REVISIONS

REV DESCRIPTION DATE APPROVED

R0 INITIAL RELEASE 01/24/19 TDM

R1 GEN B RING TERMINALS 01/30/19 TDM
R2 -ADDED GTN 650 PRESETS 05/01/19 TDM
-ROLL SERVO GROUND WIRE EXTENDED
DRAWING KEY -RING TERMINAL UPSIZED FOR EFIS
WIRING HARNESS NUMBER IF APPLICABLE SWITCH & BACKUP BATT
-L7258 (WHT) WAS L7019 (DUPLICATE #)
CIRCUIT LETTER FUNCTION CONNECTOR BODY
ES-XXXXX WH-XXXXX C411J
1 2 3 4 5 6 7 8 9 CONNECTOR AV-532L CABLE RECEIVED CONNECTOR
LETTER CIRCUITS PART NUMBER
11
IDENTIFICATION R3 AND LENGTH SPEC
05/06/19 TDM
NUMBER
C CONTROL SURFACE
BORDER COLOR CORRESPONDS TO
R4 E6023 WIRES CROSSED AT HIC TO 11/08/19 BPM
D INSTRUMENT BLUE: INDICATES PIN & PIN NUMBER NEGATE AV-60009 PCB ERROR: WHT NOW
WIRES SUPPLIED ALREADY BACKGROUND COLOR OF LABEL AND
E ENGINE INSTRUMENT MAX AMPERAGE PER PIN LO & WHT/BLU NOW HI, ADDED OPTIONAL
CONNECTED TO A HEAT SHRINK COLOR. WHT AND BLACK
F FLIGHT INSTRUMENTS ARE INTERCHANGEABLE.
CONNECTOR AITHRE SHIELD EX CO/O2 DETECTOR,
H HEATING VENTILATING
J IGNITION
ADDED F7599 & F7600 FOR OPTIONAL
GREEN: INDICATES SHIELD
K ENGINE CONTROL WHT: 40V MAX WIRES TO BE INSERTED INTO STRIPE SHIELD GARMIN G5, ON F6262 & Q6300 ES 31880
GRN: 100V MAX A CONNECTOR BY BUILDER COLOR WIRE WAS ES 36152, Q6300 27 WAS 40, ADDED
L LIGHTING RED: 400V MAX WIRE
P POWER CONTROL WIRE COLOR CABIN LIGHT DIMMER, DELETE L6029, ALL
BLUE DASHED: INDICATES GAUGE
Q FUEL PCB TRACE WIRES TO GMC 307 EXTENDED 4 INCHES,
OPTIONAL WIRE LENGTH
R RADIO NAME
MAX AMPERAGE (INCHES) NUMEROUS CORRECTIONS
RZ HEADPHONE

36
YXX XC:22S XX XXX/XXX

X.X
RATING OF CIRCUIT EDC-10A GND
T SPECIAL ELECTRONIC (NOTE CONNECTOR PIN
SOLID THICK:
WIRES SUPPLIED
R5 CHANGED CO DETECTOR WIRING, 01/06/20 BPM
TC RADIO CONTROL RATING MAY BE LESS) LENGTH OF WIRE (NOT COUNTING ADDED WH-00144
CONNECTORS) IN KIT
TD AIRBORNE ANNOUNCING PIN NOMENCLATURE
TP BEACON
BLUE: INDEPENDENT RATING DESCRIBES ITS FUNCTION TO THE SHIELDED BLUE DASHED:
GARMIN GTN 650 INTERNAL PRESETS R6 CORRECTED CABIN LIGHT TO OPTIONAL, 02/14/20 BPM
DEVICE THE PIN IS CONNECTED TO X (NUMBER OF WIRES) MULTI CONDUCTOR WIRE OPTIONAL
CO DETECTOR WIRE COLORS TO
TQ TRANSMITOR RECEIVER YELLOW: DEPENDENT UPON RED: POWER
W WARNING EMERGENCY
WIRE NUMBER NOTE: IF NO WIRE COLOR WIRES M27500 STD
OTHER ITEMS ON CIRCUIT BLUE: AUDIO AIRINC 429 CONFIGURATION
IS STATED, WIRE COLOR
WHITE: DATA CIRCUIT FUNCTION LETTER
IS WHITE
ORANGE: MATCHED DATA PAIR D-SUB PIN NUMBER
- AIRINC 429 IN 1 LOW EFIS FORMAT 2
GREEN: GROUND
- AIRINC 429 IN 2 LOW OFF
- AIRINC 429 OUT 1 LOW GAMA FORMAT 1
- AIRINC 429 OUT 2 LOW OFF
- SDI LNAV 1

RS-232 CONFIGURATION (CHANNEL, INPUT, OUTPUT)

ELECTRICAL SYSTEM BENCH TEST PROCEDURE - RS-232 1 MAPMX FORMAT 2 MAPMX FORMAT 2
- RS-232 2 OFF ADS-B+ FORMAT 1
Avionics Group - RS-232 3 OFF OFF
1.___Check PFD & MFD Power On - RS-232 4 CONNECT FORMAT 2 CONNEXT FORMAT 2
2.___SkyView Check PFD and MFD recognize a USB stick
3.___Install latest software and settings per the readme files (applicable portions) on the Van's Web Site MAIN SYSTEM CONFIGURATION
a.___Setup X Pndr Hex Code - AIRFRAME TYPE FIXED-WING
b.___Setup AP servos if installed - AIR/GROUND THRESHOLD 30KT
4.___Check PFD & MFD recognize all LRU's - AIR/GROUND DISCRETE ACTIVE FOR AIRBORNE
5.___Check X pndr will transmit. - GPS ANT. HEIGHT ABOVE GND 4FT
6.___Check COM turns on. - GPS SELECT AUTO
7.___Check PFD recognizes COM, and can push frequencies to COM radio - HEADING SRC INPUT CONNECTED
8.___Check Backup Battery Function PFD - RADIO ALTIMETER INPUT NOT CONNECTED
9.___If installed check AP Control Head function (knobs function for SkyView as well) - ALTITUDE SRC INPUT CONNECTED
- ENHANCED LIGHTING MODE DISABLED
ELECTRICAL SYSTEM NOTES
Audio Group - CROSSFILL STATUS ALERT DISABLED
- USE M22759/16 OR M27500 TEFZEL AIRCRAFT WIRE. CONTACT VAN'S ABOUT USING OTHER EQUIV. 1.___Configure GTN 650 in accordance with "GTN 650 Internal Presets" - SYSTEM ID GTN 1
2.___Configure GMA 245 in accordance with "GMA 245 Internal Presets" - DATABASE SYNC PILOT CONTROL
- USE MIL-I-23053 HEATSHRINK. CONTACT VAN'S ABOUT USING OTHER EQUIV. 3.___Check Pilot Headset Jack - AIRSPACE LABELS ENABLED
- LABEL THE FLYING LEAD OF EACH WIRE WITH THE TRUNCATED NOMENCLATURE AND WIRE NUMBER. 4.___Check Pilot Mic Jack for Xmit - CHECKLIST PAGE TITLE CHECKLIST
5.___Check Co-Pilot Headset Jack
- CONNECT ALL 20-24 AWG WIRES TO D-SUBS USING ES-SA-1017 SOCKETS OR ES-SA-1018 PINS. PERMISSIBLE TO STRIP 18 AWG WIRE TO FIT ES-SA-1017 6.___Check Co-Pilot Mic Jack for Xmit
SOCKETS OR ES-SA-1018 PINS. ALL CRIMPS TO BE MADE PER MIL-C-22520F (1.2.2) USING A TYPE 1 TOOL. COM CONFIGURATION
7.___If installed check XM music output to headset. - COM RADIO ENABLED
- USE ONLY NOR-COMP BACKSHELLS ON D-SUB CONNECTORS (WITH THE EXCEPTION OF 50-PIN CONNECTORS) - COM SQUELCH MODE BASIC
Cockpit Group - COM RF SQUELCH 0%
- HARNESS MUST BE TESTED WITH ALL AVIONICS IN ACCORDANCE WITH THE "ELECTRICAL SYSTEM BENCH TEST PROCEDURE". RESULTS ARE TO BE
NOTE: If customer has selected the pre-wired stick option then use their control sticks - MIC 1 GAIN +12DB
SUPPLIED TO VAN'S FOR EACH HARNESS.
1.___Check Pilot TX Button - SIDETONE SOURCE EXTERNAL
-CRIMPED MOLEX, TYCO, AND AMP TERMINALS ARE TO BE CRIMPED WITH THE MANUFACTURER'S RECOMMENDED CRIMPING TOOL. 2.___Check Pilot Trim Buttons (Both Directions) - SIDETONE VOLUME +62.5DB
a.___Verify proper trim direction movement on screen indicator and servo with input
- CRIMPED TERMINALS ARE TO BE INDIVIDUALLY PULL TESTED.
3.___Check Co-Pilot TX Button VOR/LOC/GS CONFIGURATION
-DO NOT COVER WIRES WITH WIRE NET. - NAV RADIO ENABLED
4.___Check Co-Pilot Trim Buttons (Both Directions) - AIRINC 429 CONFIGURATION TX LOW SDI VOR/ILS 1
- HARNESSES ARE TO BE BUNDLED WITH LACING CHORD, WITH THE EXCEPTION OF BLUE TIE-WRAPS USED AT BULKHEAD STATIONS.
a.___Verify proper trim direction movement on screen indicator and servo with input
- ALL 3 CONDUCTOR JACKETED NON-SHIELDED WIRE MAY BE REPLACED WITH TWISTED WIRES OF THE SAME AWG SIZE AND THE SAME WIRE COLOR. 5.___Check function of AP disconnect switch near throttle. DISCRETE INPUTS
6.___Check Pilot AP Disconnect Switch - J1001-36 REMOTE GO AROUND
- ADJUST SOLDER SPLICE / RING TERMINAL SIZE AS REQUIRED TO ACCOMMODATE DESIRED WIRE GAUGE(S). MAINTAIN RING TERMINAL STUD/TAB SIZE.
7.___Check Co-Pilot AP Disconnect Switch
8.___Check Pilot COM Freq Swap
9.___Check Co-Pilot Freq Swap
10.___Check Dimmer (Note PCB portion will be checked during AV-60000 Check)
a.___Turn on all switches. Check that all lighted switches lights turn on and dim. (Ignore wires going to cabin light.)
11.___Check canopy latch switch
12.___Check flap motor function both directions
13.___Check for power output at USB connectors / Power Outlet

Wing Group
1.___Check Stall Warning
2.___Check NAV/Strobe Lights
3.___Check Landing Lights (Both if applicable)
4.___Check Wig Wag Function

iS Engine Group
1.___Check Master Relay Switch grounds out wire going to master relay
2.___Check Key switch connects HIC connector start pins
3.___Check spar pin light comes on when spar pin switches are not grounded.
4.___Check emergency switch provides power to Power X3 connector Pin 3
5.___Check Emergency Li Bat Warn Wire turns on warning in EFIS when grounded. (NOTE Check this error)
6.___Check fuel pump A and B switches for function

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 1 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

R6 SEE PG 1

PFD
GDU 460

1P4X02

5
36

36
SIGNAL GROUND R7214 22 3 GRN

MONO OUT AUDIO HI

1
WHT
R7541 WHT GMA 245 (ALERT 1)

19 18

19 18
MONO OUT AUDIO LO WHT/BLU

STEREO AUDIO OUT RIGHT

STEREO AUDIO OUT LEFT
3

3
33 50 17 49 16 32 15 31 43 10 27 28 45 46 37 44 47 48 14 30 29 13 40 34 24 41

33 50 17 49 16 32 15 31 43 10 27 28 45 46 37 44 47 48 14 30 29 13 40 34 24 41
(GTN GPS POS) RS-232 OUT 5 WHT/ORN

(GTN GPS POS) RS-232 IN 5 WHT R7507 WHT GTN 650 MAPMX
SIGNAL GROUND WHT/BLU

(ELT) RS-232 OUT 4 TP7171 WHT ELT

(ADS-B) RS-232 OUT 3 WHT
TQ7169 WHT GDL 5XR ADS-B
(ADS-B) RS-232 IN 3 WHT/BLU

(GMC 307) RS-232 OUT 2 WHT

C7174 WHT GMC 307 AP MODULE
(GMC 307) RS-232 IN 2 WHT/BLU

(GTN 650 CONNEXT) RS-232 OUT 1 WHT/ORN

(GTN 650 CONNEXT) RS-232 IN 1 WHT R7537 WHT GTN 650 CONNEXT
SIGNAL GND WHT/BLU

SIGNAL GND F7207 22 3 GRN

CAN BUS HI WHT

F7547 2C:22S 21 WHT GAD 29
CAN BUS LO WHT/BLU WHT/BLU
WH-00136

ES-00019

CAN BUS TERMINATION F7179 22 2 WHT/BLU

SIGNAL GROUND
CDU SYSTEM ID PROGRAM* 1 F7208 22 2.5 WHT

14V LIGHTING BUS HI L7048 22 27 PRP/YEL LIGHTING BUS SPLITPOINT

AIRCRAFT POWER 2 P7209 RED
BACKUP BATTERY
POWER GROUND P7210 BLK

AIRCRAFT POWER 1 F7075 RED

POWER MODULE
POWER GROUND F7076 BLK

CONFIG MODULE GROUND GND

1

011-00979-22 22 2.5 BLK

CONFIG MODULE POWER VCC

4

011-00979-22 22 2.5 RED

ES-00059

CONFIG MODULE DATA DATA

3

011-00979-22 22 2.5 YEL

CONFIG MODULE CLOCK CLK

2

011-00979-22 22 2.5 WHT

CONFIG MODULE + HARNESS

011-00979-22

EFIS BATTERY

TCW
TCW IBBS-12V-3AH

5
10 11 12 13 14 15

10 11 12 13 14 15
POWER OUTPUT P7154 18 85 RED SPLIT POINT 4
MFD POWER OUTPUT P7209 18 30 RED PFD
POWER OUTPUT P7146 18 29 RED EMS
GDU 460
2P4X02

POWER OUTPUT
5
19 45 46 15 31 16 32

19 45 46 15 31 16 32

AIRCRAFT POWER 1 F7087 RED

POWER MODULE GROUND P7210 18 32 BLK PFD (POWER GROUND PIN 15)
POWER GROUND F7088 BLK
GROUND P7212 18 2.5 BLK P7211 18 13 BLK
ES-00019
AIRCRAFT POWER 2
GROUND
9

9
WHT P7213 18 15 BLK

WH-00136
POWER GROUND F7231 22 4 GRN F7550 WHT GMA 245
POWER + PASS THRU INPUT
8

8
WHT/BLU
CAN BUS HI F7225 22 2 WHT WHT
ES-00019
AP PITCH SERVO POWER + PASS THRU INPUT
7

7
F7173 WHT
WH-00136

CAN BUS LO F7226 22 2 WHT/BLU WHT/BLU

ES-00019
POWER + PASS THRU INPUT ES 36154 (#10) ES 36154 (#10)
6

STEREO AUDIO OUT RIGHT

POWER + IN, CHARGE, SENSE POWER MODULE
5

P7227 18 27 RED
STEREO AUDIO OUT LEFT
3

X
4

STEREO AUDIO OUT LO

2

LOW VOLT WARN

3

3
ES-00061 (FEMALE)
ES-00059
35 34 24 29 13 47 48 43

35 34 24 29 13 47 48 43

14V LIGHTING BUS HI L7045 22 2 PRP/YEL LIGHTING BUS SPLITPOINT

BATTERY INFO EMS (Voltage 2)
2

P7141 22 30 WHT
(GSU 25 BACKUP) RS-232 OUT 1 WHT
GSU 25 ENABLE-BACKUP SWITCH EFIS BATTERY SWITCH
1

F7508 2C:22S 127 WHT P7223 22 30 WHT

(GSU 25 BACKUP) RS-232 IN 1 WHT/BLU

(ADS-B) RS-232 OUT 3 WHT

TQ7580 WHT GDL 5XR ADS-B/FIS-B/XM WEATHER 14401 NE KEIL RD. NE
(ADS-B) RS-232 IN 3 WHT/BLU

(GTN GPS POS) RS-232 IN 5 WHT

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA
F7599 WHT GTN 650 MAPMX
SIGNAL GROUND WHT/BLU

SIGNAL GROUND F7600 22 3 GRN

ROTAX 912iS G3X NAVCOM
ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 2 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

R6 SEE PG 1
PILOT STICK GRIP CO-PILOT STICK GRIP

(PITCH TRIM DOWN) (PITCH TRIM DOWN)

1
C7117 RED R-AL 22 RED C7115 RED R-AL 22 RED
POWER MODULE (PITCH TRIM UP) POWER MODULE (PITCH TRIM UP)

CO-PILOT HEADSET JACKS

2
C7118 GRN R-AL 22 GRN C7116 GRN R-AL 22 GRN

(AP DISC) (AP DISC)

AP DISCONNECT SPLITPOINT AP DISCONNECT BUTTON

3
C7127 22 5 BLU R-AL 22 BLU C7257 BLU R-AL 22 BLU

(HPHN R)
WHT/ORN
(FREQ FLOP) (FREQ FLOP)

RAY ALLEN G405

RAY ALLEN G405

WH-00136

WH-00136
GMA 245 GMA 245

4
R7181 ORN R-AL 22 ORN R7180 ORN R-AL 22 ORN
(HPHN L)
RZ7544 WHT WHT CO-PILOT HEADPHONE
(PTT) (PTT) (HPHN LO)
PILOT HEADSET JACKS CO-PILOT HEADSET JACKS

5
R7193 WHT/BRN R-AL 22 WHT R7192 BRN R-AL 22 WHT WHT/BLU

(GND) (GND) GMA 245

6
L7203 22 4 BLK R-AL 22 BLK L7201 22 4 BLK R-AL 22 BLK
(MIC)
WHT
LEFT WING CONNECTOR RIGHT WING CONNECTOR

7
L7204 BLK L7202 BLK

ES-00321 (FEMALE)
(PTT)
ES 36154 (#10) ES 36154 (#10) RZ7546 WHT WHT/ORN CO-PILOT MIC

ES-00140 (MALE)

ES-00140 (MALE)
8

8
(MIC LO)
WHT/BLU

ES-00321
9

9
CO-PILOT STICK R7192 22 76 BRN

5
POWER MODULE RZ-6055 ORN/BLK AUDIO POWER FOR LEMO (IF INSTALLED)

LEFT WING CONNECTOR RIGHT WING CONNECTOR

PILOT CONTROL STICK CO-PILOT CONTROL STICK PILOT HEADSET JACKS
RIGHT LEFT
(HPHN R)
WING WING WHT/ORN

(HPHN L)
RZ7545 WHT WHT PILOT HEADPHONE
(HPHN LO)
WHT/BLU

POWER POWER
GMA 245
MODULE MODULE
(MIC)
WHT

(PTT)
RZ7543 WHT WHT/ORN PILOT MIC
L7095
L7204

L7097

L7090

L7089

L7098

L7202

L7092

L7091
(MIC LO)
WHT/BLU
18
W7205
18

18

18

18

18

18
22

22
L7093

L7097

L7094

L7098

L7096
PILOT STICK R7193 22 76 WHT/BRN
72
105

105
14

14
72

72

55

55
WHT/YEL

POWER MODULE RZ6054 AUDIO POWER FOR LEMO (IF INSTALLED)

WHT/GRN

WHT/GRN
ORN/BLK

WHT/YEL
BRN/YEL

YEL/RED

YEL/RED
YEL/BLU

YEL/BLU
GRN

GRN
BLK

BLK
YEL

YEL
11 11

1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8
ES-00077 WH-00136 ES-00078 WH-00136
OPTIONAL AUDIO OUTPUT
COMPONENTS NOT INCLUDED WITH HARNESS
ES-00078 WH-00032 ES-00077 WH-00033
INSTALL ON CO-PILOT SIDE OF AIRCRAFT
1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8
11 11 (PHN GND)
WHT/ORN
L7514

WHT/ORN

L6312

WHT/ORN
HEADPHONE
W216

W218

WHT/BLU

WHT/BLU
L214

L213

L216

L214

L213
(HPHN L)
WHT
WHT

WHT
JACK
1/4
(HPHN R)
WHT/BLU
WHT

GRN
RED

RED
BLK

BLU

BLK
YEL

YEL
RZ7194 22 6 WHT
RZ7195 22 6 WHT
WING GND WING GND
L6310 GRN L6310 GRN
ES 31890 (#8) ES 31890 (#8)
L6310

L6310
OPTIONAL
AUXILIARY AUDIO
WING GND

WING GND
ES 31890 (#8)

ES 31890 (#8)
OUTPUT JACK
3061056 3062055 3061056 3062055 (FOR VIDEO CAMERA) ES RS 274-249
STEREO JACK
WHT

WHT
L211 BLK 1 1 L211 BLK 1 1
ES 31890 (#8) ES 31890 (#8) 47K ohm
10
STALL WARN
WHT 2 2 WHT 2 2
WING

MICRO WHT/BLU 3 3 WHT/BLU 3 3 9

TIP

WING
SWITCH 47K ohm

TIP
WHT/ORN 4 4 WHT/ORN 4 4
5 5 5 5
GRN

GRN
RED

RED
BLK

BLK
YEL

YEL
W217 BLK
11 11 11 11
ES DV18-188-M
ES 31890 (#8)
OPTIONAL LEMO JACK
6
6
6
6

6
6
6
6
L6309 BLK

L6309 BLK
FOR PRODUCTION OF "WH-000125 LEMO". ADD JACKS TO BOTH PILOT AND CO-PILOT LOCATIONS.
22
22
22
22

22
22
22
22
THE LEMO JACK SHOULD BE INSTALLED INLINE WITH AND 1 INCH BEHIND THE MIC/HEADPHONE JACKS.

R7192 BRN
ES 36152 (#6) ES 36152 (#6)
(MIC GND)
WHT/BLU
AEROLEDS PULSAR EXP AEROLEDS PULSAR EXP
(PTT)
R7189 WHT WHT/ORN MIC
(MIC)
3061055

3061056

3061055

3061056
ES 31890 (#8) ES 31890 (#8) WHT
L215 BLK 1 1 BLK L215 BLK 1 1 BLK

2 2 GRN NAV STROBE POS 2 2 GRN NAV STROBE POS (PHN GND)
LANDING

LANDING
WHT/ORN
3 3 BLU 3 3 BLU
(HPHN L)
R7188 WHT WHT HEADPHONE
4 4 YEL 4 4 YEL
(HPHN R)
WHT/BLU
5 5 RED 5 5 RED

6 6 6 6
5 5 5 5
AUDIO PWR

1
R7112 ORN/BLK .25

THESE COMPONENTS NOT INCLUDED IN AVIONICS KIT, NOR PART OF THE WH-00136. THESE COMPONENTS NOT INCLUDED IN AVIONICS KIT, NOR PART OF THE WH-00136. AUDIO GND

2
RZ7196 22 6 WHT X
LEMO JACK

SEE WH-00032 AND WH-00033 RV-12iS WING HARNESS DRAWINGS. SEE WH-00032 AND WH-00033 RV-12iS WING HARNESS DRAWINGS. HEADPHONE (L) 6 1

3
RZ7197 22 6 WHT X
5 2

HEADPHONE (R)

4
RZ7198 22 6 WHT X 4 3

MIC

5
RZ7199 22 6 WHT X

MIC GND

6
RZ7200 22 6 WHT X

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 3 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

R6 SEE PG 1

ANTENNA
XPNDR
USE GARMIN BACKSHELL

BLK
AUDIO PANEL GTN NAV/COM

40
RG-58/U
GMA 245
J1 P1003 (COM) GTN 650
5
COM 1 AUDIO IN HI COM AUDIO HI
9

7
WHT WHT

TQ7244
ES-00019
22 21 43 44 32 31 20 19 18 17 30 15 14 13 12 11 10

22 21 43 44 32 31 20 19 18 17 30 15 14 13 12 11 10

20 18

20 18
COM 1 IN AUDIO LO WHT/BLU R7501 3C:22S 21 WHT GTN 650 GMA 245 R7501 WHT WHT/BLU COM AUDIO LO
COM 1 MIC AUDIO OUT HI WHT/ORN COM MIC AUDIO LO
COM 1 MIC KEY GTN 650 COM MIC AUDIO HI

5
R7503 WHT/BRN WHT/ORN

11

11
COM 2 AUDIO IN HI GMA 245 R7503 22 21 WHT/BRN COM MIC KEY
COM 2 AUDIO LO CO-PILOT STICK

0
ORN 47 22 TC7555

XPNDR

27

27
COM 2 MIC AUDIO OUT HI TO GARMIN BACKSHELL PILOT STICK ORN 47 22 TC7556 ORN 22 15 TC7554 COM REMOTE TRANSFER

BNC
WH-00136
COM 2 MIC KEY

0
40 38 37 44 43 30

40 38 37 44 43 30
NAV 1 AUDIO IN HI WHT POWER
R7502 2C:22S 21 WHT GTN 650 NAV AUDIO 1 (VOR/ILS) GTX 35R
NAV 1 AUDIO IN LO WHT/BLU R7509 18 26 RED POWER
POWER MODULE

ES-00187 (44 PIN HI-DENSITY MALE)

NAV 2 AUDIO IN HI R7510 18 26 RED POWER
NAV 2 AUDIO IN LO POWER MODULE (GROUND LUG) R7515 BLK R7518 22 2 BLK GROUND CONNECT
TO GARMIN
ALERT 1 AUDIO IN HI WHT R7519 22 2 BLK GROUND
R7541 2C:22S 42 WHT GDU PFD (MONO AUDIO OUT) BNC TQ-7569 RG-58/U 86 BLK AV-00008 BACKSHELL
WH-00136

COM
ALERT 1 AUDIO IN LO WHT/BLU GROUND ANTENNA

ALERT 4 AUDIO IN HI WHT

R7504 2C:22S 13 WHT GTN 650 NAV AUDIO 2 (GPS)
ALERT 4 AUDIO IN LO WHT/BLU

ES 31890 (#8)
(STALL WARN) AUX 1 AUDIO IN HI W7542 WHT POWER MODULE
P1001
(STALL WARN) AUX 1 AUDIO IN LO

ES-00192 (62 PIN HI-DENSITY MALE)

5
78 36 77 20 19

78 36 77 20 19
POWER 1
AUX 2 AUDIO HI
7

POWER MODULE R7528 RED POWER 1

AUX 2 LO
8

POWER MODULE (GROUND LUG) R7516 BLK GROUND

35 34 33

35 34 33

PILOT MIC HI WHT SHLD

(325-00238-01 SUPPLIED IN
TO/GA SWITCH C7587 YEL DISCRETE INPUT 2 (TO/GA)

RECEPTACLE

24 45

24 45
CONNECTOR KIT)
PILOT MIC PTT WHT/ORN RZ7543 3C:22S 70 WHT PILOT HEADSET JACK GND BLK BLK USB GROUND

TYPE B
GROUND

USB
PILOT MIC LO WHT/BLU D- WHT WHT USB DATA LO
AUDIO OUT HI

4
WHT WHT
EMS GMA 245 D+ USB DATA HI

2
F7549 WHT R7504 WHT GRN GRN

27 23

27 23
WHT/BLU WHT/BLU AUDIO OUT LO
XX XX XX XX 37 36

37 36

44

44
CAN BUS HI F7551 22 2 WHT WHT VBUS RED RED USB VBUS POWER
ES-00187 (44 PIN HI-DENSITY MALE)

ES-00019 F7550 2C:22S 38 WHT MFD WHT/ORN GPS RS-232 IN 1

CAN BUS LO F7552 22 2 WHT/BLU WHT/BLU GA 36
ES-00019 TNC TQ-7568 RG-400 34 CABLE TNC WAAS GPS
PFD MAPMX GPS RS-232 OUT 1

8
R7507 3C:22S 35 WHT WHT
ES-00019 ANTENNA

26 46

26 46
WHT/BLU GND SERIAL 1
WHT ES-00019

MFD MAPMX F7599 2C:22S 35 WHT GPS RS-232 IN 2

WH-00136
WHT/BLU
GA 37
GPS RS-232 OUT 2

7
WHT WAAS GPS AND
GTX 35R TQ7540 WHT XM ANTENNA

44 25 18 45

44 25 18 45
WHT/BLU GND SERIAL 2 (OPTIONAL)

LIGHTING BUS SPLITPOINT L7538 22 10 PRP/YEL LIGHTING BUS HI

GPS RS-232 IN 3

WH-00136
TO GARMIN BACKSHELL WHT/BLU GND SERIAL 3/4
J2
PFD CONNEXT GPS RS-232 OUT 4

5
5

R7537 3C:22S 35 WHT WHT

16 31

16 31

PILOT PHONES R WHT/ORN

67 48 29 10 24

67 48 29 10 24
WHT/ORN GPS RS-232 IN 4
PILOT PHONES L WHT RZ7545 3C:22S 70 WHT PILOT HEADSET JACK
WHT GPS AIRINC 429 OUT 1A

31

31
PILOT PHONES LO GAD 29 RS-232 IN 1
1

WHT/BLU R7505 2C:22S 26 WHT WHT/BLU

WHT/BLU GPS AIRINC 429 OUT 1B GSU 25 F7165 WHT
CO-PILOT PHONES R RS-232 OUT 1
4

9
WHT/ORN WHT
WHT GPS AIRINC 429 IN 1A

21 42 50 29

21 42 50 29
CO-PILOT PHONES L CO-PILOT HEADSET JACK GAD 29 RS-232 IN 3
3

WHT RZ7544 3C:22S 70 WHT R7506 2C:22S 26 WHT WHT

WHT/BLU GPS AIRINC 429 IN 1B GTN 650 TQ7540 2C:22S 28 WHT
CO-PILOT PHONES LO RS-232 GND 3
2

WHT/BLU WHT/BLU
28 26 27 25 23 24 29 21 33 34 32 38 37 36 35

28 26 27 25 23 24 29 21 33 34 32 38 37 36 35

PASS MIC HI CONFIG MODULE + HARNESS TQ7106 22 3 RED AIRCRAFT POWER 1

59 58 43 65 64 63 62

59 58 43 65 64 63 62
DATA CONFIG MOD DATA
3

YEL 22 2.5 T7530

PASS MIC LO TQ7104 RED TQ7108 22 3 RED AIRCRAFT POWER 1
CLK CONFIG MOD CLOCK
2

WHT 22 2.5 T7531 ES-00019

PASS 2 MIC HI

ES-00231 (78 PIN HI-DENSITY MALE)

GND CONFIG MOD GROUND POWER MODULE
1

BLK 22 2.5 T7532

38 59

38 59
PASS 2 MIC LO TQ7107 22 3 BLK POWER CONFIG
VCC CONFIG MOD POWER
4

RED 22 2.5 T7533

CO-PILOT MIC HI WHT TQ7105 BLK TQ7109 22 3 BLK POWER CONTROL
BLK 22 2.5 T7534 FAN GROUND ES-00019
CO PILOT MIC LO WHT/BLU RZ7546 3C:22S 70 WHT CO-PILOT HEADSET JACK
FAN YEL 22 2.5 T7535 FAN TACH IN

41 20

41 20
CO-PILOT MIC PTT WHT/ORN GRIP TQ7110 22 3 BLK POWER GROUND
SWITCH
RZ7596 22 36 BRN
W/ BOOT PANEL PTT RED 22 2.5 T7536 FAN POWER
GROUND RZ7597 22 36 BLK TQ7111 22 5 BLK POWER GND
WH-00136

FAILSAFE WARN AUDIO HI

ENT. 1 AUDIO R WHT/ORN

ENT. 1 AUDIO L WHT R7553 3C:22S XX WHT XM MUSIC (GDL 52R)

ENT. 1 AUDIO LO WHT/BLU P1004 (NAV)

P3251
ENT. 2 AUDIO R
62 61 60 52 51 23 24 29 28 17 16

62 61 60 52 51 23 24 29 28 17 16

WHT VOR/ILS AUDIO HI

ENT. 2 AUDIO L GMA 245 R7502 WHT
WHT/BLU VOR/ILS AUDIO LO
ENT. 2 AUDIO LO
VLOC REMOTE XFER
POWER
8

R7512 RED
RAMI AV-532L
POWER MODULE ILS ENERGIZE NAV ANTENNA
WH-00136
10 11

10 11

GROUND R7513 BLK

WHT VOR/ILS AIRINC OUT A
GROUND GAD 29 R7530 WHT
WHT/BLU VOR/ILS AIRINC OUT B INCLUDED WITH, BUT NOT BUNDLED TO HARNESS
14V LIGHTING BUS LO
5

R7575 22 3 BLK BNC RAMI532 BLK 283

ES-00187 (44 PIN HI-DENSITY MALE)

POWER
ES-00192 (62 PIN HI-DENSITY MALE)

14V LIGHTING BUS HI USE GARMIN BACKSHELL

6

POWER MODULE R7529 RED POWER TRIM CABLE TO LENGTH AND CRIMP ON
14V LIGHTING BUS HI LIGHTING BUS SPLIT POINT
7

L7539 22 15 PRP/YEL
ES-00019 POWER MODULE (GROUND LUG) R7517 BLK GROUND BNC CONNECTOR.
GROUND (LENGTH SHOWN IS FROM FARTHEST RING TERMINAL)

GROUND
14401 NE KEIL RD. NE
VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
USE GARMIN BACKSHELL TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 4 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

AUTOPILOT R6 SEE PG 1
PITCH SERVO
GARMIN GSA 28
WHT
GDU 465 (MFD) TRIM MOTOR

ES-00061
F7173 2C:22S 72 WHT

5
WHT/BLU
CAN H

1
F7236 22 2 WHT WHT
ES-00019 F7083 WHT AP ROLL SERVO
CAN L

2
F7237 22 2 WHT/BLU WHT/BLU
ES-00019

CAN TERM 1

3
(PTRIM SERVO POS) GND

1
WHT/ORN ORN 5.5 26
CAN TERM 2

4
PTRIM SERVO POSITION

2
WHT/GRN GRN 5.5 26
ID STRAP 1

5
C7131 22 3 WHT
(TRIM SRVO) 5V EFIS POWER

3
WHT/BLU BLU 5.5 26
POWER

WH-P30-1
ID STRAP 2

6
WH-P30-1 WHT
ES 36154 (#10) MODULE

WH-00136
ID STRAP 3 PTRIM SERVO PWR R

4
7

7
C7232 18 12 BLK WHT WHT 5.5 26

ID STRAP 4 PTRIM SERVO PWR E

5
BLK BLK 5.5 26
ES-00019

ES-205203-3 (FEMALE)
AIRCRAFT GROUND AP ROLL SERVO
9

9
C7132 18 3 BLK C7129 RED

6
15 14 13 12 11 10

15 14 13 12 11 10
AIRCRAFT POWER C7133 18 10 RED C7054 RED

7
ES-00019

ES-00140 (MALE)
TRIM IN 1 C7122 WHT

8
TRIM IN 2 C7123 WHT/BLK POWER MODULE

9
C7233 22 3 GRN
TRIM OUT 1 WHT

5
C7043 WHT
TRIM OUT 2 WHT/BLU
CO-PILOT C7257 22 33 BLU
AP DISCONNECT C7126 22 18 YEL AP DISCONNECT SPLIT POINT CONTROL STICK

TWISTED
L7581 22 7 YEL/GRN

THESE COMPONENTS NOT INCLUDED IN AVIONICS KIT, NOR PART OF THE WH-00136
ES-00019
L7582

C7035
22

YEL
7 YEL/PRP
AP DISCONNECT
AUTOPILOT

AUTOPILOT
L7589 YEL/GRN DISCONNECT
C7584 22 7 GRN
L7590 YEL/PRP
POWER

ROLL SERVO MODULE 1N4003

TWISTED
L7585 22 7 YEL/GRN

GARMIN GSA 28
WHT
AP PITCH SERVO
C7591 GRN
TAKE OFF
ES-00061

F7083 2C:22S 72 WHT L7586 22 7 YEL/PRP

5

WHT/BLU
CAN H GTN 650
GO AROUND
1

F7238 22 2 WHT WHT C7587 22 37 YEL

ES-00019 F7084 2C:22S 27 WHT GSU 25 ADAHRS TO/GA

CAN L
2

F7239 22 2 WHT/BLU WHT/BLU C7588 22 7 GRN

ES-00019

CAN TERM 1 GEA24 (GP2)

3

C7593 22 51 YEL

CAN TERM 2
4

ES-00332
ID STRAP 1
5

ID STRAP 2
6

6
WH-00136

ID STRAP 3/RS-232 OUT 1

7

WHT
C7134 WHT AP MODULE (GMC 307)
ID STRAP 4/RS-232 IN 1
8

WHT/BLU
ES 36154 (#10)
AIRCRAFT GROUND
9

C7086 18 9 BLK
15 14 13 12 11 10

15 14 13 12 11 10

AIRCRAFT POWER C7129 18 72 RED AP PITCH SERVO

TRIM IN 1
TRIM IN 2
TRIM OUT 1
TRIM OUT 2
AP DISCONNECT C7128 22 70 BLU AP DISC. SPLIT POINT

AP MODULE
GMC 307

J3051
5

14 15

14 15
POWER MODULE C7059 22 31 BLK POWER GND
X
DATA BUS POWER GND

5
10 11 12

10 11 12
LIGHTING BUS LO
ADAPTER
L7576 22 3 BLK

MAGNETOMETER LIGHTING BUS

SPLIT POINT
L7047 22 18 PRP/YEL LIGHTING BUS HI
CNTRL UNIT RMTE PWR OFF

WH-00136
GAD 29 AIRINC GMU 11 AIRCRAFT POWER 2

9
ES-205203-3 FEMALE
SIGNAL GROUND

8
5

5
CAN BUS HI

1
WHT WHT
GDU 460 (PFD) J291 GSU 25 (ADAHRS) POWER MODULE AIRCRAFT POWER 1
5

F7547

7
WHT F7167 WHT C7056 RED
CAN BUS LO

2
WHT/BLU WHT/BLU
CAN HI
1

WHT F7558 22 2 WHT

GEA 24 (EMS) F7548 ES-00019
UNIT ID

3
WHT

ES-00326 (15 PIN HI DENSITY MALE)

CAN LO SIGNAL GROUND
2

F7559

6
WHT/BLU 22 2 WHT/BLU C7173 22 3 GRN
ES-00019
RESERVED

4
RS-232 IN 2

4
WHT
WH-00136

WH-00136
RESERVED ROLL SERVO

5
C7134 2C:22S 129 WHT
RS-232 OUT 2

3
WHT/BLU
SIGNAL GROUND

6
F7168 22 3 GRN
RS-232 IN 1

2
WHT
ES-205203-3 (FEMALE 9 PIN)

AIRCRAFT POWER 1 PFD

7
F7155 RED C7174 2C:22S 36 WHT
AIRCRAFT GROUND RS-232 OUT 1

1
6

F7560 22 22 BLK WHT/BLU

POWER MODULE SPLIT POINT 4 AIRCRAFT POWER 2

8
F7157 RED
AIRCRAFT POWER 1
7

F7561 22 22 RED
POWER GROUND

9
F7156 BLK
AIRCRAFT POWER 2
8

SIGNAL GROUND
9

J292
17 12 24 11 23

WHT AIRINC IN 1A
WH-00136

GTN 650 (P1001) R7505 WHT

WHT/BLU AIRINC IN 1B
WHT AIRINC OUT 1A
GTN 650 (P1001) USE SUPPLIED CAN
ES-205208-1 (MALE 25 PIN)

R7506 WHT
WHT/BLU AIRINC OUT 1B TERMINATOR
WHT AIRINC IN 3A
GTN 650 (P1004) R7530 2C:22S 24 WHT
AIRINC IN 3B
5

WHT/BLU
20

F7557 22 3 GRN GROUND

14401 NE KEIL RD. NE
VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 5 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

R6 SEE PG 1

POWER OUTLET SPLIT POINT 5

USB DUAL PANEL JACK
TP7064 RED
SPLIT POINT 1
ELT
TP7065 BLK
POWER P6057 RED
MODULE ES 421-0108
ES 36154 (#10)
SPAR PIN SWITCH LEFT
ES-00019
C6286 WHT 8 16 F7061 RED TQ7067 RED
ES 421-0108 POWER MODULE ES-00019 ADS-B IN (GDL 50R)
F7060 BLK TQ7066 BLK
EMS W7069 BRN/BLU

SPAR PIN SWITCH JUMPER WIRE

W6075 22 204 BRN/BLU SPAR PIN SWITCH RIGHT

C6286
LIGHTING BUS
BLK FLAP MOTOR

GA 37 XM ANTENNA
SPLIT
7
18

ANTENNA
FLAP
GDU 465 (MFD) L7045 PRP/YEL

ADS-B
SWITCH
C6287 BLK 3 18
6X ES 421-0108
GMA 245 L7539 PRP/YEL
2 4 ES-00019
GMC 307 (AP MODULE) L7047 PRP/YEL L7044 PRP/YEL POWER MODULE
SPLIT POINT 4

TNC
C C
POWER C6235 RED 1 3 GTN 650 L7538 PRP/YEL

BNC
MODULE MOM

INCLUDED WITH, BUT NOT BUNDLED TO HARNESS

K2AGPAAAAA
GDU 460 (PFD) L7048 PRP/YEL
ES-00019

CABLE

CABLE
C6288 RED 3 18 F7079 RED F7155 18 70 RED
POWER MODULE ES-00019
F7080 BLK F7156 18 70 BLK GMU 11 MAGNETOMETER

135
32
BACKUP BATTERY P7154 RED F7157 18 70 RED

RG-400

RG-400
BLK 23 18 FLAP PWR - F7158 18 10 RED

RED 23 18 FLAP PWR + AUTOPILOT DISC. F7159 18 10 BLK GSU 25 ADAHRS

(FLAP POS) GND
SPLIT POINT
BLU BLU 23 18 F7160 18 10 RED

WH-00137

TQ7243
ES 421-0108 ES 421-0107
EMS C7145 WHT ORN YEL 23 18 FLAP POSITION
ES 421-0108 ES 421-0107
WHT WHT 23 18 (FLAP POS) 5V EFIS POWER C7128 BLU AP ROLL SERVO
ES 421-0108 ES 421-0107 ES-00019

FLAP POSITION SENSOR POWER MODULE C7247 BLU C7127 BLU PILOT CONTROL STICK

BNC

TNC
ES-FA-PO-150-12-2
FLAP MOTOR
C7126 BLU AP PITCH SERVO

ADS-B IN GDL 5XR

ADAHRS
P252

GSU 25
5
14

14

GROUND

5
F7161 22 3 GRN

10

10
12V MAGNETOMETER POWER AIRCRAFT POWER
6

TQ7067 22 32 RED

MAGNETOMETER GROUND EFIS BATTERY SWITCH SPLITPOINT 5

GROUND
7

9
TQ7066 22 32 BLK
OTTO K1AABAAAAA

WH-00136
13 12 15

13 12 15

RS-232 OUT 2

12 14 13 15

12 14 13 15
MASTER RELAY P7250 22 30 BLK 2 4 WHT/ORN MUSIC OUT RIGHT
RS-485 A EFIS BATTERY P7223 WHT C
GMA 245 WHT R7553 WHT MUSIC OUT LEFT
WH-00136

RS-485 B AIRFRAME GROUND P7251 22 14 BLK 1 3

ES 36154 (#10) WHT/BLU STEREO AUDIO OUT LO
OAT PROBE (GTP 59)

ES-00061 (FEMALE)
OAT POWER
1

GRMN WHT
R7579 22 3 GRN SIGNAL GROUND
OAT HIGH
2

GRMN WHT/BLU GRMN 3C:22S 78 WHT

ES-421-0108 TX B (DATA OUT)

5
WHT/BLU
OAT LOW 3 PLACES MFD (ADS-B/XM WEATHER RS232 DATA)
3

GRMN WHT/ORN TQ7580 2C:22S 140 WHT

RX B (DATA IN)

6
WHT
RS-232 OUT 3
9

WHT/BLU
ES-00061

XPNDR TX A (DATA OUT)

7
F7165 2C:22S 120 WHT WHT/BLU
10

10

RS-232 IN 3 WHT PFD (ADS-B/XM WEATHER RS232 DATA) TQ7169 2C:22S 140 WHT
RX A (DATA IN)

8
WHT
P251

AIRCRAFT POWER 1
7

F7158 RED

POWER GROUND SPLIT POINT 4

6

F7159 BLK

AIRCRAFT POWER 2
8

F7160 RED

POWER GROUND
9

9
WH-00136

RS-232 OUT 1
5

WHT/BLU
MFD
ELT REMOTE RS-232 IN 1
F7508 WHT

912iS MAINT
4

WHT

CAN BUS HI
1

F7234 22 2 WHT WHT

PORT
ES-205203-3

ES-00019 F7084 WHT AP ROLL SERVO

CAN BUS LO
2

F7235 22 2 WHT/BLU WHT/BLU

ES-00019 WHT
AV-00013 F7167 2C:22S 81 WHT GMU 11 (MAGNETOMETER)
E-04.5

9 PIN FEMALE W/ CLINCH NUTS

WHT/BLU

ES-00324
5

1
2
WHT/BLU

CABIN LIGHT & DIMMER

F7172

3
4
PHONE CABLE

WH-00144 HIC CONNECTOR

5
E6023 2C:22S 23 WHT
(ES-00338 & LC ECL-02)
RED MODULE
SPAR PIN

6 WH-00133
LUG REMOVED

POWER MODULE

7
L6028 YEL/PRP L7610 22 2 RED WHT
108

GPS RX SWITCHES ES-00141 ES-00338

8
BLK
ES-00141

9
ELT

L7611
INSTALLED
RIGHT LC ECL-02
ES DV18-188-M BY

22
SPLIT POINT 1 W6075 BRN/BLU BUILDER OPTIONAL KIT INSTALLED BY BUILDER. NOT INCLUDED
ES E22-50K
IN AVIONICS KIT, NOR PART OF THE WH-00136

6
F6262 22 4 BLK
ES 31880 (#4)
ES DV18-188-M

BLK
14401 NE KEIL RD. NE
CANOPY SWITCH
INCLUDED WITH, BUT NOT BUNDLED TO HARNESS
AV-E-04

PWR VAN'S AIRCRAFT, INC. AURORA, OR

1

1 TP7064 22 10 RED
97002 USA
INCLUDED WITH, BUT NOT BUNDLED TO HARNESS INCLUDED WITH, BUT NOT BUNDLED TO HARNESS
TEST TX SPLIT POINT 5 ES 31880 (#4)
2

1 TP7598 22 5 WHT
ES 31890 (#8) ES DV18-188-M
1 2
E-04.7 Q6300 22 27 BLK FUEL TANK SENDER GROUND
GND
F6035 22 3 BLK ES E22-50K
ROTAX 912iS G3X NAVCOM
3

1 TP7065 22 10 BLK W7069 BRN/BLU

4 3
ES E22-50K EMS F7139 22 175 WHT
SPLIT POINT 1 ES DV18-188-M

GPS RX PFD (ELT RS-232 OUT)

W6075 BRN/BLU
ES DV18-188-M
ELECTRICAL SYSTEM
4

1 TP7171 22S 118 WHT

DATE DRAWN: 04/06/2018
ELT DIN PLUG LEFT INSTALLED BY
BUILDER CANOPY LATCH
MICRO DRAWN BY: T. DE MAN
INCHES WH-00136
SWITCH TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 6 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

R6 SEE PG 1

EMS

16 11 23 13 25
GEA 24 EGT 1 HI
LEFT
EGT 1 LO
EGT 2 HI
RIGHT
EGT 2 LO
CHT 1 +
LEFT
CHT 1 -

4
14
CHT 2 +
RIGHT
CHT 2 -

P244
5K OHM

5
.25W 1%
Metal-Film
28 40 41 42 43 19 17 33 22 50

28 40 41 42 43 19 17 33 22 50
GP +12V E7594 22 8 WHT

GP2 (TO/GA) E7595 22 8 YEL C7593 YEL TO/GA BUTTON

CAN 2 LO (ROTAX FADEC) WHT/BLU
E7013 WHT HIC CONNECTOR MODULE
CAN 2 HI (ROTAX FADEC) WHT

POS 1 C7249 ORN POWER MODULE (PTRIM SERVO POS)

1N4003
DISCRETE 4 (EARTH X ERROR) W7144 WHT EARTH X FAULT
DISCRETE 3 (CANOPY LATCH) F7139 WHT CANOPY LATCH W7070 22 22 BRN/BLU IGNITION MODULE
WH-00136

1N4003
DISCRETE 2 SPAR PINS) W7068 22 7 BRN/BLU W7069 22 114 BRN/BLU SPLIT POINT 1 (LEFT SPAR PIN SWITCH)
DISCRETE 1 (STALL) W7114 BRN/YEL
1N4003
POWER MODULE FUEL SENDER
VOLTAGE 2 E7141 22 27 WHT BACKUP BATT (BATT INFO)
ES 36154 (#10)
CO DETECTOR
FUEL LEVEL 1 FUEL SENDER EMS
6

Q7142 22 137 BRN/ORN Q7142 ORN/BRN

ES-00019 OR
ES-00141 D7602 22 3 GRN D7601 & D7605
AITHRE SHIELD EX CO DETECTOR

ES-00140 (MALE)
25 11 12 15 31 32

25 11 12 15 31 32

POS 5 LO / GP 5 / GND D7603 22 3 BLK WHT/BLU BUNDLED WITH EMS WHT/RED 1 1 RED 5V POWER
SPAR PIN SWITCH Q6300 BLK IE F-385B SENSOR WIRING
POS 5 / GP 5 (O2 PRESSURE) WHT/GRN ES 421-0108 FUEL SENDER WHT 2 2 WHT CO SIGNAL OUT
RANGE
POS 4 / GP 4 (SPO2) WHT/ORN D7601 5C:22S 15 WHT CO DETECTOR 250 OHM - 40 OHM EMS D7601 WHT WHT/ORN 3 3 BLU SPO2 SIGNAL OUT (EX 3.0)

ES-00321 (FEMALE WITH CLINCH NUTS)

POS 3 / GP 3 (CO DETECTOR) WHT WHT/GRN 4 4 YEL O2 PRESSURE SIGNAL OUT (EX 3.0)

POS 3 HI / +5V WHT/RED WHT/BLU D7604 22 3 BLK 5 5 BLK GROUND

ES-00059

ES-00019 OR
(MAIN BATTERY) VOLTAGE 1 E7052 22 7 PRP ES 31890 (#8) ES-00141 6 6
D7605 22 3 BLK
7 7
8 8
9 9
P243

OPTIONAL KIT INSTALLED BY BUILDER. NOT INCLUDED

5

ES-00019 IN AVIONICS KIT, NOR PART OF THE WH-00136

35 34 37 36

35 34 37 36

SHUNT 1 LO E7051 22 7 PRP E7050 22 32 PRP

POWER MODULE (ALTERNATOR AMPS)
SHUNT 1 HI E7049 22 39 GRN

SHUNT 2 (BATTERY) LO E7252 22 39 PRP

POWER MODULE (BATTERY AMPS)
SHUNT 2 (BATTERY) HI E7253 22 39 GRN

FUEL PRESSURE
3

SENSOR Fuel Pressure

23

23

PACKARD Kavlico P500-75A-E4C

12065287 1/8-27 NPT
WH-00136

FUEL PRESSURE GROUND

1

BLU BLU KVLCO 3 BLK

ES-00019 75 PSI ABSOLUTE
FUEL PRESSURE FUEL PRESSURE SENSOR EMS
2

ORN Q7143 3C:22 132 WHT Q7143 WHT ORN KVLCO 3 GRN
ES-00019
ES-00019
FUEL PRESSURE POWER 5V
4

P7120 22 3 WHT WHT WHT KVLCO 3 RED

ES-00019
29 28 32 15

29 28 32 15

MANIFOLD PRESSURE PWR 5V P7119 22 3 WHT C7248 WHT POWER MODULE

GP 7 LO BLU
ES-00057

FLAP POSITION SENSOR

GP 7 HI ORN C7145 3C:22 58 WHT
(FLAP MOTOR)
WHT
P241

AIRCRAFT POWER 2 BACKUP BATTERY

8

P7146 RED

AIRCRAFT POWER 1 POWER MODULE

7

E7077 RED
WH-00136

POWER GROUND POWER MODULE

6

E7078 BLK

POWER GROUND
9

9
ES-205203-3

CAN BUS HI
1

F7148 22 2 WHT WHT

ES-00019 F7548 2C:22S 24 WHT GAD 29
CAN BUS LO
2

F7149 22 2 WHT/BLU WHT/BLU

ES-00019 WHT
F7549 2C:22S 36 WHT GMA 245
WHT/BLU

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 7 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS

POWER MODULE iS-ULS PCB V3.4 REV DESCRIPTION DATE APPROVED

R6 SEE PG 1

4X SCREW TERMINALS
ES-00169
ES-35107 (#6) R07

I OUT
STARTER SOLENOID K7125 WHT BATTERY SHUNT

I IN
30 4X ES-00191

47 46 37 38

47 46 37 38
AMPS A AMPS B

SCREW TERMINAL 1A 5 BATT AMPS BUS E7253 GRN

BACKUP BATTERY P7227 RED
Keystone 8197-2 RED 1A EMS
5 BATT AMPS BAT E7252 PRP
1A
5 GEN AMPS BUS E7049 GRN
1A EMS
5 GEN AMPS ENGINE E7050 PRP
ES-35107 (#6)
AMPS A AMPS B

GENERATOR (X3 PIN 3 )

I OUT
FUSE BOX K7124 10 60 WHT SHUNT

I IN
30

SCREW TERMINAL ES-00169

35

35
R06 5 POWER OUTLET P6057 18 45 RED POWER OUTLET

BACKUP POWER

LANDING LIGHT
Keystone 8197-5 BLUE

NAV & STROBE

START / TRIM

PWR OUTLET
GENERATOR
22,000 µF

AUTO PILOT

GPS / ADSB
NAV / COM
+
25V

FLAP

COM
EFIS
7.5A

7.5A

7.5A

7.5A

ELT
30A

30A

10A
5A

5A

5A

3A

3A
(912ULS ONLY)

34

34
5 AUTOPILOT C7054 18 73 RED AP PITCH SERVO
R7515 18 26 BLK ES-35107 (#6)
GTN 650 GROUNDS R7516 18 29 BLK

40

40
R7517 18 28 BLK 5 FLAPS C6235 18 45 RED FLAP MOTOR
AIRCRAFT GND 30
320568 ES-35107 (#6)
SCREW TERMINAL

20 36

20 36
FIREWALL AIRFRAME GROUND K7562 10 18 WHT
Keystone 8197-3 BLACK
5 TRIM C7056 22 38 RED
ES-00019 AP MODULE
K1ABBPCADA K2ABN(PP)CCFA
5 GND C7057 18 7 BLK C7059 BLK
SPST K2ABN(PP)CCFA DPDT
F7060 22 80 BLK
DPDT
SPLIT POINT 5

41

41
GPS/ADSB/ELT
BACKUP
ES-35107 (#6) AVIONICS NAV & STROBE LANDING/PULSE 5 F7058 18 7 RED F7061 22 80 RED
SWITCH SWITCH SWITCH
K7126 12 6 WHT EMS BACKUP BATT POWER 30 ES-00019
BACKUP BATT SWITCH SCREW TERMINAL
2 4 2 4 2 4
K7572 22 6 WHT/RED ES-00019

BATTERY
Keystone 8197-7 YELLOW C C C C C

19 45

19 45
7 7 5 EFIS (PFD) F7073 18 7 RED F7075 18 42 RED F7560 22 30 BLK
1 3 1 3 1 3 ES-00019 PFD GAD 29
5 GND F7074 18 7 BLK F7076 18 42 BLK F7561 22 30 RED

E7077 18 42 RED SWITCH

18 44

18 44
5 EFIS (MFD) F7087 18 45 RED GEA 24 (EMS)
MFD E7078 18 42 BLK
5 GND F7088 18 45 BLK
F7079 18 90 RED COVER EXPOSED CONTACTS
SPLIT POINT 4 WITH HEATSHRINK
LANDING LIGHT PULSE LEFT

3
5 L7089 YEL F7080 18 90 BLK
(7 PLACES)
LEFT WING
LANDING LIGHT LEFT

5
5 L7090 YEL/BLU
BACKUP
TRIM, STALL WARNING, DIMMER, CO DETECTOR ARDUINO VOLTAGE BATTERY SWITCH
K2AAJNEADA
REGULATION DPST

POWER MODULE ES-MFR-25-1-1K

11

11
5 LNDING LIGHT PULSE RIGHT L7091 YEL K7572 5
ARDUINO NANO RIGHT WING YELLOW TERMINAL
WHT/RED
1K OHM 640905-1
KA7808ERTM .25W 1%
ATMEGA328P LANDING LIGHT RIGHT

9
5 L7092 YEL/BLU
8V Metal-Film

MICRO-CONTROLLER +12V INPUT

V IN V OUT +8V REGULATED

12

12
POWER

GND
POWER
5 NAV L7093 18 72 YEL/RED LEFT WING JUMPER WIRE K7573 22 4 WHT/RED 5
5V - 16MHz 640905-1

13

13
5 NAV L7094 18 55 YEL/RED RIGHT WING 4X AMP

50 PIN POWER MODULE

640907-1
POWER MODULE 8
K7126 WHT EMS BACKUP BATT POWER 20 4 2
YELLOW TERMINAL

15

15
5 STROBE L7095 18 72 WHT/YEL LEFT WING C C

K7028 WHT BACKUP POWER (X3 PIN 1 ) 20 3 1

7

14

14
5 STROBE L7096 18 55 WHT/YEL RIGHT WING
FUSE BOX
K6282 WHT FUSE BOX REG A GND 20

32 16

32 16
5 COM (GTR200) R7509 RED K6283 WHT FUSE BOX AIRCRAFT GND 20
GTN 650 COM
5 COM (AUDIO POWER) R7510 RED

WH-00136
IC07 POWER MODULE L7029 YEL/GRN COCKPIT LTS PWM - 5
N-CNL 10K OHM
GND

1
VDD FLT MOSFET
5 TQ7105 18 27 BLK AMP
D R09
G XPNDR 640903-1
BRK CS
ARDUINO PTRIM -
1

C7122 22 72 WHT 5
S

17

17
PITCH AP SERVO (TRIM IN) SLP
POLOLU
VMM 5 COM (XPNDR) TQ7104 18 27 RED
ARDUINO PTRIM + GMA 245
2

C7123 22 72 WHT/BLK 5 10K OHM

DRV8801 R08
DIR OUT+ GND

2
5 R7513 18 32 BLK R7512 18 30 RED
9 PIN FLAPS

X
3

5 ES-00019
S CO-PILOT HEADSET JACKS (ONLY CONNECT IF

33

33
PWM OUT- IC05 5 COM (AUDIO POWER) R7511 18 2 RED R7112 22 54 ORN/BLK
P-CNL THE OPTIONAL LEMO HEADSET JACKS ARE INSTALLED)
AP MODULE PTRIM -
9

WHT 5 G MOSFET
WH-P30-1

GND GND D PILOT HEADSET JACKS (ONLY CONNECT IF THE

AP MODULE PTRIM+
6

WHT/BLK 5 R7113 22 71 ORN/BLK

OPTIONAL LEMO HEADSET JACKS ARE INSTALLED)
IC02
TRIM MOTOR X
4

C7121 5C:22 235 WHT 5

48 49

48 49
5 COM (NAV) R7528 18 29 RED
GND GTN 650 NAV
5

WHT/ORN 5
5 COM (NAV) R7529 18 28 RED
ES-00140 (MALE)

PSERVO POS
8

WHT/GRN 5

5V EFIS EMS POWER LEFT WING CONNECTOR

7

WHT/BLU 5 1N4148 W7205 22 65 BRN/YEL

ES-00032
5

ES-00019

22 39

22 39
5 STALL WARN SWITCH W7206 22 3 BRN/YEL W7114 22 39 BRN/YEL EMS
D13 D12 D1
5 STALL WARN AUDIO W7542 22S 33 WHT GMA 245
BUILDER POPULATES THESE PINS 3V3 D11~ R01

D10~ 10K OHM

REF

31 30

31 30
R02 5 CO-PILOT P-TRIM IN DOWN C7115 22 60 RED
A0 D9~ CO-PILOT CONTROL STICK
10K OHM 5 CO-PILOT P-TRIM IN UP C7116 22 60 GRN
A1 D8 R03

10K OHM
A2 D7

42 43

42 43
5 PILOT P-TRIM IN DOWN C7117 22 60 RED
A3 D6~ PILOT CONTROL STICK
5 PILOT P-TRIM IN UP C7118 22 60 GRN
A4 D5~ C7247 22 48 BLU AP DISCONNECT SPLIT POINT
A5 D4 R05

23

23
5 AP DCONN SWITCH C7042 22 7 YEL C7035 22 25 YEL
D3~ 5K OHM ES-00019
A6
AP DCONN SWITCH GND

7
5 C7591 22 25 GRN
A7 D2 ES-00019 AP DISCONNECT

29

29

TWISTED
5 COCKPIT LIGHTS + L7041 22 2 YEL/PRP L7590 22 23 YEL/PRP
5V GND ES-00019
COCKPIT LIGHTS PWM -

4
5 L7040 22 2 YEL/GRN L7589 22 23 YEL/GRN
RST RST
IC03
N-CNL
GND RX0 MOSFET
L6028 22 146 YEL/PRP CABIN LIGHT
D
G
VIN TX1
S
L7029 22 9 YEL/GRN BACKUP BATTERY SWITCH

IC04
L7030 22 42 YEL/GRN IGNITION MODULE

21

21
IC01 P-CHNL
5 FUSED START POWER K7228 22 3 ORN K7072 22 32 ORN HIC CONNECTOR MODULE
MOSFET
S
ES-00019 LEFT/RIGHT CPU FANS
LED PWM +PWR FUEL PUMP SWITCHES

6
5 L7019 22 9 PRP/GRN K6297 22 37 ORN
K6298 22 37 ORN
G
3 D 2X ES SA-1017
TRIM SPEED POT 10 K OHM
FEMALE D-SUB CONTACT
1K OHM

25

25
2 Bourns Inc. 3386F-1-102TLF R04
5 DIM REF LVL L7044 22 17 PRP/YEL LIGHTING BUS SPLITPOINT
1
.22 µF
DIM POTENTIOMETER LEG

8
VR01 C01 5 L7039 22 12 WHT
3
DIMMER POT

5K OHM
26 24

26 24
5 DIM POTENTIOMETER WIPER L7038 22 12 WHT
2 ES-00195
1
5 DIM POTENTIOMETER LEG L7037 22 12 WHT

50 10

50 10
5 AP MODULE PTRIM - WHT
PITCH AP SERVO
C7043 2C:22S 71 WHT
(TRIM OUTPUTS) 14401 NE KEIL RD. NE
5 AP MODULE PTRIM + WHT/BLU

VAN'S AIRCRAFT, INC. AURORA, OR

97002 USA

ROTAX 912iS G3X NAVCOM

27 28

27 28
5 5V EFIS EMS POWER C7248 22 39 WHT
EMS

ES-00059 (FEMALE)
5 PSERVO POS C7249 22 39 ORN

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018

5
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 8 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS

HIC CONNECTOR MODULE iS PCB REV DESCRIPTION DATE APPROVED

R6 SEE PG 1
ES-60009

MOLEX MEGA-FIT 171692-0108 - ES60012

14-16 AWG WIRE: MOLEX MEGA-FIT 1720630311
IC03 12 AWG WIRE: MOLEX MEGA-FIT 1720630312
USE MOLEX 2001220008 BACKSHELL
N-CNL
MOSFET
S

G
D IC01
P-CNL
MOSFET S
G

10K OHM
R2

ES-60012

23
D
20 START POWER POS 2 1 K7023 12 50 WHT EMS FUSE BOX X3 CONNECTOR PIN 2

IC02
N-CNL
20 START POWER POS 1 2 K7022 12 50 WHT EMS FUSE BOX X3 CONNECTOR PIN 3 FUEL PUMP SWITCHES
MOSFET
S 20 START POWER GND 3 3 K6257 12 38 WHT EMS FUSE BOX REG A GND FUEL PUMP 1 FUEL PUMP 2

10K OHM
SWITCH SWITCH
R1
G 20 START POWER GND 4 4 K6256 12 38 WHT EMS FUSE BOX AIRFRAME GND

WH-00134
D

4 2 4 2
640907-1
F7014 WHT 10 C C
10 SIG FUEL PUMP 1 5 F7014 14 32 WHT 3 1 3 1
FUEL PUMP 1 SWITCH 640903-1
10 GND FUEL PUMP 1 6 F7015 14 32 WHT L7018 22 4 WHT 5

HIC CONNECTOR 640907-1

10 SIG FUEL PUMP 2 7 F7016 14 32 WHT

1N4148
F7015 WHT 10
HIC CONNECTOR A FUEL PUMP 2 SWITCH MODULE
19428-0015 OR 19428-0031 10 GND FUEL PUMP 2 8 F7017 14 32 WHT 640907-1
ES-60013

F7016 WHT 10
1 LANE SEL SW A 1 18

640905-1
2 SUPP WARN LAMP A 18 L7258 22 4 WHT 5
640907-1
3 SIG FUEL PUMP 1 18 F7017 WHT 10

4 CAN GND 1 A 18
640903-1
POWER MODULE L7019 PRP/GRN 5
5 CAN LO 1 A CAN LO 912IS EMS

2
18 5 WHT/BLU
E7013 2C:22S 33 WHT GEA 24 (EMS) LED PWM +PWR
640903-1
WH-00124

6 CAN HI 1 A CAN HI 912IS EMS

1
18 5 WHT L7020 22 4 PRP/GRN 5

7 LANE SEL SW A 2 18

8 WARN LAMP A 18

9 GND FUEL PUMP 1 18

10 CAN GND 2 A 18

15 14
11 CAN LO 2 A 18 5 CAN LO 912IS MAINT WHT
E6023 WHT 912iS MAINT PORT
12 CAN HI 2 A 18 5 CAN HI 912IS MAINT WHT/BLU

HIC CONNECTOR B
19428-0016 OR 19428-0032
ES-60014

11 10
1 LANE SEL SW B 1 18 5 GND E7241 22 3 GRN

2 SUPP WARN LAMP B 18 5 GND

3 SIG FUEL PUMP 2 GND

5
18 5

4 CONN STARTER RELAY SW 18

5 X 18
FUSED START POWER POWER MODULE

6
5 K7072 ORN
6 CAN GND 1 B 18

WH-00136
7 CAN LO 1 B 18
WH-00124

FUSED START POWER

7
5 K7574 ORN
8 CAN HI 1 B 18

13
5 CONN STARTER RELAY SW K7011 22 35 WHT/RED
9 LANE SEL SW B 2 18
START BUTTON BYPASS

3
5 K7010 22 35 GRN/RED
10 WARN LAMP B 18

12
5 SUPP START SWITCH K7009 22 35 RED
11 GND FUEL PUMP 2 18
GND

4
5 K7008 22 35 BLK
12 SUPP START SWITCH 18

18 19 16 17 24 25 22 23
5 LANE SEL SW B 1 K7000 22 35 WHT
13 X 18
5 LANE SEL SW B 1 K7000 22 35 WHT
14 CAN GND 2 B 18
5 LANE SEL SW B 2 K7001 22 35 WHT/BLK
15 CAN LO 2 B 18
5 LANE SEL SW B 2 K7001 22 35 WHT/BLK
16 CAN HI 2 B 18 IGNITION MODULE
5 LANE SEL SW A 1 K7002 22 35 YEL

5 LANE SEL SW A 1 K7002 22 35 YEL

5 LANE SEL SW A 2 K7003 22 35 WHT/YEL

5 LANE SEL SW A 2 K7003 22 35 WHT/YEL

SUPP WARN LAMP B

9
5 K7004 22 35 BLU

21
5 WARN LAMP B K7005 22 35 WHT/BLU

SUPP WARN LAMP A

8
5 K7006 22 35 GRN

20
5 WARN LAMP A K7007 22 35 WHT/GRN

ES-205208-1 (MALE)

5
14401 NE KEIL RD. NE
VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 9 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

R6 SEE PG 1

AV-60002 (ROTAX 912iS)

IGNITION & START MODULE
PCB ES-60007-V3.1

LANE A LANE B
SWITCH SWITCH
K1ABBPCADA K1ABBPCADA
SPST SPST

2 4 2 4

C C

ARDUINO VOLTAGE 1 3 1 3

REGULATION LANE SEL SW B 1

1
5 K7000 WHT

22 21 18 17 16 15 14
KA7808ERTM
MASTER
5 LANE SEL SW B 1 K7000 WHT
+8V REGULATED 8V +12V INPUT SWITCH
POWER POWER

V OUT V IN
K2ABHPCABA
DPST
5 LANE SEL SW B 2 K7001 WHT/BLK

GND 5 LANE SEL SW B 2 K7001 WHT/BLK

C C
7 5 LANE SEL SW A 1 K7002 YEL
1 3
5 LANE SEL SW A 1 K7002 YEL

5 LANE SEL SW A 2 K7003 WHT/YEL

5 LANE SEL SW A 2 K7003 WHT/YEL

D13 D12

3V3 D11~

REF D10~
10K

R4

A0 D9~
LANE B
WARN LAMP B HIC CONNECTOR MODULE

5
A1 D8 WARN LAMP 5 K7005 WHT/BLU
LANE A
A2 D7 WARN LAMP 1K OHM
R5
5K

SUPP WARN LAMP B

4
A3~ D6 5 K7004 BLU
A4 D5
R2

SUPP WARN LAMP A

6
A5~ D4
1K OHM 5 K7006 GRN
A6~ D3

10K

R3
R1

19
A7 D2 5 WARN LAMP A K7007 WHT/GRN
5V GND

RST RST

GND RX0

12 20 23 11 24
VIN TX1 5 MASTER RELAY K7021 22 31 WHT/ORN MASTER RELAY

WH-00134
IC01
ARDUINO NANO SPAR PIN
5 GND
WARNING LIGHT
OVERRIDE BUTTON
LP3F1G121R
5 GND K7008 BLK

5 CONN STARTER RELAY SW K7011 WHT/RED

10K

R7

DPDT 5A 5 SUPP START SWITCH K7009 RED

RELAY
V23079A1003B301 HIC CONNECTOR MODULE
START BUTTON BYPASS

8
5 K7010 GRN/RED
R6
5K

N.O.
1
2
C 5 X
8 - N.C. +
KEY MOM
START SWITCH
JD 7510A

25
5 FUSED START POWER K7574 22 32 ORN HIC CONNECTOR MODULE
1N4148
ES-00032
COCKPIT LIGHTS PWM - POWER MODULE

3
5 L7030 YEL/GRN

13
5 SPAR PINS W7070 BRN/BLU EMS
X

7
5

ES-00060 (FEMALE)
X

9
5

10
5 X

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 10 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL
 REVISIONS
REV DESCRIPTION DATE APPROVED

R6 SEE PG 1

CYL 2 CYL 1

CYL 4 CYL 3

GENERATOR STARTER
K7028 12 60 WHT BACKUP BATTERY SWITCH ES 324082 (1/4) ES 324082 (1/4)
P151 8 10

P155
ES 324043 (#10)
K7023 WHT

8
HIC CONNECTOR MODULE

8.5
K7022 WHT
3X ES 324082 (1/4)

K7124 WHT POWER MODULE

1 2 3 POWER MODULE K7125 10 44 WHT

ROTAX
POWER X3 STARTER
POWER X1 POWER X2 FUSE BOX CONNECTOR SOLENOID

P154
LANE A LANE B 206037-2 MASTER
RELAY

8
ES 24115

7.5
ES 324044 (5/16) ES 324044 (5/16)
ES 324082 (1/4)

ES 36154 (#10)
P150 8 10

(CONNECTOR PROVIDED BY ROTAX)

GENERATOR B RING TERM #10 (10-12 AWG)

ES DIODE
ES-35109
BRAKE RES. MASTER
GENERATOR A K6284 12 20 WHT
MOUNT SCREW
K7021 WHT/ORN IGNITION MODULE
ES-35110 (1/4)
ES ETX900
EARTH-X BATTERY P7250 WHT EFIS BATTERY SWITCH
BACKUP BATTERY SWITCH K6282 12 48 WHT K6283 12 48 WHT BACKUP BATTERY SWITCH
ES-35108 (#8) ES-35110 (1/4)
ROTAX 912iS FUSE BOX ES 421-0108 ES 421-0107
HIC CONNECTOR MODULE K6257 WHT K6256 WHT HIC CONNECTOR MODULE
ES-35108 (#8) ES-35110 (1/4) W7144 WHT EMS

P149 8 5.5

ES 324043 (#10)
ES 324082 (1/4)

FUEL PUMP POWER

FUEL
PUMP 2
FUEL PUMP 2 (AUXILIARY)
Q7564 14 105 WHT

Q7565 14 105 WHT

TWISTED PAIR (2 PLACES)

Power Wire: A
Ground Wire: B
FUEL PUMP 1 Q7566 14 105 WHT

Q7567 14 105 WHT

DELPHI ASSEM: FUEL DELPHI ASSEM

1X 15339016 (HOUSING) PUMP 1 1x 12162017 (HOUSING)
2X 15344866 (CONTACTS) (MAIN) 2x 12048086 (SEAL)
2X 15324973 (SEALS) 2x 12048074 (CONTACTS)

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X NAVCOM

ELECTRICAL SYSTEM
DATE DRAWN: 04/06/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00136
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 11 OF 11

PATH\FILENAME: Q:\RV-12\Systems iS\Electrical System iS\Electrical System 912iS NavCom (WH-00136).DWG C-SIZE ORIGINAL