil. Protect the environment by applying appropriate control measures to prevent or limit
emissions.
Note: Physical and chemical properties are provided for safety, health and environmental considerations only
and may not fully represent product specifications. Contact the Supplier for additional information.
GENERAL INFORMATION
Physical State: Liquid
Colour: Brown
Odour: Characteristic
Odour Threshold: N/D
OTHER INFORMATION
Freezing Point: N/D
Product Name: MOBIL RARUS 829
Revision Date: 06 Oct 2021
Page 6 of 9
______________________________________________________________________________________________________________________
Melting Point: N/A
Pour Point: -30°C (-22°F) [ASTM D97]
______________________________________________________________________________________________________________________
Repeated Exposure: No end point data for Not expected to cause organ damage from prolonged or repeated
material. exposure. Based on assessment of the components.
OTHER INFORMATION
For the product itself:
Component concentrations in this formulation would not be expected to cause skin sensitization, based on tests of the
components, this formulation, or similar formulations.
Contains:
Synthetic base oils: Not expected to cause significant health effects under conditions of normal use, based on
laboratory studies with the same or similar materials. Not mutagenic or genotoxic. Not sensitising in test animals and
humans. N-phenyl-1-naphthylamine (PAN): A single oral overexposure may result in clinical signs/symptoms of
cyanosis, headache, shallow respiration, dizziness, confusion, low blood pressure, convulsions, coma, or jaundice.
Hematuria may occur due to bladder and kidney irritation, and anemia may develop later. Repeated exposure in
laboratory animals caused liver and kidney damage and depressed bone marrow activity. Undiluted PAN is a skin
sensitiser. Human testing of lubricants containing 1.0% PAN resulted in no reactions indicative of sensitisation.
IARC Classification:
The following ingredients are cited on the lists below: None.
The information given is based on data for the material, components of the material, or for similar materials, through the
application of bridging principals.
ECOTOXICITY
Material -- Not expected to be harmful to aquatic organisms.
MOBILITY
Base oil component -- Low solubility and floats and is expected to migrate from water to the land.
Expected to partition to sediment and wastewater solids.
ECOLOGICAL DATA
Ecotoxicity
Test Duration Organism Type Test Results
Aquatic - Chronic Toxicity 21 day(s) Daphnia magna LOELR 1 % weight: data for similar
materials
Product Name: MOBIL RARUS 829
Revision Date: 06 Oct 2021
Page 8 of 9
______________________________________________________________________________________________________________________
SECTION 13 DISPOSAL CONSIDERATIONS
Disposal recommendations based on material as supplied. Disposal must be in accordance with current applicable
laws and regulations, and material characteristics at time of disposal.
DISPOSAL RECOMMENDATIONS
Product is suitable for burning in an enclosed controlled burner for fuel value or disposal by supervised
incineration at very high temperatures to prevent formation of undesirable combustion products. Protect the
environment. Dispose of used oil at designated sites. Minimize skin contact. Do not mix used oils with solvents,
brake fluids or coolants.
Empty Container Warning Empty Container Warning (where applicable): Empty containers may contain residue
and can be dangerous. Do not attempt to refill or clean containers without proper instructions. Empty drums should
be completely drained and safely stored until appropriately reconditioned or disposed. Empty containers should be
taken for recycling, recovery, or disposal through suitably qualified or licensed contractor and in accordance with
governmental regulations. DO NOT PRESSURISE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND, OR EXPOSE
SUCH CONTAINERS TO HEAT, FLAME, SPARKS, STATIC ELECTRICITY, OR OTHER SOURCES OF IGNITION.
THEY MAY EXPLODE AND CAUSE INJURY OR DEATH.
Marine Pollutant: No
This material is not considered hazardous according to Australia Model Work Health and Safety Regulations.
No Poison Schedule number allocated by the Standard for the Uniform Scheduling of Medicines and Poisons (SUSMP)
established under the Therapeutic Goods Act.
Listed or exempt from listing/notification on the following chemical inventories : AIIC, ENCS, IECSC,
ISHL, TCSI, TSCA
Special Cases:
Inventory Status
Product Name: MOBIL RARUS 829
Revision Date: 06 Oct 2021
Page 9 of 9
______________________________________________________________________________________________________________________
KECI Restrictions Apply
NDSL Restrictions Apply
PICCS Restrictions Apply
N/D = Not determined, N/A = Not applicable, STEL = Short-Term Exposure Limit, TWA = Time-Weighted Average
KEY TO THE H-CODES CONTAINED IN SECTION 3 OF THIS DOCUMENT (for information only):
H302: Harmful if swallowed; Acute Tox Oral, Cat 4
H315: Causes skin irritation; Skin Corr/Irritation, Cat 2
H317: May cause allergic skin reaction; Skin Sensitisation, Cat 1
H361(D): Suspected of damaging the unborn child; Repro Tox, Cat 2 (Develop)
H361(F): Suspected of damaging fertility; Repro Tox, Cat 2 (Fertility)
H373: May cause damage to organs through prolonged or repeated exposure; Target Organ, Repeated, Cat 2
H400: Very toxic to aquatic life; Acute Env Tox, Cat 1
H410: Very toxic to aquatic life with long lasting effects; Chronic Env Tox, Cat 1
H413: May cause long lasting harmful effects to aquatic life; Chronic Env Tox, Cat 4
-----------------------------------------------------------------------------------------------------------------------------------------------------
DGN: 2008446DAU (554828)
-----------------------------------------------------------------------------------------------------------------------------------------------------
Prepared by: Exxon Mobil Corporation
EMBSI, Clinton NJ USA
Contact Point: See Section 1 for Local Contact number
End of (M)SDS