Plastic Waste Management 78
Plastic Waste Management 78
MANAGMENT
2 3 01 8 3 1 1 9 0 2 2 01 8 01 1 9 0 01 2 3 01 8 3 1 1 9 0
01 MUSTAFA 03
DEV Leader ASHWIN
Member Member
2
OUTLINES
PLASTIC WASTE
MANAGEMENT
INTRODUCTIO
N
PROJECT VISIT
1
PROJECT VISIT
2
3
PRESENTATION TITLE
INTRODUCTION
4
REALITY OF PLASTIC
PLASTIC POLLUTION
Over the last ten years we have produced more plastic than
during the whole of the last century.
50 percent of the plastic we use, we use just once and throw it away.
Enough plastic is thrown away each year to circle the earth
four times
Plastic constitutes approximately 90 percent of all trash floating on
the ocean’s surface
It takes 500-1,000 years for plastic to degrade.
Plastic chemicals can be absorbed by the body
Nearly every piece of plastic EVER made still exists today.
PROCESS RECOVERY
TYPICAL INPUT OUTPUT RATIO
TCD PROCESS
Pre Process
Fuel yield
TCD process around
65%
PROJECT VISIT-1
DAT 12-03-
E 24
NAGAR PALIKA
LOCATION DAHOD
Sr.
VISITED TO
khaped
DR WE
Y T
22TDP 38TDP
(PLASTIC BOOTELS & PAPER (FOOD WASTE & WET GARBAGE
ETC.) ETC.)
8
• {Where TPD stands for tones per day}
• After confronting with the Nagar Palika officers , we
PLASTIC WASTE
MANAGEMENT
9
PROJECT VISIT-2
PLASTIC WASTE
MANAGEMENT
DAT 15-03-
E 2024
10
PLASTIC WASTE
MANAGEMENT
1
2
THETRUCKFILLED WITH RDF IS MEASURED ON WEI
GHING SCALE
PLASTIC WASTE
MANAGEMENT
1
3
THE RDF IS UNLOADED TO THE DESIRED
SPACES
PLASTIC WASTE
MANAGEMENT
1
4
BY THE HELP OF HUMAN L ABOUR THE HDP & LDP ARE
SEPARATED FROM THE RDF AND SOLD DIRECTLY TO LOCAL
PLASTIC WASTE
MANAGEMENT
DEALERS.
1
5
THE REMAINING GARBAGE IS LOADED TO SEPARATOR
MACHINES WHICH SEPARATE THE RDF INTO THREE
PLASTIC WASTE
MANAGEMENT
1
6
[ 30 MM GARBAGE SEPARATOR MACHINE]
PLASTIC WASTE
MANAGEMENT
1
7
[ 6 MM GARBAGE SEPARATOR MACHINE]
PLASTIC WASTE
MANAGEMENT
1
8
• 100mm garbage separator:-
After the separation of 100mm garbage it is again being inspected. And the remaining plastic is
PLASTIC WASTE
MANAGEMENT
The 100mm garbage which contains RDF is also sold to cement industry like JK SUPER and L&T.
The remaining garbage is processed in 30mm separator. The garbage of 30mm is sold to paint
industry for run there boilers.
The contain of plastic in this separation is almost 0 so the organic garbage is processed in crusher
to make fine particles from it to make compost out of the organic garbage.
1
9
[ CRUSHING OF ORGANIC
GARBAGE]
PLASTIC WASTE
MANAGEMENT
20
RECYCLINGOF DRY COCONUT
PLASTIC WASTE
MANAGEMENT
SHELL
• Steps to prepare: Collect coconut husk and store them in a clean place.
• After pulling out fibers, dry them. Then chop or cut them into small pieces with help of a good
pair of scissors or cutters. Grind them in a mixer grinder to a fine powder. The coco fiber will be
separated as fluff. Remove the fibers out of coco peat powder with the help of a sieve
• Manually remove the fibers from atop the sieve. You can use a good stainless steel soil sieve
This resultant peat should be washed with water to remove excess salts Soak the peat in water
for about an hour. Squeeze out excess water with hands.
• Dry it in direct sunlight for a day. Coco peat is ready to be used You can fill it in a planter and
start planting.
2
1
PLASTIC WASTE
22
MANAGEMENT
SURVEYDETAILS[ 16 DEC 2023 TO 18
MAR 2024 ]
PLASTIC WASTE
MANAGEMENT
RDF
SR TOTAL (REFUSE COMPOS COCOPEA
GARBAGE DERIVED T T
(TON) (TON)
FUEL) (TON)
IN TON
23
RDF SALESDETAILS( PER
DAY):
PLASTIC WASTE
MANAGEMENT
RDF
SR TOTAL (REFUSE RATE TOTAL
GARBAGE DERIVED (₹) (₹)
(TON)
FUEL)
IN TON
24
COMPOST SALESDETAILS ( PER
DAY):
PLASTIC WASTE
MANAGEMENT
25
COCOPEAT SALE’ S DETAILS PER
DAY
PLASTIC WASTE
MANAGEMENT
26
THANK YOU